2008 BMW 335I

THE HIGH PRESSURE FUEL PUMP WHICH WAS RECALLED AND REPLACED IN 2011 IS PROBLEMATIC AGAIN. WHEN PUSHING THE GAS PEDAL HARDER, THE CAR STUTTERS AND DOES NOT RESPOND TO THE EXTRA POWER REQUESTED BY FLOORING THE GAS PEDAL AND MAKES PUT ME IN A DANGEROUS SITUATION. THE 'SERVICE ENGINE SOON' LIGHT CAME UP AS WELL. I PULLED THE CAR OVER WHEN I COULD, STOPPED AND STARTED THE ENGINE AGAIN AND THE "SERVICE ENGINE" LIGHT DISAPPEARED. THIS IS THE SAME ISSUE BACK IN 2011 AND RECURRING AGAIN. I SUSPECT THIS HAS BEEN THERE FOR A LONG TIME, BUT AS MY WIFE DOES NOT PUNCH THE GAS AS HARD AS ME, SHE NOTICED THIS ONLY ON FEW OCCASIONS. I NOTICED THIS TWICE IN THE LAST MONTH AND SO, CALLED THE STEALERSHIP AND LOGGING A COMPLAINT HERE. IN 2011, THEY SAID BMW EXTENDED THE WARRANTY TO 10 YEARS AND SO, THIS SHOULD BE COVERED NOW AS WELL, BUT THE STEALERSHIP ABVIOUSLY WOULD NOT ACKNOWLEDGE. HOPE OUR GREAT PRESIDENT TRUMP SHOW GERMANY THEIR PLACE, AND HOPE BMW PAYS FOR THE TERRIBLE ENGINEERING TILL ELON MUSK MAKES THEM GO BANKRUPT.

HIGH PRESSURE FUEL PUMP FAILURE COULD BE THE LOW PRESSURE FUEL PUMP NOT SO SURE GOT CODES P3090 CONFIRMED AND P142E PENDING. THE CAR WAS IN MOTION WHEN DOING A TURN THE VEHICLE STARTED TO BOG OUT AND ROUGHLY IDLE I IMMEDIATELY TURNED TO THE RIGHT AND SHUT THE VEHICLE OFF TRIED TO START IT ABOUT THREE TIMES IN ONE MINUTE INTERVALS CAR WOULD BOG OUT AND SHUT OFF THREW ME THOSE TWO CODES AND A CHECK ENGINE LIGHT.

WENT TO REPLACE AN OBVIOUSLY BURNED OUT BRAND NEW XENON HID BALLAST. CONFUSED ABOUT WHY IT BURNED UP(FAILURE RATE OF 1 PER 1,000 QUOTED BY THE MANUFACTURER) I TOOK OFF THE BACK COVER FOR THE HOUSING. TO MY SURPRISE, THE POWER CABLE'S THAT PLUGS INTO THE HID BALLAST INSULATION WAS COMPLETELY GONE. BARE. WIRES. THIS IS OBVIOUSLY AN EXTREME FIRE AND SAFETY HAZARD. CURIOUS IF MY OTHER HEADLIGHT WIRING WAS THE SAME WAY, I POPPED THE BACK HOUSING OF IT TO INSPECT FOR ANOTHER HAZARD. LORD AND BEHOLD, IT WAS EXACTLY THE SAME WAY. NOT JUST THE POWER SUPPLY INSULATION ON THE WIRES FOR THE BALLAST WAS CHIPPING, ALL OF IT WAS CHIPPING. THE DRL, ANGEL EYE AND TURN MAKER WIRING INSULATION WAS ALL..GONE. SOMEONE HAD RECENTLY DISCOVERED THIS ISSUE BEFOREHAND AS THERE WAS ELECTRICAL TAPE & SOLDER ON SOME OF THE WIRES KEEPING THEM TOGETHER. ---------------------------- THIS IS A FIRE HAZARD! ----------------------------

VEHICLE OVERHEATED DURING HIGH SPEED DRIVING AND BEGAN RAPIDLY SLOWING FORCING AN EMERGENCY EXIT FROM THE HIGHWAY. FORTUNATELY I WAS NEAR AN EXIT. BMW DEALERSHIP REPLACED THE WATER PUMP BUT PERSON AT THE DEALERSHIP EXPLAINED THAT THE WATER PUMP WAS PROBABLY BLOWN AS A RESULT OF THE FAILURE OF THE "IBS" CABLE. DEALER HAD TO REPLACE THE "NEGATIVE IBS CABLE." THEREFORE, IT APPEARS THAT FAILURE OF THIS CABLE WILL REQUIRE EMERGENCY STOPPING OR EMERGY HANDLING AT ANY SPEED. THE HIGHWAY SPEED I WAS TRAVELING MADE THIS PARTICULARLY DANGEROUS. I HAVE THE REPAIR INVOICE SHOWING THE REQUIRED REPLACEMENT OF THE NEGATIVE IBS CABLE.

TL* THE CONTACT OWNED A 2008 BMW 335I. WHILE THE VEHICLE WAS PARKED AND OCCUPIED, THE CONTACT NOTICED SMOKE COMING FROM THE DASHBOARD AND THROUGH THE AIR VENTS IN THE VEHICLE. THE CONTACT AND HIS FAMILY WERE ABLE TO EXIT THE VEHICLE WITHOUT INJURIES. THE VEHICLE BURST INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO A TOW LOT. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS DESTROYED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V676000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

TL* THE CONTACT OWNED A 2008 BMW 335I. WHILE WALKING TO THE PARKED VEHICLE, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD OF THE VEHICLE. THE CONTACT OPENED THE DOOR AND SAW FLAMES COMING FROM THE FLOORBOARD. THE CONTACT EXTINGUISHED THE FIRE WITH A FIRE EXTINGUISHER. THE CONTACT STATED THAT THE BLOWER MOTOR CAUGHT ON FIRE AND MELTED THROUGH THE DASHBOARD AND GLOVE BOX. THE DEALER (HANSEL BMW OF SANTA ROSA, 2925 CORBY AVE, SANTA ROSA, CA 95407) STATED THAT THEY HAD TO WAIT TO HEAR FROM THE MANUFACTURER BEFORE THEY COULD MAKE ANY DECISIONS ON HOW TO HANDLE THE FAILURE. THEY ALSO DIRECTED THE CONTACT NOT TO TOUCH ANYTHING IN THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY NEVER HEARD OF THE BLOWER MOTOR CATCHING ON FIRE. THE VEHICLE WAS DESTROYED. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V670000 (ENGINE AND ENGINE COOLING). THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 2008 BMW 335I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V676000 (ELECTRICAL SYSTEM). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED FLOW BMW (2565 PETERS CREEK PKWY, WINSTON SALEM, NC 27127, (888) 896-2985) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE SUPPLY OF PARTS WERE SCHEDULED TO ARRIVE IN THIRTY DAYS. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2008 BMW 335I. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V676000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. BMW OF MACON (LOCATED AT 4785 RIVERSIDE DR, MACON, GA 31210, (866) 980-4231) WAS CONTACTED AND CONFIRMED THAT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2008 BMW 335I. WHILE DRIVING 5 MPH, THE RPMS FLUCTUATED WITHOUT WARNING. THE CONTACT CALLED BMW OF TYLER AT (903) 229-4409 (LOCATED AT 2401 W SW LOOP 323, TYLER, TX 75701) AND WAS INFORMED TO FILE A COMPLAINT WITH THE SERVICE MANAGER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 19,051.