IllustrationREFLECTOR BOWLS IN XENON HEADLAMP ASSEMBLY BURN AND DISCOLOR, MAKING LOW BEAM LIGHTING ALMOST NEGLIGIBLE. DOESN'T EVEN SEEM LIGHTS ARE ON. VERY DANGEROUS TO DRIVE AT NIGHT WITHOUT HIGH BEAMS ON. *TR
2004 BMW 3 Series
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 BMW 3 Series do not stand out strongly from the model-year median of 23.
About this comparison →How this year compares
Owner complaints by model year
Compare all 3 Series years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
1125–50K
750–75K
1375–100K
15100–150K
4150K+
51 reports with mileage · 26 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports3 fire reports2 injury reports
What owners actually said
77 reportsAS REPORTED BY OTHER OWNERS, THE BI-XENON HEADLIGHTS NO LONGER LIGHT UP THE ROAD. IT IS A SAFETY HAZARD AND IS A KNOWN ISSUE WITH HEADLIGHTS MANUFACTURED BY ZKW ON 2003-2005 BMW 330 MODELS. THE REFLECTOR BOWLS ON THESE UNITS BURN OUT OVER TIME AND REDUCE THE HEADLIGHTS ABILITY TO REFLECT LIGHT. DRIVING AT NIGHT IS LITERALLY NO B…
Read full complaint
AS REPORTED BY OTHER OWNERS, THE BI-XENON HEADLIGHTS NO LONGER LIGHT UP THE ROAD. IT IS A SAFETY HAZARD AND IS A KNOWN ISSUE WITH HEADLIGHTS MANUFACTURED BY ZKW ON 2003-2005 BMW 330 MODELS. THE REFLECTOR BOWLS ON THESE UNITS BURN OUT OVER TIME AND REDUCE THE HEADLIGHTS ABILITY TO REFLECT LIGHT. DRIVING AT NIGHT IS LITERALLY NO BETTER WITH THE HEADLIGHTS ON OR OFF. I HAVE TO RELY ON MY FOG LIGHTS JUST TO SEE ANYTHING. PLEASE LOOK INTO THIS SAFETY ISSUE AS IT IS WIDE-SPREAD. REPLACEMENT OF HEADLIGHTS IS EXPENSIVE AT $1300 EA, THIS HAS TO BE RESOLVED BY BMW IMMEDIATELY. *TR
THE REFLECTIVE MATERIAL IN THE XENON HEADLAMPS HAS MELTED AWAY DUE TO THE HEAT OF THE BULBS RESULTING IN DRASTICALLY REDUCED HEADLIGHT EFFECTIVENESS AT NIGHT. THIS CAUSES AN EXTREMELY UNSAFE CONDITION WHEN DRIVING AT NIGHT. I HAVE DISCOVERED THIS IS A COMMON OCCURRENCE IN 2003-2005 E46 BMW 3 SERIES AND I BELIEVE IT SHOULD BE REC…
Read full complaint
THE REFLECTIVE MATERIAL IN THE XENON HEADLAMPS HAS MELTED AWAY DUE TO THE HEAT OF THE BULBS RESULTING IN DRASTICALLY REDUCED HEADLIGHT EFFECTIVENESS AT NIGHT. THIS CAUSES AN EXTREMELY UNSAFE CONDITION WHEN DRIVING AT NIGHT. I HAVE DISCOVERED THIS IS A COMMON OCCURRENCE IN 2003-2005 E46 BMW 3 SERIES AND I BELIEVE IT SHOULD BE RECALLED AND FIXED BY THE MANUFACTURER. BMW KNOWS THIS IS A DEFICIENCY AS THEY CORRECTED IT IN THEIR LATER MODELS. *TR
MY 2004 BMW 325CI RECENTLY DEVELOPED A PROBLEM WITH THE LEFT REAR TAIL LIGHT (TURN SIGNAL AND BRAKE LIGHT) INTERMITENTLY DOES NOT WORK. A LEFT TAIL LIGHT FAILURE ALSO SHOWS ON THE ON BOARD DIAGNOSTIC DISPLAY. THE PROBLEM IS INTERMITENT AND WITH NO WARNING. I DID SOME RESEARCH AND FOUND THERE WAS A BMW RECALL FOR MODEL YEARS 2…
Read full complaint
MY 2004 BMW 325CI RECENTLY DEVELOPED A PROBLEM WITH THE LEFT REAR TAIL LIGHT (TURN SIGNAL AND BRAKE LIGHT) INTERMITENTLY DOES NOT WORK. A LEFT TAIL LIGHT FAILURE ALSO SHOWS ON THE ON BOARD DIAGNOSTIC DISPLAY. THE PROBLEM IS INTERMITENT AND WITH NO WARNING. I DID SOME RESEARCH AND FOUND THERE WAS A BMW RECALL FOR MODEL YEARS 2001 THRU 2005 FOR THIS EXACT PROBLEM. THE RECALL SPECIFIES 325 SEDAN MODELS, MY MODEL IS A 325CI (COUPE). I CALLED BMW NORTH AMERICA AND THEY SAY MY PARTICULAR MODEL IS NOT COVERED BY THE RECALL. I ARGUED THAT I AM HAVING THE EXACT SAME ISSUE AS THE RECALL SUGGESTS, AND MY VEHICLE FALLS INTO THE MODEL YEARS SPECIFIED. THEY REFUSED TO ACKNOLEDGE THE PROBLEM AS PART OF THE RECALL. BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B63 06 11 LIGHTS) FOR THIS ISSUE IN JANUARY OF 2012. A RECALL (ID # 71087) WAS ISSUED AUG. 26, 2011. I WAS NOT NOTIFIED BY BMW OF EITHER THE SERVICE BULLETIN OR RECALL. I AM THE ORIGINAL PURCHASER OF THE VEHICLE. MY WIFE AND I DRIVE THIS CAR WITH OUR 11 YEAR OLD DAUGHTER IN THE CAR, AND THIS IS A DEFINITE SAFETY HAZARD. PLEASE HELP ME GET THIS RESOLVED. *TR
THOUGHT I HAD A LIGHT PROBLEM FIXED IT FIRST TIME. SIGNAL ON THE DASH DID NOT GO AWAY BUT THE LIGHT WAS ON. WENT TO A DIFFERENT PLACE AND FIXED IT AGAIN. AND THE SIGNAL STILL WOULD NOT GO AWAY. THE LIGHT WORKS BUT STILL SHOW ON THE DASH AS IF IT'S BROKEN. I'M AFRAID BY TIME IT'S TIME TO GET A NEW REGISTRATION STICKER THAT IT WIL…
Read full complaint
THOUGHT I HAD A LIGHT PROBLEM FIXED IT FIRST TIME. SIGNAL ON THE DASH DID NOT GO AWAY BUT THE LIGHT WAS ON. WENT TO A DIFFERENT PLACE AND FIXED IT AGAIN. AND THE SIGNAL STILL WOULD NOT GO AWAY. THE LIGHT WORKS BUT STILL SHOW ON THE DASH AS IF IT'S BROKEN. I'M AFRAID BY TIME IT'S TIME TO GET A NEW REGISTRATION STICKER THAT IT WILL NOT PASS. *TR
HEADLIGHTS VERY DIM WHEN COMPARED TO ORIGINAL BRIGHTNESS. *TR
RECENTLY PURCHASED SAID VEHICLE AND IT CAME WITH ZKW HID BI-XENON LIGHTING SYSTEM WHICH APPEARS THE INNER PLASTIC BOWLS ARE BURNT TO A CRISP WITH DETRIMENT LIGHT OUTPUT MAKING IT ALMOST IMPOSSIBLE TO CLEARLY SEE UNLIT ROADS AT NIGHT, THIS IS A HUGE SAFETY CONCERN AND NEEDS TO BE REVIEWED AND SOLVED IN A TIMELY MANNER AS IT AFFEC…
Read full complaint
RECENTLY PURCHASED SAID VEHICLE AND IT CAME WITH ZKW HID BI-XENON LIGHTING SYSTEM WHICH APPEARS THE INNER PLASTIC BOWLS ARE BURNT TO A CRISP WITH DETRIMENT LIGHT OUTPUT MAKING IT ALMOST IMPOSSIBLE TO CLEARLY SEE UNLIT ROADS AT NIGHT, THIS IS A HUGE SAFETY CONCERN AND NEEDS TO BE REVIEWED AND SOLVED IN A TIMELY MANNER AS IT AFFECTS THOUSANDS OF SIMILAR VEHICLES ON THE ROAD. I'M AFRAID THE REDUCED LIGHT OUTPUT MIGHT APPEAR TO OTHER DRIVERS AT NIGHT THAT MY VEHICLE IS FURTHER AWAY THAT IT IS IN REALITY GIVING THE POSSIBILITY OF THEM CROSSING INTO MY TRAVEL PATH INCURRING AN ACCIDENT. I KNOW YOU HAVE BEEN REVIEWING THIS FOR QUITE SOME TIME BUT WE NEED A RESOLUTION SOON... THANK YOU. *JS
HEADLIGHT OUTPUT BEGAN TO DIM. REPLACED BULB AND HAD CLEAR LENS COVER CLEANED. THIS DID NOT HELP. CAR IS NOW UNSAFE TO DRIVE AT NIGHT. DEALERSHIP DISCOVERED THAT THE HEAT FROM THE BULB HAS MELTED AND DISCOLORED THE REFLECTOR FOR THE HEADLIGHT. ONLINE INTERNET SEARCH INDICATES THIS IS A CHRONIC SAFETY PROBLEM WITH THIS MODEL OF …
Read full complaint
HEADLIGHT OUTPUT BEGAN TO DIM. REPLACED BULB AND HAD CLEAR LENS COVER CLEANED. THIS DID NOT HELP. CAR IS NOW UNSAFE TO DRIVE AT NIGHT. DEALERSHIP DISCOVERED THAT THE HEAT FROM THE BULB HAS MELTED AND DISCOLORED THE REFLECTOR FOR THE HEADLIGHT. ONLINE INTERNET SEARCH INDICATES THIS IS A CHRONIC SAFETY PROBLEM WITH THIS MODEL OF BMW. *TR
I OWN A 2004 BMW 3 SERIES SEDAN WITH OPTIONAL BI-XENON HEADLIGHTS. ABOUT 10,000 MILES INTO MY PURCHASE (OR 57,000) I BEGAN TO NOTICE MY HEADLIGHT OUTPUT DETERIORATING SIGNIFICANTLY. MY GIRLFRIEND OWNS A 2004 BMW 3 SERIES COUPE/CONVERTIBLE ALSO WITH THE OPTIONAL BI-ZENON AND 60,000 MILES. I COMPARED OUR VEHICLES HEADLIGHTS SIDE B…
Read full complaint
I OWN A 2004 BMW 3 SERIES SEDAN WITH OPTIONAL BI-XENON HEADLIGHTS. ABOUT 10,000 MILES INTO MY PURCHASE (OR 57,000) I BEGAN TO NOTICE MY HEADLIGHT OUTPUT DETERIORATING SIGNIFICANTLY. MY GIRLFRIEND OWNS A 2004 BMW 3 SERIES COUPE/CONVERTIBLE ALSO WITH THE OPTIONAL BI-ZENON AND 60,000 MILES. I COMPARED OUR VEHICLES HEADLIGHTS SIDE BY SIDE. MY BI-XENON HEADLIGHTS IN BOTH LOW AND HIGH BEAM FORM WERE SIGNIFICANTLY DIMMER AND HAD A YELLOW TINT WHEN COMPARED TO HER BI-XENON HEADLIGHTS. THIS IS A COMMON ISSUE ON BMW 3 SERIES SEDANS WITH THE OPTIONAL BI-XENON HEADLAMPS. THE PROBLEM IS THAT THE BI-XENON REFLECTOR HOUSING BOWL IN BMW E46 3 SERIES SEDANS IS MADE FROM A DIFFERENT MANUFACTURER THAN THE COUPES AND CONVERTIBLES. THE HEADLIGHTS IN MY VEHICLE ARE MADE AND CLASSIFIED UNDER THE TITLE (ZKW). THE COUPES AND CONVERTIBLES ARE MADE AND CLASSIFIED UNDER THE NAME (AL). THE DIFFERENCE IS THAT OEM ZKW HEADLIGHTS REFLECTOR HOUSING BOWLS ARE MADE FROM A TYPE OF PLASTIC. WHILE THE OEM AL HEADLIGHTS ARE MADE OUT OF METAL. THE METAL HOUSING IN AL STYLE HEADLIGHTS IN COUPES AND CONVERTIBLES ARE ABLE TO STAND UP TO THE HEAT OF THE XENON BULB, THE PLASTIC HOUSINGS IN MY SEDAN ARE NOT. DUE TO THIS IT LITERALLY GETS TOO HOT AND BURNS THE PLASTIC REFLECTIVE HOUSING TO A BROWN CRISP, WHICH IS NOT A REFLECTIVE SURFACE AND DETERIORATED MY HEADLIGHT OUTPUT TO AN EXTREMELY UNSAFE LEVEL. THE OUTPUT LEVEL HAS DIMMED SO THAT WHEN THERE IS ANY ONCOMING TRAFFIC MY LIGHTS GET DROWNED OUT AND I MUST PUT ON MY FOG LAMPS TO MAINTAIN ANY TYPE OF VISIBILITY. THE OUTPUT LEVEL IS BELOW ANY HALOGEN LAMP I HAVE SEEN. THIS IS EXTREMELY UNSAFE AT ANY SPEED AND IS A KNOWN ISSUE ON ALL BI-XENON EQUIPPED BMW E46 3 SERIES SEDANS. BMW IS AWARE OF THIS ISSUE AND HAS DONE NOTHING TO ADDRESS THIS DESIGN FLAW, WHICH COMPROMISES THE SAFETY OF MYSELF AND OTHERS. PICTURES OF THE ISSUE ARE AVAILABLE UPON REQUEST. THANK YOU. *TR
MY BI-XENON HEADLIGHTS HAVE BEEN SLOWLY FADING RESULTING IN EXTREMELY POOR VISIBILITY DURING NORMAL NIGHTIME DRIVING. THIS DEGRADATION HAS BEEN OCCURRING WITHOUT MY KNOWLEDGE UNTIL IT BECAME OBVIOUS AFTER DRIVING ANOTHER VEHICLE. AS IT TURNS OUT, MY MECHANIC HAS ADVISED THERE IS A COMMON ISSUE WITH CERTAIN BMW ASSEMBLIES THAT TH…
Read full complaint
MY BI-XENON HEADLIGHTS HAVE BEEN SLOWLY FADING RESULTING IN EXTREMELY POOR VISIBILITY DURING NORMAL NIGHTIME DRIVING. THIS DEGRADATION HAS BEEN OCCURRING WITHOUT MY KNOWLEDGE UNTIL IT BECAME OBVIOUS AFTER DRIVING ANOTHER VEHICLE. AS IT TURNS OUT, MY MECHANIC HAS ADVISED THERE IS A COMMON ISSUE WITH CERTAIN BMW ASSEMBLIES THAT THE PROJECTOR LENSES LITERALLY BURN DUE TO HEAT RESULTING IN THE NEED TO REPLACE THE ENTIRE ASSEMBLY. THIS LOSS OF HEADLIGHT INTENSITY RESULTING IN POOR VISIBILITY IS A SIGNIFICANT SAFETY SITUATION AND REQUEST SOMEONE LOOK INTO WHY NO RECALL HAS OCCURRED AS THIS IS OBVIOUSLY A SAFETY CONCERN. I HAVE ENTERED TODAY'S DATE AS INCIDENT DATE AS I AM NOT SURE WHEN DEGRADATION OF THE PROJECTORS BEGAN. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.