Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
AUGUST 6, 2016 - CAR STALLED AT ABOUT 50MPH, JUST WHEN ABOUT TO GO UPHILL. I WASN'T ABLE TO MAKE IT TO THE SHOULDER LEAVING THE CAR BLOCKING TRAFFIC WITH MY WIFE AND DAUGHTER IN IT. ONCE IT STOPS, IT PUTS ITSELF IN PARK, MAKING IT IMPOSSIBLE TO PUSH ASIDE. WE CREATED A TRAFFIC JAM AND POLICE BARRICADED WHILE WE WERE TRYING TO …
Read full complaint
AUGUST 6, 2016 - CAR STALLED AT ABOUT 50MPH, JUST WHEN ABOUT TO GO UPHILL. I WASN'T ABLE TO MAKE IT TO THE SHOULDER LEAVING THE CAR BLOCKING TRAFFIC WITH MY WIFE AND DAUGHTER IN IT. ONCE IT STOPS, IT PUTS ITSELF IN PARK, MAKING IT IMPOSSIBLE TO PUSH ASIDE. WE CREATED A TRAFFIC JAM AND POLICE BARRICADED WHILE WE WERE TRYING TO MOVE THE CAR. EVENTUALLY, IN ABOUT 30 MINS, THE CAR TURNS ON. HAPPENED AFTER AN HOUR OF HIGHWAY DRIVING. CAR SEEMED FINE AFTER THAT. AUGUST 17, 2016 - ON ANOTHER LONG TRIP, THE CAR STALLED ON THE HIGHWAY. WOULD CRANK BUT NOT TURN ON. ALMOST EXHAUSTED THE BATTERY. CALLED A TOW TRUCK BUT BY THE TIME IT GOT THERE, AFTER ABOUT AN HOUR, THE CAR RESTARTED. HAD MY ODB-II SCANNER WITH ME AND GOT CODE USED MY OBDII READER AND GOT CODE P142E - PRESSURE TOO LOW IN HIGH-PRESSURE SYSTEM, WHICH IS CONSISTENT WITH NOT STARTING AND THE AND THE FUEL SYSTEM MALFUNCTION MESSAGE. I TOOK THE CAR TO AUTOGERMANA SERVICE CENTER, THAT SAME DAY. SEPTEMBER 22, 2016 - STALLED ON A MAIN ROAD, WITH MY DAUGHTER, ON THE WAY TO THE PEDIATRICIAN. I WAS ABLE TO MANEUVER TO THE RIGHT LANE AND PARK ON A GAS STATION. AMBIENT TEMP WAS 94F. WAITED ABOUT 30MINS AND THE CAR RE-STARTED. THE DEALESHIP WOULD NOT ACKNOWLEDGE A FUEL SYSTEM PROBLEM BECAUSE THEY COULD NOT REPLICATE THE FAILURE. SENT EMAIL TO BMW CUSTOMER RELATIONS BUT THEY REFERRED ME BACK TO THE DEALERSHIP.
NHTSA ODI #10925651
24,000 miles · Nov 11, 2016
Fuel/propulsion System
I WAS DRIVING ON A VERY BUSY ROAD IN DOWNTOWN CHICAGO IN HEAVY TRAFFIC AND THE CAR JUST SUDDENLY STALLED WITHOUT ANY WARNING MIDDLE OF THE ROAD AND WON'T MOVE. OF COURSE CAME CLOSE TO BEING CRASHED FROM BEHIND. I AM GRATEFUL AND LUCKY THAT THE CARS BEHIND WERE ABLE TO STOP IN TIME AND MANEUVER AROUND ME TO AVOID COLLISION. T…
Read full complaint
I WAS DRIVING ON A VERY BUSY ROAD IN DOWNTOWN CHICAGO IN HEAVY TRAFFIC AND THE CAR JUST SUDDENLY STALLED WITHOUT ANY WARNING MIDDLE OF THE ROAD AND WON'T MOVE. OF COURSE CAME CLOSE TO BEING CRASHED FROM BEHIND. I AM GRATEFUL AND LUCKY THAT THE CARS BEHIND WERE ABLE TO STOP IN TIME AND MANEUVER AROUND ME TO AVOID COLLISION. THE BMW DEALER INSPECTED THE CAR AND TOLD ME THAT THE FUEL PUMP AND ITS CONTROL UNIT IS FAULTY. I HAVE ATTACHED THEIR DIAGNOSIS AS WELL. I FIND IT HARD TO BELIEVE THAT A LESS THAN 4 YEAR OLD CAR WITH UNDER 25K MILES ON IT HAS A FUEL PUMP FAILURE, UNLESS IT WAS FAULTY TO BEGIN WITH. I CHECKED INTO THE RECALLS FOR BMW 328I MODELS FOR FAULTY FUEL PUMPS AND IT SEEMS BMW RECALLED MODELS FROM 2014, BUT IT SEEMS THE 2012 BMW HAS THIS ISSUE AS WELL. I WAS SAVED BUT I WANT TO MAKE SURE NO ONE ELSE IS HURT BECAUSE OF FAULTY PARTS THAT CAR MANUFACTURERS FAIL TO CHECK BEFORE SELLING IT TO UNSUSPECTING CONSUMERS, WHO THINK THEY ARE SAFE WHEN DRIVING THESE EXPENSIVE CARS WITH THEIR FAMILIES AND PRECIOUS ONES IN IT. I SHUDDER TO THINK WHAT COULD HAVE HAPPENED AND I CONSIDER MYSELF LUCKY TO BE STILL ALIVE, SAFE AND OK TO WRITE THIS MESSAGE.
BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.
Consequence & remedy
Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.
Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Consequence & remedy
Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.
BMW IS RECALLING CERTAIN MODEL YEAR 2012 BMW 3-SERIES VEHICLES MANUFACTURED FROM OCTOBER 19, 2011, THROUGH MARCH 18, 2012, THAT HAVE FRONT SEAT HEAD RESTRAINTS THAT EXCEED THE DOWNWARD MOVEMENT LIMIT OF 25MM IN THE HIGHEST POSITION. THUS, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202A,"HEAD RESTRAINTS."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE HEAD RESTRAINT MAY UNEXPECTEDLY MOVE DOWN SLIGHTLY IF IT WAS ADJUSTED TO THE FULLY EXTENDED POSITION, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL ATTACH A CLAMP TO THE FRONT SEAT HEAD RESTRAINT POSTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
1
PE13030 · Loss Of Power Assist Braking
Opened Sep 6, 2013 · Closed Oct 25, 2013
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist:vacuum
In a letter dated September 26, 2013, BMW Group submitted a safety recall notice to NHTSA identifying a defect condition in the vacuum pump oil supply that may result in loss of power assist braking in 76,191 model year (MY) 2012 through 2014 BMW 3-Series, 5-Series, X1 SAV, X3 SAV, and Z4 vehicles equipped with 4-cylinder engines (NHTSA Recall 13V-454).According to BMW, movement of the seal disk within the camshaft may result in blocking of the oil supply to the vacuum pump, resulting in improper pump operation and loss of power assist braking.On July 11, 2013, BMW initiated a change to the camshaft geometry that prevented the seal disk from blocking the oil port.BMW has not received any braking complaints related to loss of power assist after the design change was implemented in production.The owners of all affected vehicles will be contacted by mail and asked to take their vehicle to a BMW dealer who will install a locking ring into the camshaft to keep the seal disk in its proper location.BMW expects to begin dealer and owner notification in November 2013 and complete dealer and owner notification in December when the remedy is expected to be available.Based on the actions taken by BMW, this investigation is closed.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration