NHTSA owner reports · September 18, 2026 snapshot.
Latches/locks/linkages complaints
5 reportsClear category filter76,000 miles · May 1, 2012
Latches/locks/linkagesStructure
TL* THE CONTACT OWNS A 2006 BMW 325XI. THE CONTACT STATED THAT HE WAS UNABLE TO OPEN ANY OF THE VEHICLE DOORS, OTHER THAN THE DRIVER SIDE, BY USING THE KEY FOB OR MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT ONE OF THE LOCK MECHANISMS WAS DEFECTIVE AND THE SENSOR WAS NOT STRONG ENOUGH AS A RESULT BOTH THE LOC…
Read full complaint
TL* THE CONTACT OWNS A 2006 BMW 325XI. THE CONTACT STATED THAT HE WAS UNABLE TO OPEN ANY OF THE VEHICLE DOORS, OTHER THAN THE DRIVER SIDE, BY USING THE KEY FOB OR MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT ONE OF THE LOCK MECHANISMS WAS DEFECTIVE AND THE SENSOR WAS NOT STRONG ENOUGH AS A RESULT BOTH THE LOCK MECHANISM AND SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 76,000. UPDATED 06/06/12 *BF THE CONSUMER STATED THE SAME FAILURE OCCURRED TO THE FUEL DOOR, RENDERING HIM UNABLE TO FUEL THE CAR. UPDATED 06/07/12 *JS
NHTSA ODI #10457066
88,000 miles · Jun 29, 2011
Latches/locks/linkages
3 OF THE 4 DOOR LOCKS ON MY 2006 BMW 325XI FAILED. A FRIEND WAS IN THE PASSENGER SEAT AND ONCE WE STOPPED AND ATTEMPTED TO GET OUT, THE PASSENGER DOOR WOULD NOT OPEN. SHE WAS TRAPPED IN THE CAR AND HAD TO BE REMOVED VIA THE PASSENGER WINDOW. THE TWO REAR DOORS AND ONE PASSENGER DOOR WOULD NOT OPEN EITHER. THE BUTTONS WOULD NOT W…
Read full complaint
3 OF THE 4 DOOR LOCKS ON MY 2006 BMW 325XI FAILED. A FRIEND WAS IN THE PASSENGER SEAT AND ONCE WE STOPPED AND ATTEMPTED TO GET OUT, THE PASSENGER DOOR WOULD NOT OPEN. SHE WAS TRAPPED IN THE CAR AND HAD TO BE REMOVED VIA THE PASSENGER WINDOW. THE TWO REAR DOORS AND ONE PASSENGER DOOR WOULD NOT OPEN EITHER. THE BUTTONS WOULD NOT WORK TO OPEN THEM AND THE DOORS COULD NOT BE OPENED BY PULLING THE HANDLE INSIDE. MY 76 YEAR OLD GRANDMOTHER HAD JUST LEFT THE CAR 20 MINUTES EARLIER AND HAS DIFFICULTY WITH MOBILITY, IT WAS 94 DEGREES TODAY, WHAT WOULD I DO IF SHE WAS TRAPPED IN THE CAR IN THIS HEAT? THE PROBLEM IS CONSTANT AND NO CORRECTIVE ACTIONS HAVE BEEN TAKEN FOR FEAR OF FURTHER DAMAGE. *TR
NHTSA ODI #10409406
49,000 miles · Feb 18, 2011
Latches/locks/linkages
DOOR LOCKING ISSUES, DOORS WILL NOT OPEN FROM INSIDE OF THE CAR WHEN HANDLE IS OPENED BY PASSENGERS. DOORS WILL NOT UNLOCK VIA KEY FOB. POSSIBLE ISSUE WITH CONTROL MODULE GM5 WITHIN THE BMW DASHBOARD. *LN
NHTSA ODI #10383200
48,000 miles · Sep 11, 2010
Latches/locks/linkagesStructure
3 DOORS ON THE CAR WOULD NOT OPEN FROM INSIDE OR OUTSIDE OF THE CAR. LUCKILY THE DRIVER DOOR STILL WORKED. IN THE EVENT OF AN ACCIDENT OR FIRE THIS IS A SEVERE HAZARD. *TR
NHTSA ODI #10355026
101,600 miles · Jul 22, 2010
Latches/locks/linkages
THE DOOR LOCKS ON MY 2006 BMW 325XI ALL FAILED AT ONCE WITHOUT ANY WARNING. THE FRONT PASSENGER AND BOTH REAR DOORS DO NOT UNLOCK AT ALL, EITHER ELECTRONICALLY OR MANUALLY. THE DRIVER SIDE DOOR WILL OPEN WITH THE KEY AND IS THE ONLY ONE, SO FAR, THAT CAN BE OPENED FROM INSIDE THE VEHICLE. HAD PASSENGERS BEEN IN THE CAR AND TH…
Read full complaint
THE DOOR LOCKS ON MY 2006 BMW 325XI ALL FAILED AT ONCE WITHOUT ANY WARNING. THE FRONT PASSENGER AND BOTH REAR DOORS DO NOT UNLOCK AT ALL, EITHER ELECTRONICALLY OR MANUALLY. THE DRIVER SIDE DOOR WILL OPEN WITH THE KEY AND IS THE ONLY ONE, SO FAR, THAT CAN BE OPENED FROM INSIDE THE VEHICLE. HAD PASSENGERS BEEN IN THE CAR AND THE CAR WAS INVOLVED IN AN ACCIDENT, IT WOULD HAVE BEEN EXTREMELY DIFFICULT TO EXIT THE VEHICLE. *TR
NHTSA ODI #10344636
Official recalls
6Jul 3, 2024
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Air Bags:frontal
BMW of North America, LLC (BMW) is recalling certain 2006-2011 3 Series Sedan (324i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi), 2006-2012 3 Series Sportswagon (325xi, 328i, 328xi), and 2009-2011 3 Series Sedan (335d) vehicles. The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with an inflator that can explode during deployment.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will inspect and replace the driver's air bag module as necessary, free of charge. Owner notification letters were mailed August 30, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Jan 15, 2020
BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.
Apr 4, 2019
BMW of North America, LLC (BMW) is recalling certain 2006 525i, 525xi, 530i, 530xi, 530xi Sports Wagon, 325i, 325xi, 325xi Sports Wagon, 330i, 330xi, Z4 3.0i and Z4 3.0si vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. The recall began May 30, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion to recall 17V-683.
Oct 25, 2017
BMW of North America, LLC (BMW) is recalling certain 2006-2011 323i, 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi and M3, 2007-2011 328i xDrive, 335i xDrive and 335is and 2009-2011 335d vehicles. The wiring and electrical connectors for the system that controls air flow for the heating and air conditioning system may overheat.
Consequence & remedy
Consequence: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.
Remedy: BMW will notify owners, and dealers will replace the wiring and electrical connectors, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact BMW customer service at 1-800-525-7417.
Jul 6, 2017
BMW of North America, Inc. (BMW) is recalling certain 2006 325i, 325xi, 330i, 330xi, 525i, 525xi, 530i, 530xi, and 550i vehicles equipped with the Sport Seat option and certain 2006 525i, 525xi, 530i, 530xi, 550i vehicles with standard seats. The front passenger seat occupant detection mat that determines if, and how, the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners, and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, replacing it as necessary, free of charge. The recall began September 1, 2017. Owners may contact BMW customer service at 1-800-525-7417.
Nov 12, 2013
BMW of North America LLC (BMW) is recalling certain model year 2006 325i, 325xi, 330i, 330xi sedans and 325xi sports wagons, model year 2007 328i, 328xi, 335i, 335xi sedans and 328i and 328xi sports wagons, model year 2006-2007 525i, 525xi, 530i, 530xi, 550i sedans and 530xi sports wagons, model year 2006 760i sedans, model year 2006-2007 750i, 750Li, and 760Li sedans, and model year 2006 X5 sports activity vehicles, equipped with certain seat types. The front passenger seat occupant detection mat that determines if and how the passenger frontal air bag should deploy in a crash may fatigue and develop cracks which could lead to a system failure.
Consequence & remedy
Consequence: Should the system fail, in the event of a crash, the front passenger air bag would be deactivated, increasing the risk of personal injury.
Remedy: BMW will notify owners with an interim notification letter in January 2014 since parts are not currently available. When parts are available, BMW sent a second letter in August and dealers will repair the occupant detection mat to eliminate the possibility that it may crack, free of charge. Additionally, owners of model year 2006-2007 3 Series with standard seats, 5 Series with comfort seats, and Z4 models, will receive an extended warranty on their front passenger seat occupant detection mat. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration