Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 7 of 7 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
7 reports
94,000 miles · Feb 16, 2016
Electrical SystemExterior Lighting
JUST BOUGHT A USED 2008 528I (E60) W/94K MILES, IN OTHERWISE PERFECT CONDITION. WENT TO CHANGE THE ANGEL EYES FROM DRAB YELLOW TO LUX LED'S. NOTICED BARE WIRES ON BOTH SIDES OF THE BULB CONNECTORS, ON BOTH SIDES OF THE CAR. TRIED TO USE ELECTRICAL TAPE, JUST MADE MORE BARE WIRE. THE MORE I TOUCHED THE WIRES, THE MORE INSULAT…
Read full complaint
JUST BOUGHT A USED 2008 528I (E60) W/94K MILES, IN OTHERWISE PERFECT CONDITION. WENT TO CHANGE THE ANGEL EYES FROM DRAB YELLOW TO LUX LED'S. NOTICED BARE WIRES ON BOTH SIDES OF THE BULB CONNECTORS, ON BOTH SIDES OF THE CAR. TRIED TO USE ELECTRICAL TAPE, JUST MADE MORE BARE WIRE. THE MORE I TOUCHED THE WIRES, THE MORE INSULATION FLAKED OFF, ALMOST LIKE A POWDER. I'VE NEVER SEEN ANYTHING LIKE IT. CAN'T POSSIBLY BE SAFE. DEFINITELY A FIRE HAZARD. NEIGHBOR BROUGHT OVER A BOTTLE OF LIQUID TAPE, AND I RE-COATED ALL THE BARE WIRE I COULD SEE, MAKING SURE EACH WIRE WAS SEPARATED SO A SHORT WOULD NOT OCCUR. THAT IS A GOOD TEMPORARY FIX. WILL HAVE TO STAY ON TOP OF THIS PROBLEM, SINCE MOST, IF NOT ALL, OF THE HEADLIGHT WIRING IS MADE WITH BAD, QUICKLY DEGRADING WIRE INSULATION. A REAL DISAPPOINTMENT IN OTHERWISE GOOD GERMAN QUALITY AND ENGINEERING. I GUESS THE SOURCE PROCURER AT THE FACTORY SAVED BMW SOME BIG BUCKS ON THAT WIRE!! THIS IS DEFINITELY A NHTSA SAFETY RECALL ISSUE. TORT LAWYERS SHOULD HAVE A FIELD DAY ON THIS ONE. PHOTOS OF THIS PROBLEM ARE AVAILABLE AT: HTTP://WWW.BIMMERFORUMS.COM/FORUM/SHOWTHREAD.PHP?2132684-HEADLIGHT-WIRE-JACKETS-JUST-FLAKE-OFF
NHTSA ODI #10836474
48,000 miles · Apr 29, 2015
Electrical System
( I AM THE ORIGINAL OWNER THIS VEHICLE) WHILE REPLACING A BURNT OUT HEADLIGHT, I NOTICED THAT THE INSULATION IN THE SEALED HEADLIGHT WAS MISSING. WHEN I CHECKED THE OPPOSITE SIDE, I FOUND THE SAME THING, THE INSULATION WAS BROKEN AND MISSING. BEING THAT THIS IS A SEALED HEADLIGHT HOUSING, I AM UNABLE TO REMOVE AND REPAIR …
Read full complaint
( I AM THE ORIGINAL OWNER THIS VEHICLE) WHILE REPLACING A BURNT OUT HEADLIGHT, I NOTICED THAT THE INSULATION IN THE SEALED HEADLIGHT WAS MISSING. WHEN I CHECKED THE OPPOSITE SIDE, I FOUND THE SAME THING, THE INSULATION WAS BROKEN AND MISSING. BEING THAT THIS IS A SEALED HEADLIGHT HOUSING, I AM UNABLE TO REMOVE AND REPAIR THE PROBLEM. BMW PARTS STATED THAT THE WIRING HARNESS IS NOT SOLD FOR THOSE LIGHTS. ONE HAS TO PURCHASE A COMPLETELY NEW HEADLIGHT ASSEMBLY AT A AVERAGE COST OF $700.00+. *TR
NHTSA ODI #10713565
79,000 miles · Jan 22, 2015
Electrical SystemSteering
OUR 2007 BMW 530XI DEVELOPED A STEERING WHEEL LOCK MALFUNCTION WARNING. A RED STEERING WHEEL WITH A PADLOCK APPEARS ON THE DASH SCREEN WITH A WARNING ON THE COMPUTER. THE STEERING WHEEL LOCKS AND UNLOCKS PERFECTLY EVERY TIME. THE CAR IS DRIVABLE. THE DEALER SAYS THE STEERING LOCK MODULE MUST BE REPLACED FOR $600. I FOUND TH…
Read full complaint
OUR 2007 BMW 530XI DEVELOPED A STEERING WHEEL LOCK MALFUNCTION WARNING. A RED STEERING WHEEL WITH A PADLOCK APPEARS ON THE DASH SCREEN WITH A WARNING ON THE COMPUTER. THE STEERING WHEEL LOCKS AND UNLOCKS PERFECTLY EVERY TIME. THE CAR IS DRIVABLE. THE DEALER SAYS THE STEERING LOCK MODULE MUST BE REPLACED FOR $600. I FOUND THAT THIS IS A RAMPANT PROBLEM ON BMWS AND THAT BMW CORPORATION IS AWARE OF THE PROBLEM. THERE SHOULD BE A RECALL FOR THIS PROBLEM. *TR
NHTSA ODI #10678436
114,400 miles · Dec 22, 2014
Visibility/wiper
WHILE TRAVELING DOWN THE HIGHWAY, I HEARD A LOUD NOISE - VERY LOUD - ON THE TOP OF MY CAR. IT SOUNDED LIKE SOMETHING FELL OR LANDED ON THE SUNROOF. I SAFELY BROUGHT THE CAR TO A STOP AND THEN SAW THE HUGE HOLE IN MY SUNROOF! *TR
NHTSA ODI #10667819
90,000 miles · Nov 12, 2014
Fuel/propulsion System
GASOLINE IS LEAKING FROM THE FUEL LEVEL SENSOR, WHICH IS ACCESSED BENEATH THE LEFT REAR PASSENGER SEAT, DUE TO A CRACK IN THE PLASTIC HOUSING. MY INDEPENDENT MECHANIC WHO SPECIALIZES IN BMW REPAIR, TELLS ME THIS IS A COMMON PROBLEM WITH BMW AND MERCEDES VEHICLES. *TR
NHTSA ODI #10654546
45,000 miles · Dec 18, 2013
Engine
WATER PUMP FAILURE WITH LESS THAN 50K MILES, REPAIR COST $1200, RIDICULOUS! SEE NHTSA ID NUMBER: 10472497, THIS GENTLEMAN HAD THE SAME COMPLAINT AND JUST LIKE HIM, MY CAR WAS OUT OF WARRANTY BY 1.5 MONTHS. *TR
NHTSA ODI #10556566
64,500 miles · May 24, 2012
Structure
LEFT SIDE OF THE CENTER DASH TRIM CONTINUES TO POP OFF. OCCURS EVERY 4 MONTHS AT $40 A REPAIR. REPAIRED 3 TIMES; ONCE UNDER WARRANTY AND TWICE OUT OF WARRANTY. THE TRIM POPS OUT ON ITS OWN, HOWEVER THE BMW DEALERSHIP CONTINUES TO STATE THAT EXCESSIVE FORCE IS CAUSING THE PROBLEM. THAT IS NOT THE CASE. THIS IS NOT A CHARACTE…
Read full complaint
LEFT SIDE OF THE CENTER DASH TRIM CONTINUES TO POP OFF. OCCURS EVERY 4 MONTHS AT $40 A REPAIR. REPAIRED 3 TIMES; ONCE UNDER WARRANTY AND TWICE OUT OF WARRANTY. THE TRIM POPS OUT ON ITS OWN, HOWEVER THE BMW DEALERSHIP CONTINUES TO STATE THAT EXCESSIVE FORCE IS CAUSING THE PROBLEM. THAT IS NOT THE CASE. THIS IS NOT A CHARACTERISTIC TO EXPECT ON THIS CLASS OF VEHICLE. AN OWNER SHOULD NOT EXPECT TO MAINTAIN THE DASH TRIM. *TR
NHTSA ODI #10459542
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2008 BMW 5-SERIES Problems, Complaints & Recalls | Skip That Year
Illustration