NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
51 reportsClear category filterMileage unknown · Apr 23, 2026
Electrical System
The vehicle underwent a BMW recall repair involving the blower motor wiring, completed at an authorized BMW dealership. Immediately after the recall repair, the blower motor began operating intermittently. The system turns on and off while driving. The blower motor function can be temporarily restored by physically moving the w…
Read full complaint
The vehicle underwent a BMW recall repair involving the blower motor wiring, completed at an authorized BMW dealership. Immediately after the recall repair, the blower motor began operating intermittently. The system turns on and off while driving. The blower motor function can be temporarily restored by physically moving the wiring harness behind the glove box in the area where the recall repair was performed. Upon inspection, the wiring in the repair area appears to have been cut and spliced, with sections exposed and not properly insulated. The intermittent failure appears directly linked to movement of this wiring harness. The dealership was informed of the issue and recommended replacing the blower motor. However, the blower motor was functioning properly prior to the recall repair. The symptoms began immediately after the recall service. This condition presents a potential electrical safety concern and loss of HVAC functionality while driving. Photos documenting the wiring condition are available. I am requesting review of this recall repair to determine whether it was performed correctly and whether corrective action is required.
NHTSA ODI #11733326
Mileage unknown · Dec 13, 2023
Electrical SystemExterior Lighting
The coating on the angel.eye wiring is made to deteriorate (environmental purposes) but leads to shorting out. Now my angel eyes don't turn on. Wiring needs to be replaced. Could possibly cause a fire I would assume as the live wires have no coating. Multiple forums talk about this issue and lots of drivers experience this. It i…
Read full complaint
The coating on the angel.eye wiring is made to deteriorate (environmental purposes) but leads to shorting out. Now my angel eyes don't turn on. Wiring needs to be replaced. Could possibly cause a fire I would assume as the live wires have no coating. Multiple forums talk about this issue and lots of drivers experience this. It is a hazzard and possible fire instigator the same as the blower motor wiring which does have a recall.
NHTSA ODI #11559984
Mileage unknown · Jul 8, 2023
Electrical SystemUnknown Or OtherFire
The battery light would come on randomly when using the AC. We just took the car out for a 30 minute drive and parked in the garage. When we went back out to get something out of the car 10 minutes later, the car was smoking. We popped the trunk and the battery was on fire! I researched if there were recalls of faulty wiring and…
Read full complaint
The battery light would come on randomly when using the AC. We just took the car out for a 30 minute drive and parked in the garage. When we went back out to get something out of the car 10 minutes later, the car was smoking. We popped the trunk and the battery was on fire! I researched if there were recalls of faulty wiring and came across an article that mentioned this happening when the AC was on. It also mentioned issues with PCV valve heater recalls. After we bought this car, we noticed burn marks around the area near the battery when we replaced it. We wonder if the same thing happened to them but not as much damage. One recall involves the heater for the positive crankcase ventilation (PCV) valve, and the other recall involves wiring and electrical connectors in the system that controls air flow for heating and air conditioning. Can we get help from a BMW dealer to fix this issue? Please advise. Thank you.
NHTSA ODI #11531093
Mileage unknown · Jul 28, 2022
Electrical SystemEngineFuel/propulsion System
The oil filter housing gasket, the mechatronic transmission and the electrical system failed. Yes, it is available for inspection. My safety and the safety of others were put at risk as a result of my vehicle losing power suddenly while I was driving on the highway. I was driving at the highway speed limit and my vehicle malfu…
Read full complaint
The oil filter housing gasket, the mechatronic transmission and the electrical system failed. Yes, it is available for inspection. My safety and the safety of others were put at risk as a result of my vehicle losing power suddenly while I was driving on the highway. I was driving at the highway speed limit and my vehicle malfunctioned and lost power while others were at high speeds. I had to abruptly stop almost causing an accident. The problem has been reproduced and confirmed by the BMW service center. The vehicle has been inspected by the BMW dealer service department. The warning lamps that came on my dashboard were the check engine light, oil level light, and the transmission light. The car was running poorly. The engine wouldn’t crank and then it would jolt after driving. I would smell oil occasionally. The symptoms first appeared in 2011. I had my vehicle serviced at BMW regularly. In 2016 the symptoms got worse despite having my vehicle serviced for the same issue. I had the repairs done at BMW and when I drove it for the first time after getting it repaired it still failed.
NHTSA ODI #11476287
Mileage unknown · Mar 24, 2022
Electrical SystemEngineFuel/propulsion SystemFire
I bought a 2007 BMW 335i convertible on March 10th 2022. On March 18th I left my house and as I was pulling out of my neighborhood the vehicle cut off at about 25 miles an hour and as I pulled over I noticed black smoke coming out from under the hood. There were no warning lights on with the exception of a random airbag light th…
Read full complaint
I bought a 2007 BMW 335i convertible on March 10th 2022. On March 18th I left my house and as I was pulling out of my neighborhood the vehicle cut off at about 25 miles an hour and as I pulled over I noticed black smoke coming out from under the hood. There were no warning lights on with the exception of a random airbag light that came on the day after I bought the car and a tire pressure monitor light. My wife and I pulled over and I ran to a nearby house and took a case of Dasani water from painters who were working (with their permission). I got the fire put out within minutes of its starting but the wiring harness is completely melted together along with all of the induction piping to the turbos and the intake manifold and fuel line. I told the car home and had my insurance agent look at it. She said because it was a fire it would be a mechanical issue and needed to go to the BMW dealership. I paid to have it towed there that day. The dealer called me about an hour after the car showed up there and said that they would not service or inspect the vehicle for damage because I have the wrong insurance company. I was forced to tow the car back home after being turned away by several other dealerships and collision centers due to the high volume of mechanical work already on their lots. BMW has open recalls on 3 series vehicles because they can have engine fires. My car for some reason is not one of the ones they cover under that recall. Still have no resolution from my insurance company on what to do because the car hasn't been officially inspected by a BMW technician. I've now towed the car three times and I'm exactly where I was at the beginning of this claim.
NHTSA ODI #11458127
Mileage unknown · Jun 15, 2021
Electrical SystemEngineSteering
Earlier this year in February I have replaced the alternator and some other major part right after purchasing from dealership and i have seen all the other recent recalls for the vehicle also it appears to have recalls that have not been worked on by manufacture . there also were no signs that came on also the wheel tightened up…
Read full complaint
Earlier this year in February I have replaced the alternator and some other major part right after purchasing from dealership and i have seen all the other recent recalls for the vehicle also it appears to have recalls that have not been worked on by manufacture . there also were no signs that came on also the wheel tightened up and stopped on me out of no where while driving. this being the second time this has happened as on new years i was on the freeway on my way home and the car did the same when i first replaced the alternator
NHTSA ODI #11421040
168,000 miles · Mar 21, 2021
Air BagsElectrical SystemUnknown Or Other
SO I GOT A PAPER SAYING I HAD A RECALL ON MY AIR BAGS SO I CALLED AND GOT MY CAR TAKIN TO BMW IN BELLEVUE. BMW'S ROAD SIDE ASSISTANTS GAVE THE WRONG ADDRESS TO THE TOW COMPANY AND WOULD NOT ANSWER THE PHONE TOW FOR THEM> I EVEN ATTEMPTED TO CALL AND WAS PLACED ON HOLD FOR APPROXIMATYELY 40 MINUTES TO FIX THIS PROBLEM. FINALLY I…
Read full complaint
SO I GOT A PAPER SAYING I HAD A RECALL ON MY AIR BAGS SO I CALLED AND GOT MY CAR TAKIN TO BMW IN BELLEVUE. BMW'S ROAD SIDE ASSISTANTS GAVE THE WRONG ADDRESS TO THE TOW COMPANY AND WOULD NOT ANSWER THE PHONE TOW FOR THEM> I EVEN ATTEMPTED TO CALL AND WAS PLACED ON HOLD FOR APPROXIMATYELY 40 MINUTES TO FIX THIS PROBLEM. FINALLY I SPOKE WITH THE TOW COMPANYS DISPATCHER WHO WAS SO FRUSTRATED HE STARTED ACCUSING ME OF PLAYING GAMES AND THREATENED TO HAVE MY VEHICLE DROPPED AT THE WRONG DEALERSHIP THEN EXTORTED ME FOR ANOTHER 80 DOLLARS JUST TO DROP MY CAR OFF HIS TRUCK AND LEAVE IT AT MY HOUSE. HOURS LATER AFTER FINALLY GETTING A HOD OF ROADSIDE ASSISTANCE THE EXACT SAME COMPANY RETURNED AND DELIVERED MY VEHICLE TO THE RIGHT LOCATION. AFTER ALL OF THIS WE ARE BEING JERKED AROUND BY BELLEVUE BMW ON THE RECALLS THEY ASKED ME FOR 3 HOURS OF LABOR AND PROMISED US TO GET THE VEHICLE STARTED AFTER APPROXIMATELY A WEEK THEY SAID MY DME IS BAD AN IT WOULD COST 8000.00 TO FIX IT AND SAID IT WASN'T WORTH FIXING BECAUSE IT WAS OLD NEVER MENTIONED ANYTHING ABOUT A RECALL UNTIL I FINALLY BROUGHT IT UP THE LAST TIME I SPOKE WITH BMW IN BELLEVUE WHICH WAS MONDAY THE15TH OF MARCH 2021. I WAS TOLD THE WIRE HARNESS WAS REPAIRED NOT REPLACED AND THE AIRBAG RECALL WAS REPLACED. THEN SAID MY BILL WAS OVER 600.00 > AFTER DOING MY RESEARCH THRU THENHTSA WEBSITE I FOUND OUT MY RECALLS WERE NOT FIXED AND I TOOK PHOTOS WITH THE DATES AND TIME SHOWING MY RECALLS WERE NOT FIXED WHICH I FEEL UPSET AND VERY WORRIED AND CONCERNED FOR MY SAFETY NOW I AM NOT SURE WHERE TO GO FROM HEAR BECAUSE MY FAMILY AND I ARE BEING PLACED INTO A HARDSHIP AND TO MAKE IT WORSE WE ARE IN THE MIDDLE OF A PANDEMIC PLEASE HELP US. I DON'T KNOW IF ANYTHING WAS DONE TO THE CAR I THINK WE NEED TO TALK TO AN ATTORNEY
NHTSA ODI #11404084
202,000 miles · Jan 26, 2021
Electrical SystemSteering
I WENT TO START MY CAR AND THERE WAS A RED WARNING LIGHT THAT IS A STEERING WHEEL WITH A PADLOCK. I AM NOT ABLE TO START MY CAR OR DO ANYTHING WITH IT FOR THAT MATTER, SO I AM STUCK. THANK GOODNESS I WAS HOME AND PARKED IN THE DRIVEWAY OR WORSE, DRIVING AND IT LOCK ON ME! SO NOW I AM STUCK WITHOUT A CAR AND HARD TELLING WHAT ITS…
Read full complaint
I WENT TO START MY CAR AND THERE WAS A RED WARNING LIGHT THAT IS A STEERING WHEEL WITH A PADLOCK. I AM NOT ABLE TO START MY CAR OR DO ANYTHING WITH IT FOR THAT MATTER, SO I AM STUCK. THANK GOODNESS I WAS HOME AND PARKED IN THE DRIVEWAY OR WORSE, DRIVING AND IT LOCK ON ME! SO NOW I AM STUCK WITHOUT A CAR AND HARD TELLING WHAT ITS GOING TO COST ME! IVE BEEN READING THAT A LOT OF OTHER PEOPLE ARE HAVING OR HAVE HAD THE SAME ISSUE.
NHTSA ODI #11389998
220,000 miles · Dec 10, 2019
Electrical SystemFire
TURNED ON BLOWER MOTOR, CAR SMOKED AND BURNT UP BEFORE FIRE TRUCK ARRIVED
NHTSA ODI #11288186
72,000 miles · Apr 19, 2019
Electrical System
TL* THE CONTACT OWNS A 2007 BMW 335I. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART AND WAS TAKEN TO BEVERLY HILLS BMW (LOCATED AT 5070 WILSHIRE BLVD, LOS ANGELES, CA 90036, (877) 794-4678). THE DEALER DIAGNOSED THAT THE POSITIVE BATTERY CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAI…
Read full complaint
TL* THE CONTACT OWNS A 2007 BMW 335I. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART AND WAS TAKEN TO BEVERLY HILLS BMW (LOCATED AT 5070 WILSHIRE BLVD, LOS ANGELES, CA 90036, (877) 794-4678). THE DEALER DIAGNOSED THAT THE POSITIVE BATTERY CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V044000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.
NHTSA ODI #11197369
Official recalls
5Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Nov 12, 2013
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Feb 7, 2013
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration