IllustrationFUEL PUMP FAILURE. *TR
2007 BMW 335I
Owner reports · Recalls · Investigations
More warning signs than most 335I years
Owner complaints for the 2007 BMW 335I are substantially higher than the model-year median of 31.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all 335I years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
780–25K
4525–50K
5450–75K
2175–100K
27100–150K
11150K+
236 reports with mileage · 52 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports9 fire reports2 injury reports
What owners actually said
288 reportsENTERING A FREEWAY ON RAMP DURING A TURN, THE CAR'S FUEL SYSTEM FAILED AND CAUSED THE CAR TO 'SHUTTER' (SAME FEELING AS SOMEONE WHO DOES NOT KNOW HOW TO DRIVE A STICK SHIFT). THIS CAUSED THE CAR TO LOSE CONTROL AND FLIP OVER AFTER HITTING A DITCH. THE CAR HAS ALREADY HAD TWO FUEL PUMPS REPLACED AND BMW KNOWS ABOUT THIS PROBLEM. …
Read full complaint
ENTERING A FREEWAY ON RAMP DURING A TURN, THE CAR'S FUEL SYSTEM FAILED AND CAUSED THE CAR TO 'SHUTTER' (SAME FEELING AS SOMEONE WHO DOES NOT KNOW HOW TO DRIVE A STICK SHIFT). THIS CAUSED THE CAR TO LOSE CONTROL AND FLIP OVER AFTER HITTING A DITCH. THE CAR HAS ALREADY HAD TWO FUEL PUMPS REPLACED AND BMW KNOWS ABOUT THIS PROBLEM. SO FAR, BMW DOES NOT WANT TO TAKE RESPONSIBILITY FOR THEIR INABILITY TO FIX THIS KNOWN 335I PROBLEM. THERE ARE ALREADY 11 COMPLAINTS (NOT INCLUDING THIS ONE) REGARDING THE ISSUE ON THIS WEBSITE. BMW ASSIST ALSO FAILED IN THE CRASH AS IT DID NOT CONTACT BMW ASSIST CALL CENTER AFTER THE CRASH. *TR
THE HIGH PRESSURE FUEL PUMP MALFUNCTIONED WHILE MERGING INTO TRAFFIC ON A FREEWAY ON-RAMP, RESULTING IN A NEAR REAR- END COLLISION AS THE VEHICLE SUDDENLY SLOWED DUE TO THE MALFUNCTION. THIS IS A WELL KNOWN DEFECT IN THIS VEHICLE FOR WHICH PRODUCTION CONTINUED, KNOWING FULL WELL THE POTENTIAL FOR EVENTUAL MALFUNCTION, WITHOUT D…
Read full complaint
THE HIGH PRESSURE FUEL PUMP MALFUNCTIONED WHILE MERGING INTO TRAFFIC ON A FREEWAY ON-RAMP, RESULTING IN A NEAR REAR- END COLLISION AS THE VEHICLE SUDDENLY SLOWED DUE TO THE MALFUNCTION. THIS IS A WELL KNOWN DEFECT IN THIS VEHICLE FOR WHICH PRODUCTION CONTINUED, KNOWING FULL WELL THE POTENTIAL FOR EVENTUAL MALFUNCTION, WITHOUT DISCLOSURE TO THE PURCHASER. *TR
FAILED FUEL PUMP, (TWICE NOW) ONCE AT 8,000 MILES, AND NOW AGAIN AT 23,000 MILES. I BOUGHT THIS VEHICLE NEW. IT'S A 2007 BMW 335I. *TR
TL*THE CONTACT OWNS A 2007 BMW 335I. THE CONTACT STATED THAT THE PASSENGER DOOR LOCKING MECHANISM FUSES BLOW OUT DUE TO ELECTRICAL FAILURE. WHEN THE FUSES BLOW, THE VEHICLE LOCKS COMPLETELY AND THE PASSENGER CANNOT EXIT THE VEHICLE. THE UNIT WAS REPLACED AND WORKED FOR A SHORT PERIOD OF TIME BEFORE THE FAILURE RECURRED. THE …
Read full complaint
TL*THE CONTACT OWNS A 2007 BMW 335I. THE CONTACT STATED THAT THE PASSENGER DOOR LOCKING MECHANISM FUSES BLOW OUT DUE TO ELECTRICAL FAILURE. WHEN THE FUSES BLOW, THE VEHICLE LOCKS COMPLETELY AND THE PASSENGER CANNOT EXIT THE VEHICLE. THE UNIT WAS REPLACED AND WORKED FOR A SHORT PERIOD OF TIME BEFORE THE FAILURE RECURRED. THE FAILURE HAS OCCURRED THREE TIMES AND STILL PERSISTS. THE MANUFACTURER HAS NOT YET BEEN NOTIFIED. THE FAILURE MILEAGE WAS 18,000 AND CURRENT MILEAGE WAS 24,000. UPDATED 02-14-08 *BF
2 FUEL PUMP FAILURES RESULTING IN OVER ONE MONTH WITHOUT VEHICLE. *TR
I JUST BOUGHT A BMW 335 IN DECEMBER 2006, LESS THAN 7,000 MILES AND WHILE DRIVING IN THE HIGHWAY THE MALFUNCTION ENGINE LIGHT TURNED ON. THE CAR STARTED TO IDLE AND THERE WAS ALMOST COMPLETE LOSS OF POWER. WHEN I TRIED TO TAKE THE CAR TO SERVICE THEY INITIALLY REFUSED TO TAKE THE CAR BECAUSE I HAD NOT MADE AN APPOINTMENT. SUCH A…
Read full complaint
I JUST BOUGHT A BMW 335 IN DECEMBER 2006, LESS THAN 7,000 MILES AND WHILE DRIVING IN THE HIGHWAY THE MALFUNCTION ENGINE LIGHT TURNED ON. THE CAR STARTED TO IDLE AND THERE WAS ALMOST COMPLETE LOSS OF POWER. WHEN I TRIED TO TAKE THE CAR TO SERVICE THEY INITIALLY REFUSED TO TAKE THE CAR BECAUSE I HAD NOT MADE AN APPOINTMENT. SUCH AN EXPENSIVE CAR AND ITS FALLING APART JUST A FEW MILES AFTER. FINALLY THEY LOOK INTO THE PROBLEM AND IT SEEMS TO BE THE HIGH PRESSURE GASOLINE PUMP. I'VE READ ONLINE THAT SEVERAL PEOPLE HAVE HAD THIS PROBLEM BUT STILL BMW REFUSES TO ACKNOWLEDGE IT. *TR
BMW 335 WINDSHIELD USES DEFECTIVE GLASS. *TR
MY NEW BMW 335I SEDAN STARTED LOSING POWER AND EVENTUALLY VIBRATED TO A HALT. FUEL PUMP FAILURE. DEALER HAD MEMO ON DCS BUT FAILED TO ACKNOWLEDGE SO. *JB
I OWN A 2007 BMW 335I COUPE. AT 9,000 MILES I STARTED NOTICING A STRANGE SOUND COMING FORM THE TIRE AREA. IT GRADUALLY GOT WORSE. AT 10,000 MILES I NOTICED PHYSICAL SIGNS OF "SCALLOPING" AND ACTUAL UNEVEN (QUITE DRAMATICALLY UNEVEN) WEAR. IT LOOKED AS THOUGH THE LEADING EDGES OF SOME, JUST SOME, TREADS WERE ACTUALLY AS MUCH OF A…
Read full complaint
I OWN A 2007 BMW 335I COUPE. AT 9,000 MILES I STARTED NOTICING A STRANGE SOUND COMING FORM THE TIRE AREA. IT GRADUALLY GOT WORSE. AT 10,000 MILES I NOTICED PHYSICAL SIGNS OF "SCALLOPING" AND ACTUAL UNEVEN (QUITE DRAMATICALLY UNEVEN) WEAR. IT LOOKED AS THOUGH THE LEADING EDGES OF SOME, JUST SOME, TREADS WERE ACTUALLY AS MUCH OF A QUARTER IN LOWER THAN THE BACK SIDE OF THE SAME TREAD AND OF COURSE THE BACK SIDE OF THE TREAD IT WAS ADJACENT TO. IT ALMOST LOOKS LIKE RUBBER HAS LITERALLY BEEN THROWN OFF THE TIRE. THAT'S HOW BIG THE DIFFERENCE IN HEIGHTS IS OF THE RANDOM TREADS. THIS WAS TRUE ON BOTH THE INNER AND OUTER EDGES OF THE TIRES AND EVEN THE MIDDLE. THIS WOULD EXPLAIN THE THRUMMING NOISE. I MADE AN APPOINTMENT TO GET IT INTO THE DEALER AND WITHOUT EVEN LOOKING AT THE TIRES THE SERVICE MANAGER SAID, "BRIDGESTONE WILL REPLACE THE TIRES UP TO 20,000 MILES AND PAY HALF THE COST". I SAID THAT THESE TIRES WEREN'T WORN OUT, THEY WERE WEARING EXTREMELY UNEVENLY. CUPPING AND SCALLOPING LIKE I HAVE NEVER SEEN. HE SAID IT WAS THE DESIGN OF THE CARS, THAT BMW MAKES THEM VERY AGGRESSIVELY TO HANDLE THE WAY THEY DO AND ANY TIRE WOULD DO THAT. I ASKED IF I COULD GET THEM REPLACED WITH CONTINENTALS SINCE I HAVE HEARD THEY HAD LESS PROBLEMS WITH THOSE. HE SAID NO, ONLY WHAT WAS ON THERE AS BMW WASN'T WARRANTING THE TIRES, BRIDGESTONE WAS. THEY DIDN'T OFFER TO ROTATE THEM, LOOK AT THE ALIGNMENT, NOTHING, JUST REPLACE AT HALF COST. SO 9 MONTHS AND NOW 11,000 MILES INTO A $50K CAR I AM FORCED TO PAY ABOUT $5-600 DOLLARS JUST SO I CAN TALK TO MY PASSENGERS AND BE HEARD OVER THE TIRE NOISE. I REALLY FEEL THAT THIS IS A HUGE SAFETY ISSUE AS ONLY PART OF THE TIRE IS IN CONTACT WITH ROAD AT ANY TIME. *TR
Official recalls
524V513000 · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module
Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
20V017000 · Air Bags:frontal:driver Side:inflator Module
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
17V676000 · Electrical System:wiring
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
13V564000 · Air Bags:sensor:occupant Classification
Nov 12, 2013
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
13V044000 · Electrical System; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:wiring:fuses And Circuit Breakers
Feb 7, 2013
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08032 · Engine Stalling - Fuel Pump Failure
Opened Apr 28, 2008 · Closed Aug 15, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump
IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PE08-032 BMW STATED THAT DURING FAILURE OF THE HIGH PRESSURE PUMP THE CUSTOMER SHOULD INITIALLY EXPERIENCE LONGER ENGINE STARTING TIMES OR ROUGH ENGINE RUNNING.AFTER A DISTANCE OF APPROXIMATELY 1 TO 2 MILES THE PUMP- AND ENGINE-EMERGENCY OPERATION PROGRAM IS ACTIVATED, AND THE MALFUNCTION INDICATOR LAMP IS ILLUMINATED.DESPITE REDUCED ENGINE POWER BMW BELIEVES THAT SAFE VEHICLE OPERATION IS POSSIBLE AND THAT VEHICLE DRIVEABILITY, STEERING, AND BRAKING SYSTEMS ARE NOT AFFECTED AND FUNCTION IN A NORMAL MANNER.BMW INDICATED THAT ONLY IN VERY RARE CASES COULD THE ENGINE STALL. ODI'S ANALYSIS OF WARRANTY DATA CLAIMS INDICATING POSSIBLE STALL INCIDENTS ESTIMATES THAT THE RATE AT THREE YEARS IN SERVICE WOULD BE LESS THAN 1.0% OF THE POPULATION (NOTE THAT SOME OF THE CLAIMS INDICATING STALL DO NOT APPEAR TO INVOLVE ACTUAL ENGINE STALLS, BUT RATHER OPERATION AT REDUCED ENGINE POWER).ODI'S ANALYSIS OF CONSUMER COMPLAINTS DETERMINED THAT ABOUT HALF DESCRIBE THE CONSEQUENCE OF THE FAILURE AS OPERATION IN LIMP MODE, 27 PERCENT INDICATE THE PROBLEM RESULTED IN A HARD START OR NO START CONDITION AND 19 PERCENT STATE THAT THE PROBLEM WAS DETECTED BY ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP OR A MINOR DRIVEABILITY SYMPTOM. ONLY FOUR PERCENT OF THE COMPLAINTS TO ODI AND BMW INDICATE THAT AN ENGINE STALL OCCURRED.BMW INDICATED THAT A SERVICE ACTION WAS INITIATED IN APRIL 2008 TO ADDRESS THE PROBLEM AND IT IS CONTINUING TO MONITOR THE FIELD SITUATION AND ANALYZE FIELD DATA. FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (3)
Fuel System, Gasoline
IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PE08-032 BMW STATED THAT DURING FAILURE OF THE HIGH PRESSURE PUMP THE CUSTOMER SHOULD INITIALLY EXPERIENCE LONGER ENGINE STARTING TIMES OR ROUGH ENGINE RUNNING.AFTER A DISTANCE OF APPROXIMATELY 1 TO 2 MILES THE PUMP- AND ENGINE-EMERGENCY OPERATION PROGRAM IS ACTIVATED, AND THE MALFUNCTION INDICATOR LAMP IS ILLUMINATED.DESPITE REDUCED ENGINE POWER BMW BELIEVES THAT SAFE VEHICLE OPERATION IS POSSIBLE AND THAT VEHICLE DRIVEABILITY, STEERING, AND BRAKING SYSTEMS ARE NOT AFFECTED AND FUNCTION IN A NORMAL MANNER.BMW INDICATED THAT ONLY IN VERY RARE CASES COULD THE ENGINE STALL. ODI'S ANALYSIS OF WARRANTY DATA CLAIMS INDICATING POSSIBLE STALL INCIDENTS ESTIMATES THAT THE RATE AT THREE YEARS IN SERVICE WOULD BE LESS THAN 1.0% OF THE POPULATION (NOTE THAT SOME OF THE CLAIMS INDICATING STALL DO NOT APPEAR TO INVOLVE ACTUAL ENGINE STALLS, BUT RATHER OPERATION AT REDUCED ENGINE POWER).ODI'S ANALYSIS OF CONSUMER COMPLAINTS DETERMINED THAT ABOUT HALF DESCRIBE THE CONSEQUENCE OF THE FAILURE AS OPERATION IN LIMP MODE, 27 PERCENT INDICATE THE PROBLEM RESULTED IN A HARD START OR NO START CONDITION AND 19 PERCENT STATE THAT THE PROBLEM WAS DETECTED BY ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP OR A MINOR DRIVEABILITY SYMPTOM. ONLY FOUR PERCENT OF THE COMPLAINTS TO ODI AND BMW INDICATE THAT AN ENGINE STALL OCCURRED.BMW INDICATED THAT A SERVICE ACTION WAS INITIATED IN APRIL 2008 TO ADDRESS THE PROBLEM AND IT IS CONTINUING TO MONITOR THE FIELD SITUATION AND ANALYZE FIELD DATA. FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline:delivery
IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PE08-032 BMW STATED THAT DURING FAILURE OF THE HIGH PRESSURE PUMP THE CUSTOMER SHOULD INITIALLY EXPERIENCE LONGER ENGINE STARTING TIMES OR ROUGH ENGINE RUNNING.AFTER A DISTANCE OF APPROXIMATELY 1 TO 2 MILES THE PUMP- AND ENGINE-EMERGENCY OPERATION PROGRAM IS ACTIVATED, AND THE MALFUNCTION INDICATOR LAMP IS ILLUMINATED.DESPITE REDUCED ENGINE POWER BMW BELIEVES THAT SAFE VEHICLE OPERATION IS POSSIBLE AND THAT VEHICLE DRIVEABILITY, STEERING, AND BRAKING SYSTEMS ARE NOT AFFECTED AND FUNCTION IN A NORMAL MANNER.BMW INDICATED THAT ONLY IN VERY RARE CASES COULD THE ENGINE STALL. ODI'S ANALYSIS OF WARRANTY DATA CLAIMS INDICATING POSSIBLE STALL INCIDENTS ESTIMATES THAT THE RATE AT THREE YEARS IN SERVICE WOULD BE LESS THAN 1.0% OF THE POPULATION (NOTE THAT SOME OF THE CLAIMS INDICATING STALL DO NOT APPEAR TO INVOLVE ACTUAL ENGINE STALLS, BUT RATHER OPERATION AT REDUCED ENGINE POWER).ODI'S ANALYSIS OF CONSUMER COMPLAINTS DETERMINED THAT ABOUT HALF DESCRIBE THE CONSEQUENCE OF THE FAILURE AS OPERATION IN LIMP MODE, 27 PERCENT INDICATE THE PROBLEM RESULTED IN A HARD START OR NO START CONDITION AND 19 PERCENT STATE THAT THE PROBLEM WAS DETECTED BY ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP OR A MINOR DRIVEABILITY SYMPTOM. ONLY FOUR PERCENT OF THE COMPLAINTS TO ODI AND BMW INDICATE THAT AN ENGINE STALL OCCURRED.BMW INDICATED THAT A SERVICE ACTION WAS INITIATED IN APRIL 2008 TO ADDRESS THE PROBLEM AND IT IS CONTINUING TO MONITOR THE FIELD SITUATION AND ANALYZE FIELD DATA. FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline:delivery:fuel Pump
IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PE08-032 BMW STATED THAT DURING FAILURE OF THE HIGH PRESSURE PUMP THE CUSTOMER SHOULD INITIALLY EXPERIENCE LONGER ENGINE STARTING TIMES OR ROUGH ENGINE RUNNING.AFTER A DISTANCE OF APPROXIMATELY 1 TO 2 MILES THE PUMP- AND ENGINE-EMERGENCY OPERATION PROGRAM IS ACTIVATED, AND THE MALFUNCTION INDICATOR LAMP IS ILLUMINATED.DESPITE REDUCED ENGINE POWER BMW BELIEVES THAT SAFE VEHICLE OPERATION IS POSSIBLE AND THAT VEHICLE DRIVEABILITY, STEERING, AND BRAKING SYSTEMS ARE NOT AFFECTED AND FUNCTION IN A NORMAL MANNER.BMW INDICATED THAT ONLY IN VERY RARE CASES COULD THE ENGINE STALL. ODI'S ANALYSIS OF WARRANTY DATA CLAIMS INDICATING POSSIBLE STALL INCIDENTS ESTIMATES THAT THE RATE AT THREE YEARS IN SERVICE WOULD BE LESS THAN 1.0% OF THE POPULATION (NOTE THAT SOME OF THE CLAIMS INDICATING STALL DO NOT APPEAR TO INVOLVE ACTUAL ENGINE STALLS, BUT RATHER OPERATION AT REDUCED ENGINE POWER).ODI'S ANALYSIS OF CONSUMER COMPLAINTS DETERMINED THAT ABOUT HALF DESCRIBE THE CONSEQUENCE OF THE FAILURE AS OPERATION IN LIMP MODE, 27 PERCENT INDICATE THE PROBLEM RESULTED IN A HARD START OR NO START CONDITION AND 19 PERCENT STATE THAT THE PROBLEM WAS DETECTED BY ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP OR A MINOR DRIVEABILITY SYMPTOM. ONLY FOUR PERCENT OF THE COMPLAINTS TO ODI AND BMW INDICATE THAT AN ENGINE STALL OCCURRED.BMW INDICATED THAT A SERVICE ACTION WAS INITIATED IN APRIL 2008 TO ADDRESS THE PROBLEM AND IT IS CONTINUING TO MONITOR THE FIELD SITUATION AND ANALYZE FIELD DATA. FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.