HEADLAMP BULB OUT AND UPON REPLACEMENT IT WAS NOTED THE COATED WIRING TO THE XENON SYSTEM TO RIGHT AND LEFT HEADLIGHT IS BRITTLE (THE WIRES PLASTIC COATING IS FALLING OFF)AND IN SOME PLACES EXPOSED WIRING WAS FOUND. ELECTRICAL TAPE NEED TO WRAP THE WIRING TO AVOID POTENTIAL FIRE. LATE NOTICE TO THIS SITE I WAS UNAWARE TO FILE A …
Read full complaint
HEADLAMP BULB OUT AND UPON REPLACEMENT IT WAS NOTED THE COATED WIRING TO THE XENON SYSTEM TO RIGHT AND LEFT HEADLIGHT IS BRITTLE (THE WIRES PLASTIC COATING IS FALLING OFF)AND IN SOME PLACES EXPOSED WIRING WAS FOUND. ELECTRICAL TAPE NEED TO WRAP THE WIRING TO AVOID POTENTIAL FIRE. LATE NOTICE TO THIS SITE I WAS UNAWARE TO FILE A REPORT. OTHERS ALSO HAVE COMPLAINED ABOUT THE SAME ISSUES.
NHTSA ODI #11190961
Mileage unknown · Jan 2, 2017
Exterior Lighting
HEADLIGHTS PROJECT ALMOST NO LIGHT. JUST PAID $130 TO HAVE LENSES CLEANED, NO IMPROVMENT. I THOUGHT IT WAS MY EYES AND COMPLAINED TO OPTHAMOLOGIST TWICE BUT MY EYES ARE OK. I'VE READ THT THE REFLECTOR BOWLS IN THIS MODEL MELT FROM THE HEAT OF THE BULB. I NEED TO REMEDY THIS SITUATION ASAP SO I WILL NOT BE ABLE TO WAIT FOR AN …
Read full complaint
HEADLIGHTS PROJECT ALMOST NO LIGHT. JUST PAID $130 TO HAVE LENSES CLEANED, NO IMPROVMENT. I THOUGHT IT WAS MY EYES AND COMPLAINED TO OPTHAMOLOGIST TWICE BUT MY EYES ARE OK. I'VE READ THT THE REFLECTOR BOWLS IN THIS MODEL MELT FROM THE HEAT OF THE BULB. I NEED TO REMEDY THIS SITUATION ASAP SO I WILL NOT BE ABLE TO WAIT FOR AN INVESTIGATION.
NHTSA ODI #10939058
Mileage unknown · Oct 12, 2016
Exterior Lighting
MY HEADLIGHTS ARE SO DIM AT NIGHT IT IS IMPOSSIBLE TO SEE WITHOUT HIGH BEAMS ON AT ALL TIMES. THE FOG LIGHTS ARE BRIGHTER THAN MY NEW HEADLIGHT BULBS. ONLY SOLUTION SEEMS TO REPLACE THE WHOLE ASSEMBLY BUT AFTER RESEARCHING THIS SEEMS TO BE AN ONGOING ISSUE WITH BMW SO WHY SHOULD I HAVE TO SPEND OVER 1500.00 WHEN THEY SHOULD HAVE…
Read full complaint
MY HEADLIGHTS ARE SO DIM AT NIGHT IT IS IMPOSSIBLE TO SEE WITHOUT HIGH BEAMS ON AT ALL TIMES. THE FOG LIGHTS ARE BRIGHTER THAN MY NEW HEADLIGHT BULBS. ONLY SOLUTION SEEMS TO REPLACE THE WHOLE ASSEMBLY BUT AFTER RESEARCHING THIS SEEMS TO BE AN ONGOING ISSUE WITH BMW SO WHY SHOULD I HAVE TO SPEND OVER 1500.00 WHEN THEY SHOULD HAVE TO REPLACE THEM WITH A RECALL.
NHTSA ODI #10915585
75,000 miles · Apr 6, 2015
Exterior Lighting
HEAD LIGHTS ARE VERY DIM. REFLECTORS ARE BURNED. HEADLIGHTS DO NOT PROJECT ON THE ROAD. CANNOT SEE AT NIGHT. *TR
NHTSA ODI #10703876
80,000 miles · Feb 27, 2015
Exterior Lighting
ZKW HID XENON LOW BEAM REFLECTORS BURNT OR CORRODED CAUSING A SIGNIFICANT DECREASE IN LIGHT OUTPUT THAT BMW WANTS ~$3000 TO FIX. LIGHTS WERE A PREMIUM OPTION AND CANNOT BE CORRECTED BY XENON BULB REPLACEMENT. THE OUTPUT HAS DIMMED AS TO BE UNSAFE. *TR
NHTSA ODI #10691116
Mileage unknown · Feb 1, 2015
Exterior Lighting
THE VERY FIRST TIME I TRIED TO DRIVE THE CAR AT NIGHTTIME TO GO BACK HOME, MY WIFE AND KIDS WERE ON BOARD, AND WE WERE MORE THAN 200 MILES FROM HOME. AFTER I TURNED ON THE LOW-BEAM HEAD LAMPS AND STARTED ROLLING, I COULD BARELY SEE THE ROAD BECAUSE THE HEADLAMPS WERE NOT PROPERLY ILLUMINATING. I FLIPPED THE SWITCH SEVERAL TIMES…
Read full complaint
THE VERY FIRST TIME I TRIED TO DRIVE THE CAR AT NIGHTTIME TO GO BACK HOME, MY WIFE AND KIDS WERE ON BOARD, AND WE WERE MORE THAN 200 MILES FROM HOME. AFTER I TURNED ON THE LOW-BEAM HEAD LAMPS AND STARTED ROLLING, I COULD BARELY SEE THE ROAD BECAUSE THE HEADLAMPS WERE NOT PROPERLY ILLUMINATING. I FLIPPED THE SWITCH SEVERAL TIMES TO NO AVAIL.' PUTTING LIVES AND PROPERTIES AT RISK, I CONTINUED DRIVING UNTIL WE GOT HOME, ALL THE WHILE DRIVING WITH THE HIGH-BEAM LAMPS ON AND APPARENTLY GETTING THE OTHERS DRIVERS ON THE ROAD FUMING. I TOOK THE CAR TO BOTH A LAMP-ADJUSTING STATION AND A BMW DEALER WHERE I WAS TOLD THE LAMPS COULD NEITHER BE ADJUSTED NOR THEIR BULBS MERELY REPLACED BECAUSE THE PROBLEM WAS THE REFLECTOR BOWLS WERE DEFECTIVE AND HAD LOST THEIR ABILITY TO PROJECT LIGHT PROPERLY. I WAS ALSO TOLD THAT BOTH THAT THE REFLECTOR BOWLS COULD NOT BE REPLACED INDIVIDUALLY, AND THAT BOTH (LEFT AND RIGHT SIDES) ASSEMBLIES MUST BE REPLACED AT A TOTAL COST OF MORE THAN $2000.00. MANY POSTERS IN THE BMW FORUMS HAVE VOICED OUT EXACTLY THE SAME PROBLEMS, AND I WISH THAT ALL WOULD FILE A COMPLAINT TO NHTSA. I NEVER DROVE THIS CAR AGAIN AT NIGHT UNTIL I HAD ? IN AUGUST 2014 ? PURCHASED AND FINALLY RECEIVED AND INSTALLED THE HEAD LAMPS ASSEMBLIES IN OCTOBER 2014. I HAVE IN MY POSSESSION THE HEADLAMP ADJUSTING STATION'S INVOICE AND RECOMMENDATION PLUS THE RECEIPT AND INVOICE FOR THE NEW HEADLAMP ASSEMBLIES THAT HAD TO BE SPECIALLY ORDERED FROM GERMANY. ON NOVEMBER 17, 2014, BY CERTIFIED MAIL, I SENT BMW OF NORTH AMERICA MY REQUEST FOR REIMBURSEMENT, BUT I HAVE YET TO RECEIVE A RESPONSE. DUE TO THIS DEFECT WHICH AFFECTS SAFETY, I STRONGLY AND RESPECTFULLY SUGGEST THAT A RECALL BE ISSUED ON THIS BMW MODEL, OR SOME SORT OF DIRECTIVE BE ISSUED FOR BMW TO REIMBURSE THOSE OWNERS 'SUCH AS I' WHO HAD ALREADY REPLACED THEIR LAMP ASSEMBLIES AT THEIR OWN EXPENSE. *TR
NHTSA ODI #10680367
110,000 miles · Nov 6, 2014
Exterior Lighting
MY ZKW HEADLIGHTS DO NOT REFLECT LIGHT ANYMORE. BMW OFFER NO REPLACEMENT REFLECTOR BOWLS FOR THE HEADLIGHT, SO NO FIX IS AVAILABLE EXCEPT REPLACING THE HEADLIGHT ASSEMBLY WITH THE SAME FAULTY ASSEMBLY FROM THE SAME MANUFACTURER. HEADLIGHTS PRODUCE TOO MUCH HEAT AND MELT THE REFLECTORS DEEMING THEM USELESS AND AN EXTREME DANGER…
Read full complaint
MY ZKW HEADLIGHTS DO NOT REFLECT LIGHT ANYMORE. BMW OFFER NO REPLACEMENT REFLECTOR BOWLS FOR THE HEADLIGHT, SO NO FIX IS AVAILABLE EXCEPT REPLACING THE HEADLIGHT ASSEMBLY WITH THE SAME FAULTY ASSEMBLY FROM THE SAME MANUFACTURER. HEADLIGHTS PRODUCE TOO MUCH HEAT AND MELT THE REFLECTORS DEEMING THEM USELESS AND AN EXTREME DANGER. RECALL NEEDED FOR EXTREME SAFETY REASONS. I CAN'T DRIVE MY CAR AT NIGHT ANYMORE. *TR
NHTSA ODI #10653206
156,000 miles · Oct 30, 2014
Electrical SystemExterior Lighting
WIRE LOOSING COATING ON INSIDE OF ADAPTIVE HEADLIGHTS, CAUSING SHORTS OR BROKEN WIRES WHERE THE HEADLIGHTS AND OR TURN SIGNALS WILL FAIL TO WORK. WIRE IS VERY BRITTLE AS THIS IS ALSO ROUGHLY 20 GAUGE WIRE. THIS CAN BE AN EXTREME HAZARD ESPECIALLY AT NIGHT. THIS SEEMS TO BE AFFECTING BMW'S 3/5/6/ SERIES FROM AT LEAST 2004 TO 20…
Read full complaint
WIRE LOOSING COATING ON INSIDE OF ADAPTIVE HEADLIGHTS, CAUSING SHORTS OR BROKEN WIRES WHERE THE HEADLIGHTS AND OR TURN SIGNALS WILL FAIL TO WORK. WIRE IS VERY BRITTLE AS THIS IS ALSO ROUGHLY 20 GAUGE WIRE. THIS CAN BE AN EXTREME HAZARD ESPECIALLY AT NIGHT. THIS SEEMS TO BE AFFECTING BMW'S 3/5/6/ SERIES FROM AT LEAST 2004 TO 2008 FROM MY INDEPENDENT RESEARCH. MANY PICTURES AND COMPLAINTS ON VARIOUS BMW FORUMS TO DOCUMENT THIS PROBLEM. MY PROBLEM OCCURRED WHEN I LOST ONE HEADLIGHT ON MY WAY HOME IN THE DARK AND AN INDICATOR CAME ON TO IDENTIFY A FAULT IN THE HEADLIGHT. ORIGINALLY I THOUGH IT WAS A BULB, CHANGED BULB AND IT STILL DID NOT WORK. FURTHER INVESTIGATION LED TO A BROKEN WIRE INSIDE OF THE HEADLIGHT ASSEMBLY. I FIXED THE BROKEN WIRE AND THEN NOTICED TWO MORE WIRES WHERE THE COATING ON THE WIRE SEEM TO HAVE FLAKED OFF CAUSING BARE WIRE. I ALSO FIXED THOSE WIRES AND ALL WAS WELL. A DAY OR TWO LATER, THE INDICATOR CAME ON AGAIN POINTING TO THE SAME HEADLIGHT. THIS TIME THE TURN SIGNAL WAS OUT. I OPENED THE ACCESS PANEL TO CHECK THE WIRING AND NOW A FORTH WIRE HAS BEEN SEVERED, HOWEVER I CAN NOT FIX IT AS IT IS DOWN PRETTY FAR INSIDE THE HEADLIGHT AND TO REPAIR WOULD REQUIRE REMOVING THE HEADLIGHT AND TAKING IT APART. APPARENTLY BMW USED BIODEGRADABLE WIRE FOR THE HEADLIGHTS?? SOURCE OF THE HEADLIGHT IS BELIEVED TO BE HELLA. SUPPOSEDLY BMW KNOWS ABOUT THE ISSUE BUT UNWILLING TO FIX UNLESS YOU PURCHASE A $800-1500 NEW HEADLIGHT. THIS IS CRAZY FOR A CAR THAT IS 10 YEARS OLD AND WELL MAINTAINED. THIS IS A SAFETY HAZARD AS YOU WILL CAN LOOSE A HEADLIGHT IN THE DARK AND MAYBE BOTH HEADLIGHTS GOING OUT, PLUS THE FACT OF BARE WIRES THAT CAN SHORT AND CAUSE A FIRE. *TR
NHTSA ODI #10651507
126,000 miles · Oct 2, 2014
Exterior Lighting
REFLECTOR BOWLS IN XENON HEADLAMP ASSEMBLY BURN AND DISCOLOR, MAKING LOW BEAM LIGHTING ALMOST NEGLIGIBLE. DOESN'T EVEN SEEM LIGHTS ARE ON. VERY DANGEROUS TO DRIVE AT NIGHT WITHOUT HIGH BEAMS ON. *TR
AS REPORTED BY OTHER OWNERS, THE BI-XENON HEADLIGHTS NO LONGER LIGHT UP THE ROAD. IT IS A SAFETY HAZARD AND IS A KNOWN ISSUE WITH HEADLIGHTS MANUFACTURED BY ZKW ON 2003-2005 BMW 330 MODELS. THE REFLECTOR BOWLS ON THESE UNITS BURN OUT OVER TIME AND REDUCE THE HEADLIGHTS ABILITY TO REFLECT LIGHT. DRIVING AT NIGHT IS LITERALLY NO B…
Read full complaint
AS REPORTED BY OTHER OWNERS, THE BI-XENON HEADLIGHTS NO LONGER LIGHT UP THE ROAD. IT IS A SAFETY HAZARD AND IS A KNOWN ISSUE WITH HEADLIGHTS MANUFACTURED BY ZKW ON 2003-2005 BMW 330 MODELS. THE REFLECTOR BOWLS ON THESE UNITS BURN OUT OVER TIME AND REDUCE THE HEADLIGHTS ABILITY TO REFLECT LIGHT. DRIVING AT NIGHT IS LITERALLY NO BETTER WITH THE HEADLIGHTS ON OR OFF. I HAVE TO RELY ON MY FOG LIGHTS JUST TO SEE ANYTHING. PLEASE LOOK INTO THIS SAFETY ISSUE AS IT IS WIDE-SPREAD. REPLACEMENT OF HEADLIGHTS IS EXPENSIVE AT $1300 EA, THIS HAS TO BE RESOLVED BY BMW IMMEDIATELY. *TR
NHTSA ODI #10628093
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA09019 · Rear Lamp Illumination
Opened Dec 18, 2009 · Closed Sep 28, 2011
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Additional source detail variants (4)
Exterior Lighting
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:brake Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:tail Lights
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
Exterior Lighting:turn Signal
In a letter submitted to the Office of Defects Investigation (ODI) dated August25, 2011, BMWindicated that it will conduct a voluntary recall campaign to remedy the subject vehicles.The issue involves the rear lamps in the vehicles body panel.Through normal vehicle use over time, the rear lamps ground wiring and associated 8-pin connector can experience an increase of the resistance at the electrical contact points.This can lead to intermittent or permanent loss of the rear lamp functions which include tail, brake, and turn signal operation.The recall consists of modifying the rear lamps in the vehicles body panel by adding a secondary ground connection in parallel to the existing primary ground connection.An 8-pin connector that attaches the primary ground wiring to the rear lamp assembly will also be inspected and replaced if necessary.BMW will complete dealer notification in September 2011 and will begin owner notification in October 2011.All 3 series sedans (except for the M3 sedan which utilized a different rear lamp assembly) that were built between September 1, 2001 and March 1, 2005 are included in this recall, totalling approximately 241,000 vehicles.The action taken by BMW is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
PE09036 · Rear Lamp Illumination
Opened Aug 7, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Additional source detail variants (4)
Exterior Lighting
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:brake Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:tail Lights
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
Exterior Lighting:turn Signal
ODI HAS RECEIVED COMPLAINTS FROM CONSUMERS STATING THAT THEIR TAIL LIGHT ASSEMBLY IS NOT PROPERLY ILLUMINATING.THE TAIL LIGHT ASSEMBLY CONSISTS OF A TURN SIGNAL LAMP, A TAIL LAMP AND A BRAKE LAMP.THE COMPLAINANTS HAVE INDICATED THAT THE ISSUE IS WITH AN 8 PIN CONNECTOR AND ASSOCIATED GROUND WIRING.THESE COMPONENTS ARE ALLEGEDLY OVERHEATING AND MELTING DUE TO EXCESSIVE ELECTRICAL CURRENT THAT RUNS THROUGH THE SYSTEM.BMW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) SIB-630306 ON FEBRUARY 2007 TO ADDRESS THE CONDITION BY ADDING SUPPLEMENTARY GROUND WIRING TO THE TAIL LAMP ASSEMBLY.ODI IS UPGRADING TO AN EA TO FURTHER INVESTIGATE THE ISSUE.
DP09002 · Rear Lamp Illumination
Opened Apr 8, 2009 · Closed Aug 6, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Additional source detail variants (5)
Exterior Lighting:back Up Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:brake Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:tail Lights
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
Exterior Lighting:turn Signal
IN MARCH 2009, THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A PETITION FROM MR. MARK PETERS REQUESTING AN INVESTIGATION OF REAR LAMP FAILURE IN MODEL YEAR 2002-2005 BMW 3-SERIES VEHICLES.AN INFORMATION REQUEST LETTER WAS SENT TO BMW IN APRIL 2009, AND ODI RECEIVED BMW'S RESPONSE IN JUNE 2009.THE TAIL LAMP ASSEMBLY CONTAINS LIGHTING FOR THE BRAKE LAMPS, TAIL LAMPS, AND TURN SIGNALS.A TECHNICAL SERVICE BULLETIN (TSB) WAS ISSUED BY BMW IN JANUARY OF 2007 INSTRUCTING SERVICE TECHNICIANS TO EXAMINE AN 8 PIN ELECTRICAL CONNECTOR FOR HEAT-RELATED DAMAGE AND TO INCORPORATE ADDITIONAL GROUND WIRING TO THE CONNECTOR.COMPLAINANTS HAVE ALLEGED THAT SIGNIFICANT THERMAL DAMAGE TO THE CONNECTOR AND ASSOCIATED GROUND WIRING HAS OCCURRED.THIS CONDITION CAN RESULT IN INTERMITTENT OR TOTAL LOSS OF ALL LIGHTING (BRAKE, TAIL, AND TURN SIGNAL) FOR THE EFFECTED REAR LAMP ASSEMBLY.ODI WILL OPEN A PRELIMINARY EVALUATION TO FURTHER EXAMINE THIS ISSUE INCLUDING FURTHER EVALUATING BMW COMPLAINTS AND RELATED WARRANTY DATA.
2004 BMW 3 Series Problems, Complaints & Recalls | Skip That Year
Illustration