NHTSA owner reports · September 18, 2026 snapshot.
Latches/locks/linkages complaints
4 reportsClear category filter170,000 miles · Sep 6, 2024
Latches/locks/linkages
The contact owns a 2008 BMW 328I. The contact stated while the vehicle was parked, the contact stated that the manual door locks became inoperable. The contact had to climb out of the driver's side window to exit the vehicle. The contact was able to enter the vehicle by using the key fob. The dealer was contacted. The vehicle wa…
Read full complaint
The contact owns a 2008 BMW 328I. The contact stated while the vehicle was parked, the contact stated that the manual door locks became inoperable. The contact had to climb out of the driver's side window to exit the vehicle. The contact was able to enter the vehicle by using the key fob. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 170,000.
NHTSA ODI #11613049
81,000 miles · Nov 3, 2014
Latches/locks/linkagesStructure
I AM UNABLE TO OPEN/UNLOCK THE DRIVER'S SIDE DOOR. OTHER DOORS ARE FINE BUT I WOULD BE TRAPPED IN CASE OF FIRE OR ACCIDENT. DOOR DOES UNLOCK THROUGH MANUAL KEY (NOT FOB). *TR
NHTSA ODI #10652294
31,000 miles · Oct 25, 2012
Latches/locks/linkages
TL* THE CONTACT OWNS A 2008 BMW 328I. THE CONTACT STATED THAT THE POWER DOOR LOCKS FAILED ON ALL OF THE DOORS. THE CONTACT STATED THE FAILURE PREVENTED THE DOORS FROM BEING OPEN MANUALLY. THE CONTACT STATED THAT IF YOU WAS INSIDE THE VEHICLE YOU HAD TO ROLL DOWN THE WINDOW AND USE THE KEY ON THE OUTSIDE TO GET OUT OF THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2008 BMW 328I. THE CONTACT STATED THAT THE POWER DOOR LOCKS FAILED ON ALL OF THE DOORS. THE CONTACT STATED THE FAILURE PREVENTED THE DOORS FROM BEING OPEN MANUALLY. THE CONTACT STATED THAT IF YOU WAS INSIDE THE VEHICLE YOU HAD TO ROLL DOWN THE WINDOW AND USE THE KEY ON THE OUTSIDE TO GET OUT OF THE VEHICLE. THE CONTACT STATED THAT THE ONLY DOOR THAT COULD BE UNLOCKED IN THIS SITUATION WAS THE DRIVER SIDE DOOR, ANY ONE ELSE IN THE VEHICLE HAS TO CLIMB OVER TO THE DRIVER SEAT TO EXIT. THE CONTACT FELT THIS WAS A SAFETY HAZARD FOR THE ELDERLY AND PEOPLE WITH DISABILITIES. THE DEALER STATED THAT THE DOOR ACTUATORS FAILED AND VERIFIED THAT THE DRIVERS DOOR WAS THE ONLY ONE THAT WOULD OPEN FROM THE OUTSIDE. THE FAILURE AND CURRENT MILEAGE WAS 31,000. UPDATED 12/06/12*LJ THE CONSUMER STATED ONLY THE DRIVER'S SIDE DOOR WITH THE USE OF THE KEY WORKED. UPDATED 12/06/12
NHTSA ODI #10482178
67,800 miles · Oct 23, 2011
Electrical SystemLatches/locks/linkages
DOORS WILL NOT UNLOCK. MANUAL KEY WILL WORK IN THE DRIVE SIDE DOOR OUTSIDE ONLY. OTHER 3 DOORS WILL NOT OPEN AT ALL. THE ONLY WAY TO GET OUT OF THE CAR IS TO CLIMB THRU THE WINDOW OR CLIMB OUT OF THE DRIVER DOOR. DRIVER HAS TO CLIMB OUT OF WINDOW AND USE MANUAL KEY TO OPEN DOOR. MANY POST ONLINE OF THIS PROBLEM. I WILL HAVE …
Read full complaint
DOORS WILL NOT UNLOCK. MANUAL KEY WILL WORK IN THE DRIVE SIDE DOOR OUTSIDE ONLY. OTHER 3 DOORS WILL NOT OPEN AT ALL. THE ONLY WAY TO GET OUT OF THE CAR IS TO CLIMB THRU THE WINDOW OR CLIMB OUT OF THE DRIVER DOOR. DRIVER HAS TO CLIMB OUT OF WINDOW AND USE MANUAL KEY TO OPEN DOOR. MANY POST ONLINE OF THIS PROBLEM. I WILL HAVE IT FIXED, HOWEVER, THE COSTS ARE VERY HIGH; THIS IS A SAFETY HAZARD! IF CAR IS WRECKED OR ON FIRE, RESCUE WOULD NOT LIKELY BE ABLE TO HELP DRIVER OR PASSENGER TIMELY. RECALL IS NEEDED! *TR
NHTSA ODI #10432510
Official recalls
5Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Oct 30, 2017
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Feb 7, 2013
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence & remedy
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Additional source detail variants (3)
Electrical System:wiring:fuses And Circuit Breakers
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical SYSTEM:12V/24V/48V Battery:cables
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Electrical System
BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.
Consequence: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration