ON SEVERAL OCCASIONS WE TRIED DEPRESSING THE BRAKE PEDAL, TURNING OFF THE CRUISE CONTROL SWITCH, AND FINALLY EVEN TURNING OFF THE IGNITION FOR SEVERAL SECONDS. THE CRUISE CONTROL MAINTAINED THE PRESET SPEED OF 70 MPH. BRAKE PEDAL PRESSURE AND BRAKE EFFECTIVENESS ALLOWED THE CAR TO BE SLOWED AND STOPPED. NO OTHER SYMPTOMS OR I…
Read full complaint
ON SEVERAL OCCASIONS WE TRIED DEPRESSING THE BRAKE PEDAL, TURNING OFF THE CRUISE CONTROL SWITCH, AND FINALLY EVEN TURNING OFF THE IGNITION FOR SEVERAL SECONDS. THE CRUISE CONTROL MAINTAINED THE PRESET SPEED OF 70 MPH. BRAKE PEDAL PRESSURE AND BRAKE EFFECTIVENESS ALLOWED THE CAR TO BE SLOWED AND STOPPED. NO OTHER SYMPTOMS OR INSTANCES HAVE OCCURRED.*AK
NHTSA ODI #746975
Mileage unknown · Mar 7, 2000
Service Brakes, HydraulicSuspension
WHILE DRIVING DOWN THE ROAD, NOTICED A VIBRATION IN THE RIGHT PASSENGER'S SEAT, WHICH FELT AS IF IT WAS COMING FROM ONE OF THE REAR TIRES. CONSUMER IN THE BACK OF THE CAR STARTED SHAKING, SO DID THE SEAT. THEN, STEERING WHELL STARTED SHAKING. IT WAS RAINING, CONSUMER PUT ON BRAKES AND VEHICLE STARTED TO SLIDE OVER TO A DITC…
Read full complaint
WHILE DRIVING DOWN THE ROAD, NOTICED A VIBRATION IN THE RIGHT PASSENGER'S SEAT, WHICH FELT AS IF IT WAS COMING FROM ONE OF THE REAR TIRES. CONSUMER IN THE BACK OF THE CAR STARTED SHAKING, SO DID THE SEAT. THEN, STEERING WHELL STARTED SHAKING. IT WAS RAINING, CONSUMER PUT ON BRAKES AND VEHICLE STARTED TO SLIDE OVER TO A DITCH. CONSUMER DID NOT HIT ANYTHING, MECHANIC ATTEMPTED TO PULL VEHICLE FROM DITCH, AND MECHANIC DAMAGED VEHICLE. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Consequence & remedy
Consequence: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.
THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Consequence & remedy
Consequence: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.
THE DOUBLE-LOCK FEATURE CAN ENGAGE WITH OCCUPANTS AND THE DOOR/IGNITION KEY INSIDE THE VEHICLE.
Consequence & remedy
Consequence: THE OCCUPANTS OF THE VEHICLE WOULD BE UNABLE TO EXIT EITHER FROM THE DOORS OR FROM THE WINDOWS OF THE VEHICLE. DRIVE-AWAY PROTECTION WOULD PREVENT THE ENGINE FROM STARTING.
Remedy: DEALERS WILL REPLACE THE GENERAL CONTROL MODULE WITH ONE CONTAINING THE REVISED SOFTWARE TO PERMIT WINDOW OPENING WITH THE DOUBLE-LOCK ENGAGED AND KEY IN THE IGNITION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1995 BMW 525I Problems, Complaints & Recalls | Skip That Year
Illustration