2013 Audi S5

NHTSA Safety Complaint DraftVehicle Information:Year/Make/Model: 2013 Audi S5 Premium Plus CoupeVIN: [XXX]: Power Train / Transmission (7-Speed Dual-Clutch S-Tronic / DSG)Description of Safety Defect:I am writing to report a severe, recurring safety defect regarding the 7-speed dual-clutch transmission in my 2013 Audi S5. The vehicle is experiencing catastrophic transmission issues, including sudden power loss, violent juddering, erratic shifting, and abruptly entering "limp mode" without warning.This issue presents an immediate and severe safety hazard. When the transmission abruptly loses power or forces the vehicle into limp mode while driving at highway speeds, it leaves the driver completely unable to accelerate or safely keep pace with surrounding traffic. This sudden, unpredictable loss of propulsion significantly increases the risk of a high-speed rear-end collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I had a very pricey service performed on my vehicle and during that service they said there was a service bulletin or recall that required a software upgrade for the transmission (Audi of El Paso, TX). Once that occurred, my transmission would shift very hard especially going from 1st to 2nd gear or downshifting from 2nd to 1st gear. My service advisor told me that my vehicle had to learn again and that it would smooth out in time. It never has. My vehicle with only 79,000 miles on it should certainly not be having any transmission issues, especially since they were non-existent until the software upgrade was applied. I have researched the issue and have found that it is a common and widely known issue in Audis with similar electronic transmissions. I was able to find well over a hundred Audi owners who documented the same issues. Due to this update my vehicle showed simultaneous warning for a TPMS failure and gearbox failure.

TL* THE CONTACT OWNS A 2013 AUDI S5. THE CONTACT STATED THAT WHILE HIS WIFE WAS DRIVING AT VARIOUS SPEEDS, AN ABNORMAL ODOR WAS INSIDE THE VEHICLE. THE CONTACT'S WIFE DROVE THE VEHICLE TO THE RESIDENCE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED FUEL LEAKING IN THE ENGINE COMPARTMENT. GREEN AUDI (3881 WABASH AVE, SPRINGFIELD, IL 62711) WAS CONTACTED AND INFORMED THE CONTACT THAT AN APPOINTMENT SHOULD BE SCHEDULED TO HAVE THE VEHICLE DIAGNOSED. THE VIN WAS NOT SUBJECTED TO A RECALL. THE VEHICLE WAS NOT SEEN OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V019000 (FUEL SYSTEM, GASOLINE) AS A POSSIBLE SOLUTION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 56,618.

MY CAR WENT INTO LIMP MODE WHERE THE TRANSMISSION DOESN'T ENGAGE AND COME TO FIND OUT IT WAS THE MECHATRONIC UNIT IN THE TRANSMISSION AND A VERY WELL KNOWN PROBLEM. THE CAR WOULDN'T MOVE WHEN I WAS ON A BUSY ROAD. IT SAID CONTINUE TO DRIVE BUT I COULDN'T. IT HAPPENED AT 65K MILES. I HAD IT REBUILT FOR OVER $2000 AND THE CAR IS VERY WELL MAINTAINED.

MY VEHICLE AS WELL AS MANY AUDIS WITH THE MECHATRONIC SYSTEM ARE HAVING AN ISSUE THAT PRESENT A ERROR, " MECHATRONIC FAILURE TPMS GEARBOX MALFUNCTION). IT OFTEN EITHER NOT DRIVABLE, EVEN WHEN IN TRAFFIC OR DRIVES AT A SNAIL'S PACE WHEN ATTEMPTING TO EXIT TRAFFIC. AUDI CORPORATE SAID A RECALL IS ONLY DONE WHEN THE NHTSA FEEL THAT'S IT A ISSUE THAT CAN CALLS SAFETY &/OR DEATH. THIS SEEM TO EFFECT, FROM MY RESEARCH, 2010 - 2014 AUDI S4, S5 AND A5 MODEL [N THE USA AND THERE ARE SOME EUROPE COMPLAINTS, WHICH I HAVE FOUND AS WELL] MANUFACTORED AT A PARTICULAR PLANT OR PROVIDER. THIS TYPE OF MALFUNCTION CAN CERTAINLY CAUSE 'LOSS OF LIFE' AS IT OCCURS IN TRAFFIC. I HAPPEN TO LIVE IN METRO ATLANTA GA, WITH OUR FAST PACE TRAFFIC, ITS A SERIOUS ISSUE. THERE ABSOLUTELY SHOULD BE A RECALL. THE COST TO REPAIR CAN BE UP TO $15K. THERE IS NO WAY THIS SHOULD HAPPED TO A $60-$75 HIGH-END VEHICLE. HAVE VIDEO'S OF THE DASHBOARD WITH THE ERROR AND CAN UPLOAD TO YOU. I WAS OFFERED 15% ON THE REPAIR, WHICH IS REALLY AN INSULT. PLEASE LOOK INTO THIS ISSUE AND ITS NOT HARD TO FIND OTHERS WITH THIS ISSUE. I PRAY FOR SOME RELIEF IN THE FORM OF A RECALL. IT HAS BEEN HAPPENING SINE 2010, FROM WHAT I HAVE LEARNED.