NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
4 reportsClear category filterMileage unknown · Sep 13, 2026
Engine
The engine water pump on this vehicle is leaking both internally and externally. This vehicle uses the 3.0T (EA839) engine, which uses a vacuum-actuated water pump with a shroud sleeve mechanism. A licensed repair facility diagnosed the failure and estimated repair cost at approximately $5,500. The internal leak path allows coo…
Read full complaint
The engine water pump on this vehicle is leaking both internally and externally. This vehicle uses the 3.0T (EA839) engine, which uses a vacuum-actuated water pump with a shroud sleeve mechanism. A licensed repair facility diagnosed the failure and estimated repair cost at approximately $5,500. The internal leak path allows coolant to migrate into the vacuum system rather than escape as a visible external leak. This means the failure can progress without producing the puddle or drip that owners are trained to look for during routine visual checks, delaying detection until damage has advanced further and the repair has grown more extensive. At the time of failure I observed low coolant warning, which is documented as a symptom of this failure mode. This failure is reported by independent repair shops and owner communities as occurring predominantly in the 40,000-70,000 mile range, which falls just beyond Audi's 4-year/50,000-mile factory warranty. The design is used across multiple Audi models and model years sharing the EA839 2.9T/3.0T engine, including the SQ5, S4, S5, A6, A7, and Q7. This defect is the subject of pending litigation, [XXX] v. Volkswagen Group of America, Inc., Case No. XXX ([XXX], filed XXX, which alleges Audi was aware of the defect since at least 2018. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11763880
Mileage unknown · Jun 18, 2026
Electrical SystemEnginePower Train
While driving at normal operational speeds, the vehicle suffered a sudden, un-commanded, and catastrophic loss of motive power while navigating a live traffic intersection. The transmission completely disengaged all gears without warning, rendering the vehicle entirely stationary and immobilized in the path of oncoming traffic. …
Read full complaint
While driving at normal operational speeds, the vehicle suffered a sudden, un-commanded, and catastrophic loss of motive power while navigating a live traffic intersection. The transmission completely disengaged all gears without warning, rendering the vehicle entirely stationary and immobilized in the path of oncoming traffic. This failure created an immediate, severe safety hazard, exposing the occupants to a high risk of a side-impact or rear-end collision due to the inability to clear the intersection under the vehicle's own power. The vehicle had to be flatbedded to an authorized dealer (Audi - Glenwood Springs). The professional diagnostic evaluation confirmed an internal failure of the transmission assembly and Transmission Control Module (TCM) / Mechatronic unit, requiring a total replacement of the powertrain assembly. The failure occurred at 59,000 miles.
NHTSA ODI #11745096
Mileage unknown · Aug 6, 2025
EnginePower Train
Component/System: Engine and Cooling — Water Pump / Coolant System Vehicle: 2021 Audi SQ5 Engine Code: CWGD Mileage at Failure: 71,000 Date of Incident: 8/6/2025 Audi Denver I’m reporting a known defect affecting my 2021 Audi SQ5 with engine code CWGD. The engine experienced an internal coolant leak from the water pump housing…
Read full complaint
Component/System: Engine and Cooling — Water Pump / Coolant System Vehicle: 2021 Audi SQ5 Engine Code: CWGD Mileage at Failure: 71,000 Date of Incident: 8/6/2025 Audi Denver I’m reporting a known defect affecting my 2021 Audi SQ5 with engine code CWGD. The engine experienced an internal coolant leak from the water pump housing, which is a known issue previously acknowledged by Audi in TSB #19Q5 2022 01, covering earlier 3.0T engines (DEWA/DEWC). Although my engine (CWGD) is not listed in the bulletin, the failure is identical in nature: the plastic thermostat/water pump housing fails internally, leading to coolant loss and potential engine overheating. This issue is widespread among Audi 3.0T engines, including CWGD, and poses a risk of engine failure and overheating. Audi has extended the warranty for earlier engine variants but refuses to cover mine, even though the defect and consequences are the same. This inconsistent coverage leaves owners like me exposed to high repair costs for a clearly known design flaw. I am requesting that NHTSA investigate whether Audi’s CWGD engines should also fall under the scope of the extended warranty or safety defect coverage already applied to DEWA/DEWC engine variants. Audi’s selective VIN or engine code exclusions appear arbitrary and may allow known safety-related failures to go unaddressed. Documentation available: dealer inspection report confirming internal water pump leak, warranty denial letter, and TSB copy.
NHTSA ODI #11678890
2,400 miles · Apr 18, 2021
Electrical SystemEngineSteering
WHILE DRIVING KID SPILLED WATER ON REAR SEAT, WITHIN 5 MIN ALL SENSORS STARTED BEEPING, DISPLAY STARTED TURNING OFF AND ON, STEERING WHEEL VERY HARD TO MANEUVER, WINDOWS OPENING AND CLOSING SPONTANEOUSLY, CAR WOULDN'T GO INTO PARK MODE, ENGINE WOULDN'T TURN OFF (FINALLY DID AFTER PRESSING AND HOLDING IGNITION MULTIPLE TIMES FOR …
Read full complaint
WHILE DRIVING KID SPILLED WATER ON REAR SEAT, WITHIN 5 MIN ALL SENSORS STARTED BEEPING, DISPLAY STARTED TURNING OFF AND ON, STEERING WHEEL VERY HARD TO MANEUVER, WINDOWS OPENING AND CLOSING SPONTANEOUSLY, CAR WOULDN'T GO INTO PARK MODE, ENGINE WOULDN'T TURN OFF (FINALLY DID AFTER PRESSING AND HOLDING IGNITION MULTIPLE TIMES FOR SEVERAL SECONDS). AUDI DEALER STATES MODULE UNDERNEATH THE REAR SEAT IS CORRODED. IT'S A BRAND NEW CAR (LEASED < 3 MONTHS AGO). TERRIFIED TO DRIVE IT AGAIN AS IT APPEARS TO BE A SAFETY ISSUE AND IS HAZARDOUS FOR MY FAMILY.
NHTSA ODI #11408669
Official recalls
5Oct 5, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Audi A8, RS7, RS6 Avant, RS5 Sportback, RS5 Coupe, Q8, Q7, Q5 Sportback, S4 Sedan, Q5, A7, A6, A6 Allroad, A5 Sportback, A5 Coupe, A5 Cabrioleet, A4 Sedan, A4 Allroad, E-Tron Sportback Quattro, SQ7, S5 Cabriolet, E-Tron Quattro, SQ8, SQ5 Sportback, SQ5, S8, S7, S6 Sedan, S5 Sportback, S5 Coupe, 2022 E-Tron GT, and 2021-2022 RSQ8 vehicles. Due to a software issue, a blank or black screen may be displayed instead of the rearview camera image when the vehicle is placed in reverse gear. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A blank rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the infotainment unit software, free of charge. Owner notification letters were mailed October 25, 2022. Owners may contact Audi's customer service at 1-800-253-2834. Volkswagen's number for this recall is 91DZ.
Jan 26, 2022
Volkswagen Group of America, Inc. (Audi) is recalling certain 2019-2021 Audi A5 Sportback, RS5 Coupe, RS5 Sportback, S5 Sportback, 2020-2021 A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A6 Allroad, A6 Sedan, A7, A8, Q5, S4 Sedan, S5 Coupe, S5 Cabriolet, S6 Sedan, S7, S8, SQ5, 2021 Q5 Sportback, Q7, Q8, RS6 Avant, RS7, RSQ8, SQ5 Sportback, SQ7, and SQ8 vehicles. The rear axle alignment may not have been inspected after the repairs for Recall 21V-295 (42L1) were performed.
Consequence & remedy
Consequence: Rear axle misalignment may cause premature or uneven tire wear, increasing the risk of a crash.
Remedy: Dealers will inspect the rear axle, adjust the alignment as necessary, and replace any prematurely or unevenly worn tires, free of charge. Owner notification letters were mailed March 3, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 42L5.
Additional source detail variants (2)
Tires
Volkswagen Group of America, Inc. (Audi) is recalling certain 2019-2021 Audi A5 Sportback, RS5 Coupe, RS5 Sportback, S5 Sportback, 2020-2021 A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A6 Allroad, A6 Sedan, A7, A8, Q5, S4 Sedan, S5 Coupe, S5 Cabriolet, S6 Sedan, S7, S8, SQ5, 2021 Q5 Sportback, Q7, Q8, RS6 Avant, RS7, RSQ8, SQ5 Sportback, SQ7, and SQ8 vehicles. The rear axle alignment may not have been inspected after the repairs for Recall 21V-295 (42L1) were performed.
Consequence: Rear axle misalignment may cause premature or uneven tire wear, increasing the risk of a crash.
Remedy: Dealers will inspect the rear axle, adjust the alignment as necessary, and replace any prematurely or unevenly worn tires, free of charge. Owner notification letters were mailed March 3, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 42L5.
SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
Volkswagen Group of America, Inc. (Audi) is recalling certain 2019-2021 Audi A5 Sportback, RS5 Coupe, RS5 Sportback, S5 Sportback, 2020-2021 A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A6 Allroad, A6 Sedan, A7, A8, Q5, S4 Sedan, S5 Coupe, S5 Cabriolet, S6 Sedan, S7, S8, SQ5, 2021 Q5 Sportback, Q7, Q8, RS6 Avant, RS7, RSQ8, SQ5 Sportback, SQ7, and SQ8 vehicles. The rear axle alignment may not have been inspected after the repairs for Recall 21V-295 (42L1) were performed.
Consequence: Rear axle misalignment may cause premature or uneven tire wear, increasing the risk of a crash.
Remedy: Dealers will inspect the rear axle, adjust the alignment as necessary, and replace any prematurely or unevenly worn tires, free of charge. Owner notification letters were mailed March 3, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 42L5.
Dec 8, 2021
Volkswagen Group of America, Inc. (Audi) is recalling certain 2021-2022 Q5 Sportback, SQ5 Sportback, 2018-2022 Q5, and SQ5 vehicles. A liquid spill in the rear seat, or water ingress from an insufficient body seam underneath the vehicle may allow liquid to penetrate the gateway control module, causing it to shutdown.
Consequence & remedy
Consequence: A gateway control module shutdown will suddenly reduce engine power, increasing the risk of a crash.
Remedy: Dealers will install a protective cover on the gateway control module and seal an underbody seam as necessary, free of charge. Owner notification letters were mailed January 21, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 90S9.
Additional source detail variants (2)
Structure:body
Volkswagen Group of America, Inc. (Audi) is recalling certain 2021-2022 Q5 Sportback, SQ5 Sportback, 2018-2022 Q5, and SQ5 vehicles. A liquid spill in the rear seat, or water ingress from an insufficient body seam underneath the vehicle may allow liquid to penetrate the gateway control module, causing it to shutdown.
Consequence: A gateway control module shutdown will suddenly reduce engine power, increasing the risk of a crash.
Remedy: Dealers will install a protective cover on the gateway control module and seal an underbody seam as necessary, free of charge. Owner notification letters were mailed January 21, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 90S9.
Electrical System:body Control Module/bcm
Volkswagen Group of America, Inc. (Audi) is recalling certain 2021-2022 Q5 Sportback, SQ5 Sportback, 2018-2022 Q5, and SQ5 vehicles. A liquid spill in the rear seat, or water ingress from an insufficient body seam underneath the vehicle may allow liquid to penetrate the gateway control module, causing it to shutdown.
Consequence: A gateway control module shutdown will suddenly reduce engine power, increasing the risk of a crash.
Remedy: Dealers will install a protective cover on the gateway control module and seal an underbody seam as necessary, free of charge. Owner notification letters were mailed January 21, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 90S9.
Aug 5, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Additional source detail variants (2)
Seat Belts:rear/other:retractor
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Seat Belts
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen ID4, Audi A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A5 Sportback, A6 Allroad, A6 Sedan, A7, A8, E-Tron Quattro, E-Tron Sportback Quattro, Q3, Q5, Q5 Sportback, Q7, Q8, RS5 Sportback, RS5 Coupe, RS6 Avant, RS7, RSQ8, S4 Sedan, S5 Cabriolet, S5 Coupe, S5 Sportback, S6 Sedan, S7, S8, SQ5, SQ5 Sportback, SQ7, SQ8, and 2021-2022 S3 Sedan vehicles. The rear seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect, and replace as necessary, the middle-rear seat belt assemblies, free of charge. Owner notification letters were mailed August 27, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298 and Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69CR (VW) and 69CS (Audi).
Apr 26, 2021
Volkswagen Group of America, Inc. (Audi) is recalling certain 2021 Q7, Q8, Q5 Sportback, SQ5 Sportback, RS6 Avant, RS7, RS Q8, 2020-2021 Audi S6 sedan, Q5, A8, S8, A7, A6 Allroad, A5 Cabriolet, A4 sedan, A4 Allroad, SQ5, S7, A6 sedan, S5 coupe, S4 sedan, S5 Cabriolet, A5 coupe, 2019-2021 RS5 coupe, A5 Sportback, S5 Sportback, RS5 Sportback vehicles. The lock nut on the trailing arm of the rear axle may break due to stress corrosion.
Consequence & remedy
Consequence: A broken lock nut may misalign the rear axle, causing a loss of control and increasing the risk of a crash.
Remedy: Dealers will replace the lock nuts and, if necessary, the associated bolts, free of charge. Owner notification letters were mailed June 4, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 42L1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration