Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
4 reports
18,000 miles · Dec 3, 2003
Service Brakes, Hydraulic
RECEIVED RECALL 02V278000 CONCERNING ABS FAILURE. WHILE DRIVING AT 30 MPH, THE CONSUMER SAW SMOKE COMING OUT FROM THE FRONT WHEELS. THE VEHICLE WAS TAKEN TO THE DEALER AND THE DEALER LEARNED THAT A RECALL WAS IN EFFECT. THE DEALER PRESENTED A SET OF TEMPORARY PARTS TO FIX THE PROBLEM. THE CONSUMER WAITED FOR EIGHT MONTHS FOR…
Read full complaint
RECEIVED RECALL 02V278000 CONCERNING ABS FAILURE. WHILE DRIVING AT 30 MPH, THE CONSUMER SAW SMOKE COMING OUT FROM THE FRONT WHEELS. THE VEHICLE WAS TAKEN TO THE DEALER AND THE DEALER LEARNED THAT A RECALL WAS IN EFFECT. THE DEALER PRESENTED A SET OF TEMPORARY PARTS TO FIX THE PROBLEM. THE CONSUMER WAITED FOR EIGHT MONTHS FOR THE REQUIRED PARTS TO ARRIVE THEN THE DEALER PRESENTED A SET OF TEMPORARY PARTS TO FIX THE PROBLEM. *AK *SCC *JB
NHTSA ODI #10044135
26,000 miles · Nov 12, 2003
Tires
VEHICLE LEFT TIRE BLEW OUT WHILE DRIVING.*MR THE VEHICLE EXPERIENCED TWO BLOW OUTS. THE FIRST TIME THE DRIVERS SIDE FRONT TIRE BLEW OUT WHILE DRIVING. THE SECOND TIME THE PASSENGER SIDE FRONT TIRE BLEW OUT WHILE DRIVING. THIS TIRE CAUSED DAMAGE TOT HE FUEL LINE WHICH CAUSED FUEL TO LEAK INTO THE HOT ROTORS. ANOTHER VEHIC…
Read full complaint
VEHICLE LEFT TIRE BLEW OUT WHILE DRIVING.*MR THE VEHICLE EXPERIENCED TWO BLOW OUTS. THE FIRST TIME THE DRIVERS SIDE FRONT TIRE BLEW OUT WHILE DRIVING. THE SECOND TIME THE PASSENGER SIDE FRONT TIRE BLEW OUT WHILE DRIVING. THIS TIRE CAUSED DAMAGE TOT HE FUEL LINE WHICH CAUSED FUEL TO LEAK INTO THE HOT ROTORS. ANOTHER VEHICLE WAS DAMAGED BY THE FLYING RUBBER. THE TIRE WAS SENT TO THE CONSUMER INSURANCE COMPANY FOR AN INDEPENDENT EVALUATION. *NLM
NHTSA ODI #10048193
24,000 miles · Nov 12, 2003
Service Brakes, HydraulicSuspension
WHILE APPLYING THE BRAKES ON A MOTOR HOME AND WITHOUT WARNING BRAKE LIGHT APPEARED ON THE DASHBOARD. ALSO, THERE SMOKE WAS COMING FROM THE LEFT FRONT WHEEL, AND OIL LEAKED FROM IN SIDE OF WHEEL BEARING. HEAT KNOCKED OUT THE ABS BRAKING SYSTEM, CAUSING THE PEDAL TO GO ALL THE WAY DOWN TO THE FLOOR. *AK THE WHEEL BEARINGS…
Read full complaint
WHILE APPLYING THE BRAKES ON A MOTOR HOME AND WITHOUT WARNING BRAKE LIGHT APPEARED ON THE DASHBOARD. ALSO, THERE SMOKE WAS COMING FROM THE LEFT FRONT WHEEL, AND OIL LEAKED FROM IN SIDE OF WHEEL BEARING. HEAT KNOCKED OUT THE ABS BRAKING SYSTEM, CAUSING THE PEDAL TO GO ALL THE WAY DOWN TO THE FLOOR. *AK THE WHEEL BEARINGS WERE IN AN OIL BATH. BOTH SIDES HAD THE OIL BOILING OUT THE CENTER HOLE. THE LEFT FRONT ROTORS HAS BEEN SO HOT THAT IT CHANGED THE COLOR OF THE STEEL. *NLM
NHTSA ODI #10040545
Mileage unknown · Mar 30, 2002
Service Brakes, Hydraulic
FROM DATE OF PURCHASE WE HAD CONCERNS ON HOW BRAKING SYSTEM WORKED. MANUFACTURER HAS TOLD US FOR 2 YEARS BRAKES ARE FINE. MOTOR HOME HAS BEEN IN SHOP FOR BRAKES, IT HAS HAD 4 SETS OF PADS, 2ND SET OF ROTORS, 2ND SET OF CALIBORS, IN LESS THAN 13,000 MILES. THE COACH HAS BEEN UNUSED SINCE APRIL 2001 AND IS NOW IN SHOP, DUE TO HEAT…
Read full complaint
FROM DATE OF PURCHASE WE HAD CONCERNS ON HOW BRAKING SYSTEM WORKED. MANUFACTURER HAS TOLD US FOR 2 YEARS BRAKES ARE FINE. MOTOR HOME HAS BEEN IN SHOP FOR BRAKES, IT HAS HAD 4 SETS OF PADS, 2ND SET OF ROTORS, 2ND SET OF CALIBORS, IN LESS THAN 13,000 MILES. THE COACH HAS BEEN UNUSED SINCE APRIL 2001 AND IS NOW IN SHOP, DUE TO HEATING PROBLEMS OF BRAKES. WE HAVE HAD THE COACH AT OREGON LIGHT TRUCK REPAIR TALKING WITH THEM, THEY FEEL THIS COACH IS EXTREMLY UNDER BRAKED. MANUFACTURE HAS DISCONTUNED CONTACT OTHER THAN ATTORNEYS. WHILE DRIVING COACH BRAKES GET EXTREMLY HOT AND YOU CAN SMELL THEM. WHEN LOOKING AT FRONT BRAKES YOU CAN SEE THE SMOKE BECAUSE THEY ARE SO HOT. BRAKES GET TO SMOKING POINT IN ANY DRIVING CONDITION. MANUFACTURE STATES THAT WHEN BRAKES GET HOT THAT IT IS COMMON. WE AND THE REPAIR PEOPLE (THAT WE HAVE THE COACH AT NOW) DISAGREE WITH BEAVER. FRONT BRAKES WILL GET HOT ENOUGH TO DISCOLOR ALUMUNIM WHEELS. PLEASE CONTACT US WITH ANY FUTHER QUESTIONS. *AK
ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
Consequence & remedy
Consequence: THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
VEHICLE DESCRIPTION: CERTAIN MOTOR HOMES BUILT ON DODGE VAN CHASSIS AND EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE BETWEEN JANUARY 28 AND AUGUST 15, 2000. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Consequence & remedy
Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPAIR THE SEAT BELTS. OWNER NOTIFICATION BEGAN AUGUST 31, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE COMMERCIAL PRODUCTS AT 219-266-8330 OR SMC AT 1-800-344-6332.
VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH MERITOR WABCO PHASE 1, D-VERSION ANTILOCK BRAKE SYSTEM (ABS), FAIL TO COMPLY TO THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." AN INTERNAL DIAGNOSTIC SYSTEM IN THE ABS MAY NOT DETECT AN EXTREME WHEEL SPEED SENSOR AIR GAP. SUCH A CONDITION COULD POSSIBLY OCCUR DURING (1) ORIGINAL ASSEMBLY OR (2) SUBSEQUENT WHEEL END SERVICE.
Consequence & remedy
Consequence: THIS COULD DISABLE THE ANTI-LOCK FUNCTION ON THE AFFECTED WHEEL WITHOUT PROVIDING THE REQUIRED OPERATOR WARNING THAT THE ABS FUNCTION REQUIRES SERVICING.
Remedy: THE ABS ECU WILL BE REMOVED AND REPLACED ON THESE MOTOR HOMES. MERITOR IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY SCHEDULING FOR THIS CAMPAIGN. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING APRIL/MAY 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MERITOR WABCO AT 1-800-535-5560.
VEHICLE DESCRIPTION: CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Consequence & remedy
Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Remedy: DEALERS WILL REPAIR THE SEAT BELTS. OWNER NOTIFICATION BEGAN OCTOBER 18, 20000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SMC CUSTOMER SERVICE AT 1-800-344-6332 OR AM-SAFE AT 1-219-266-8330.
VEHICLE DESCRIPTION: MOTOR HOME CHASSIS EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.
Remedy: DEALERS WILL REPLACE THE DEFECTIVE BALL SOCKETS AND/OR DRAG LINKS. OWNER NOTIFICATION BEGAN MARCH 16, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SMC AT 1-800-344-6332 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.
VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH FABRIC COVERED FRONT OVERHEAD TV FACIA SURROUND. THE FRONT OVERHEAD TELEVISION COULD COME LOOSE FROM ITS MOUNTING, AND FALL FROM THE CABINET.
Consequence & remedy
Consequence: THIS COULD CAUSE PERSONAL INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSTALL A SAFETY RETAINING BRACKET.
VEHICLE DESCRIPTION: 1999 AND 2000 MOTOR HOMES MANUFACTURED BETWEEN APRIL 2 AND NOVEMBER 20, 1999, AND EQUIPPED WITH ABS SYSTEMS WITH BRAKE WIRING HARNESS PART #2505168. THE ELECTRICAL CONNECTOR WHICH CONNECTS TO THE MODULATOR WAS MIS-WIRED CAUSING THE ANTI-LOCK BRAKE MODULATOR TO REACT IMPROPERLY WHILE REGULATING HYDRAULIC PRESSURE TO THE APPROPRIATE WHEEL.
Consequence & remedy
Consequence: FAILURE OF THE ANTI-LOCK BRAKING SYSTEM COULD CAUSE A LOSS OF CONTROL OF THE VEHICLE IN CERTAIN BRAKING SITUATIONS.
Remedy: DEALERS WILL INSTALL A WIRING HARNESS UPDATE, WHICH PROPERLY ROUTES THE ELECTRICAL SIGNAL FROM THE ECU TO THE MODULATOR. 7OWNER NOTIFICATION IS EXPECTED TO BEGIN JULY 13, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAFARI/BEAVER/HARNEY AT 1-800-344-6332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
SQ00013 · Wiring Harness Incorrectly Installed
Opened Jun 20, 2000 · Closed Jul 6, 2000
Status: closed (inferred from source dates) · Electrical System
THE ABS BRAKE SYSTEM WAS INCORRECTLY WIRED
2000 Beaver Patriot Problems, Complaints & Recalls | Skip That Year
Illustration