NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
24 reportsClear category filter2,500 miles · Sep 9, 2010
Equipment Adaptive/mobilityFuel System, Gasoline
LONG CRANKS, STUTTERING UPON PUSHING ON THE ACCELERATOR WITH LURCHING SENSATION AND FRONT ENGINE BLOCK SHAKING. IT USED TO OCCUR EVERY DAY BEFORE THEY REPLACED MY FIRST HIGH PRESSURE FUEL PUMP AT 2500 MILES. SECOND TIME I HAD LONG CRANKS A FEW TIMES A WEEK WITH LURCHING/STUTTERING SENSATION UPON PUSHING ON THE ACCELERATOR WHILE…
Read full complaint
LONG CRANKS, STUTTERING UPON PUSHING ON THE ACCELERATOR WITH LURCHING SENSATION AND FRONT ENGINE BLOCK SHAKING. IT USED TO OCCUR EVERY DAY BEFORE THEY REPLACED MY FIRST HIGH PRESSURE FUEL PUMP AT 2500 MILES. SECOND TIME I HAD LONG CRANKS A FEW TIMES A WEEK WITH LURCHING/STUTTERING SENSATION UPON PUSHING ON THE ACCELERATOR WHILE HI-WAY DRIVING EVERY DAY. I HAVE A 2009 BMW 335I . VIN [XXX]. I'VE HAD MY HPFP REPLACED ONCE. THE SECOND TIME AROUND THEY JUST REPROGRAMMED THE HPFP BUT I STILL GET LONG CRANKS 2 A WEEK WITH LURCHING/STUTTERING ON HI-WAY ACCELERATION ATTEMPTS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
NHTSA ODI #10354696
15,500 miles · Aug 25, 2010
Fuel System, Gasoline
THE CAR'S HIGH PRESSURE FUEL PUMP FAILED ON FREEWAY ON-RAMP ACCELERATION LEADING TO A NEAR REAR-END COLLISION BY A FOLLOWING CAR. THIS FAILURE WAS PRECEDED BY LONG-CRANK STARTING AND ENGINE RACING ON STARTING. THE HPFP WAS REPLACED AT 6,000 MILES (10/09). AT 12,000 MILES THE SOFTWARE WAS REPROGRAMMED. (6/10) THE DEALER SAYS …
Read full complaint
THE CAR'S HIGH PRESSURE FUEL PUMP FAILED ON FREEWAY ON-RAMP ACCELERATION LEADING TO A NEAR REAR-END COLLISION BY A FOLLOWING CAR. THIS FAILURE WAS PRECEDED BY LONG-CRANK STARTING AND ENGINE RACING ON STARTING. THE HPFP WAS REPLACED AT 6,000 MILES (10/09). AT 12,000 MILES THE SOFTWARE WAS REPROGRAMMED. (6/10) THE DEALER SAYS IT IS REPLACING THE HPFP AGAIN. THIS APPEARS TO BE AN ONGOING PROBLEM WITH THE BMW 335I ENGINE STARTING WITH THE 2007 MODELS AS REPORTED ON THIS WEBSITE. ACCORDING TO A SURVEY OF 300+ OWNERS NEARLY 50% HAVE EXPERIENCED THIS PROBLEM. *TR
NHTSA ODI #10351761
4,800 miles · Aug 4, 2010
Fuel System, Gasoline
VEHICLE HAD APROX, 3,400 MILES AND BEGAN TO EXPERIENCE LONG CRANKS DURING START UP. FOR ABOUT 1 MONTH I EXPERIENCED INTERMITTENT LONG CRANKS BUT THE VEHICLE PERFORMED NORMALLY. WITH 4,800 MILES ON THE VEHICLE I WAS DRIVING ON A HIGHWAY ATTEMPTING TO PASS A VEHICLE IN RIGHT LANE AND THE VEHICLE SPUTTERED AND A REDUCED POWER IND…
Read full complaint
VEHICLE HAD APROX, 3,400 MILES AND BEGAN TO EXPERIENCE LONG CRANKS DURING START UP. FOR ABOUT 1 MONTH I EXPERIENCED INTERMITTENT LONG CRANKS BUT THE VEHICLE PERFORMED NORMALLY. WITH 4,800 MILES ON THE VEHICLE I WAS DRIVING ON A HIGHWAY ATTEMPTING TO PASS A VEHICLE IN RIGHT LANE AND THE VEHICLE SPUTTERED AND A REDUCED POWER INDICATOR SHOWED ON DASH. I WAS ABLE TO LIMP THE VEHICLE TO DEALERSHIP, STALLED ONCE DURING TRIP TO DEALER. DEALERSHIP DIAGNOSED BAD HIGH PRESSURE FUEL PUMP AND REPLACED SAME DAY. *TR
NHTSA ODI #10347175
14,000 miles · Jul 30, 2010
Fuel System, Gasoline
THE CAR IS A 2009 BMW 335I . ABOUT 23 WEEKS AGO, THE CAR LOST POWER. FORTUNATELY, THERE WAS NOT A ACCIDENT. WHEN THE CAR WENT INTO THE DEALER, I WAS TOLD THAT IT WAS A FUEL PUMP PROBLEM AND THE CHANGED THE PUMP. *TR
NHTSA ODI #10346378
9,000 miles · Jul 27, 2010
Fuel System, Gasoline
FAILURE OF HIGH PRESSURE FUEL PUMP WITH RESULTING LOSS OF POWER AND DRIVABLE. FAILURE HAS OCCURRED ONCE SO FAR AT 10 MONTHS OF OWNERSHIP AND APPROXIMATELY 9000 MILES. INITIAL REPAIR WAS A SOFTWARE UPDATE. THIS REPAIR WAS OF NO BENEFIT AND SHORTLY THEREAFTER THE CAR WAS RETURNED TO THE DEALER AND THE HPFP WAS REPLACED WITH A R…
Read full complaint
FAILURE OF HIGH PRESSURE FUEL PUMP WITH RESULTING LOSS OF POWER AND DRIVABLE. FAILURE HAS OCCURRED ONCE SO FAR AT 10 MONTHS OF OWNERSHIP AND APPROXIMATELY 9000 MILES. INITIAL REPAIR WAS A SOFTWARE UPDATE. THIS REPAIR WAS OF NO BENEFIT AND SHORTLY THEREAFTER THE CAR WAS RETURNED TO THE DEALER AND THE HPFP WAS REPLACED WITH A REMANUFACTURED HPFP. *TR
NHTSA ODI #10345678
24,000 miles · Jul 27, 2010
Fuel System, Gasoline
THE FUEL PUMP ON MY 2009 BMW 335I HAS FAILED AND I BELIEVE IT'S STARTING TO FAIL AGAIN BUT EVERYTIME I TAKE IT IN THEY SAY IT'S FINE AND THEY CANT DO ANYTHING UNTIL IT ACTUALLY FAILS. PROBLEM WITH THAT IS IF IT FAILS ON THE HIGHWAY DOING 70MPH THEN I'M GOING TO BE IN A WORLD OF HURT. THE PUMP HAS ALREADY FAILED ONCE. *TR
NHTSA ODI #10345597
4,500 miles · Jul 24, 2010
Fuel System, Gasoline
I OWN A 2009 BMW 335. IT WAS PURCHASED IN EARLY 2009. PRIOR TO THE FAILURE OF THE PART, THERE WAS NO SIGN OF TROUBLE. WHILE I WAS DRIVING ON THE FREEWAY IN SOUTHERN CALIFORNIA, MY CAR STARTED TO LOSE POWER. CONCURRENT WITH THAT POWER LOSS, THE "SERVICE ENGINE SOON" LIGHT APPEARED ON MY INSTRUMENT CLUSTER. ADDITIONALLY, AN…
Read full complaint
I OWN A 2009 BMW 335. IT WAS PURCHASED IN EARLY 2009. PRIOR TO THE FAILURE OF THE PART, THERE WAS NO SIGN OF TROUBLE. WHILE I WAS DRIVING ON THE FREEWAY IN SOUTHERN CALIFORNIA, MY CAR STARTED TO LOSE POWER. CONCURRENT WITH THAT POWER LOSS, THE "SERVICE ENGINE SOON" LIGHT APPEARED ON MY INSTRUMENT CLUSTER. ADDITIONALLY, AN ICON (IT LOOKED LIKE A TRANSMISSION) LIT UP AS WELL. WHEN THE POWER LOSS FIRST OCCURRED, I WAS IN THE FAST LANE ON THE FREEWAY. I HAD TO WORK EXTREMELY QUICK TO GET TO THE OTHER SIDE OF THE FREEWAY, FOR FEAR THAT SOMEONE WOULD HIT ME FROM BEHIND (AS MY CAR SLOWED DOWN). I EVENTUALLY MADE IT TO THE OTHER SIDE OF THE FREEWAY WITHOUT INCIDENT. I PULLED OFF TO THE SIDE OF THE ROAD AND TURNED THE CAR OFF. I EVENTUALLY CALLED A TOW TRUCK AND HAD MY CAR TOWED TO THE NEAREST BMW DEALERSHIP. TURNS OUT THAT MY HIGH-PRESSURE FUEL PUMP FAILED. I DID NOT HAVE ANY WARNING PRIOR TO THE FAILURE. THE DEALERSHIP REPLACED THE HIGH-PRESSURE FUEL PUMP. SINCE THEN, I HAVE PUT 5500 MILES ON THE CAR. MY FUEL PUMP IS STILL WORKING PROPERLY. *TR
NHTSA ODI #10345026
10,825 miles · Jul 15, 2010
Fuel System, Gasoline
I WAS DRIVING UPHILL LAST NIGHT AND AN ENGINE LIGHT CAME ON AND THE NAVIGATION SCREEN SAID REDUCED POWER. I HAD TO SHIFT DOWN INTO THIRD GEAR AND PUT MY FOOT TO THE FLOOR AND THE CAR HARDLY KEPT GOING UP THE HILL. I TURNED IT OFF AND THEN ON AGAIN AND ALL SEEMED FINE. ON THE WAY HOME THE SAME LIGHTS CAME ON BUT THEN THE SERVI…
Read full complaint
I WAS DRIVING UPHILL LAST NIGHT AND AN ENGINE LIGHT CAME ON AND THE NAVIGATION SCREEN SAID REDUCED POWER. I HAD TO SHIFT DOWN INTO THIRD GEAR AND PUT MY FOOT TO THE FLOOR AND THE CAR HARDLY KEPT GOING UP THE HILL. I TURNED IT OFF AND THEN ON AGAIN AND ALL SEEMED FINE. ON THE WAY HOME THE SAME LIGHTS CAME ON BUT THEN THE SERVICE ENGINE SOON LIGHT CAME ON AND BEGAN FLASHING AND THE CAR BEGAN SHAKING AND IDLING VERY ROUGH. THE CAR WAS VERY HARD TO DRIVE AND HAD ALMOST NO POWER WHATSOEVER. PROBLEM OCCURRED AGAIN THIS MORNING AND THE CAR WAS TAKEN TO THE DEALERSHIP ON A FLAT BED. THIS WOULD BE EXTREMELY DANGEROUS IF IT HAPPENED AT HIGHWAY SPEEDS OR ON AN OPEN STRETCH OF HIGHWAY WITH LITTLE ACCESS TO SERVICES AND/OR REPAIR FACILITIES. THE DEALERSHIP SAYS IT IS THE HIGH PRESSURE FUEL PUMP. *TR
NHTSA ODI #10343531
4,315 miles · Jul 15, 2010
Fuel System, Gasoline
FUEL PUMP FAILURE WHILE DRIVING ON THE HIGHWAY AT 65MPH. COMPLETE LOSS OF POWER AND ENGINE. *TR
NHTSA ODI #10343401
8,000 miles · Jun 20, 2010
Fuel System, Gasoline
2009 BMW 335I HIGH PRESSURE FUEL PUMP FAILED ON MAY 30TH. I WAS ABLE TO DRIVE THE CAR HOME WITH REDUCED POWER. I SUBSEQUENTLY BROUGHT THE CAR TO MOUNTAIN VIEW BMW ON JUNE 10TH. NEW FUEL PUMP WAS INSTALLED WITH SOFTWARE UPDATE. *TR
NHTSA ODI #10339202
Official recalls
4Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Feb 7, 2013
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration