NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
15 reports195,800 miles · Mar 26, 2016
Fuel/propulsion System
WHILE DRIVING MY ENGINE LIGHT CAME ON, AND I SMELLED GAS. I BROUGHT THE CAR TO A SHOP TO HAVE IT REPAIRED. THERE IS A GAS LEAK FROM ROLLOVER VALVE ON THE GAS TANK. WAS RECALLED IN 2009, REPAIRED BY THE DEALER. I HAVE JUST BOUGHT THE CAR USED AND FOUND THAT THE SAME PROBLEM IS OCCURRING AGAIN. WITH SOME RESEARCH I FOUND OUT THA…
Read full complaint
WHILE DRIVING MY ENGINE LIGHT CAME ON, AND I SMELLED GAS. I BROUGHT THE CAR TO A SHOP TO HAVE IT REPAIRED. THERE IS A GAS LEAK FROM ROLLOVER VALVE ON THE GAS TANK. WAS RECALLED IN 2009, REPAIRED BY THE DEALER. I HAVE JUST BOUGHT THE CAR USED AND FOUND THAT THE SAME PROBLEM IS OCCURRING AGAIN. WITH SOME RESEARCH I FOUND OUT THAT THE DEALER FIXED THE PROBLEM WITH EPOXY.
NHTSA ODI #10851719
162,000 miles · Aug 24, 2015
Electrical SystemFuel/propulsion SystemFire
TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. WHILE DRIVING AT AN UNKNOWN SPEED, BURNING FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT A FIRE ERUPTED NEAR THE TURN SIGNALS AND THE STEERING COLUMN AREA. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH WATER. THE VEHICLE WAS TOWED TO A REPAIR…
Read full complaint
TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. WHILE DRIVING AT AN UNKNOWN SPEED, BURNING FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT A FIRE ERUPTED NEAR THE TURN SIGNALS AND THE STEERING COLUMN AREA. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH WATER. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND LATER TO A DEALER FOR INSPECTION AND DIAGNOSTIC TESTING. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 08V157000 (FUEL SYSTEM, GASOLINE), 06V198000 (ELECTRICAL SYSTEM), AND 04V133000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.
NHTSA ODI #10758950
95,000 miles · Sep 15, 2014
StructureVisibility
WHILE DRIVING DOWN THE INTERSTATE THE MOON ROOF SPONTANEOUSLY EXPLODED! IT WAS NOT HIT BY ANYTHING, IT JUST EXPLODED. I HAVE DONE A LITTLE RESEARCH AND HAVE FOUND THAT AUDI HAS HAD A PROBLEM IN THE PAST WITH FAULTY GLASS CAUSING THEIR MOON ROOFS TO EXPLODE AND HAD TO ISSUED A RECALL FOR THIS PROBLEM. I CONTACTED AUDI AND REQU…
Read full complaint
WHILE DRIVING DOWN THE INTERSTATE THE MOON ROOF SPONTANEOUSLY EXPLODED! IT WAS NOT HIT BY ANYTHING, IT JUST EXPLODED. I HAVE DONE A LITTLE RESEARCH AND HAVE FOUND THAT AUDI HAS HAD A PROBLEM IN THE PAST WITH FAULTY GLASS CAUSING THEIR MOON ROOFS TO EXPLODE AND HAD TO ISSUED A RECALL FOR THIS PROBLEM. I CONTACTED AUDI AND REQUESTED THEM TO REPLACE MY MOON ROOF. THEY GAVE ME THE RUN AROUND AND THEN UNFORTUNATELY, DECIDED THAT THEY ARE UNWILLING TO ASSIST ME WITH THE REPLACEMENT OF MY OWN MOON ROOF BECAUSE IT WAS NOT ONE OF THE MODELS RECALLED AND MY CAR IS OVER 10 YEARS OLD SO IT IS OUT OF WARRANTY. THANK GOD MY CHILDREN WERE NOT IN THE CAR TO BE INJURED BY EXPLODING GLASS AND THANK GOD IT WAS 5:00 IN THE MORNING SO THERE WAS NO TRAFFIC AROUND FOR THE EXPLOSION TO HAVE CAUSED AN ACCIDENT! AUDI HAS TREATED THIS LIKE IT'S NOT BIG DEAL, SOMETHING THAT SHOULD BE EXPECTED TO HAPPEN AFTER OWNING ONE OF THEIR CARS FOR 10 YEARS, AND THAT IT IS MY PROBLEM FOR HAVING AN "OLD" CAR. SHAME ON AUDI FOR NOT TAKING RESPONSIBILITY FOR THIS! *TR
NHTSA ODI #10633244
38,840 miles · Aug 30, 2014
EngineVehicle Speed ControlCrash
ON AUG. 09 2014 COMMING TO A STOP I APPLIED THE BRAKES. ALL OF A SUUDEN THE ENGINE STARTED TO ACCELERATE UNCONTROLABLE TRYING TO MOVE THE CAR FORWARD. I PRESSED THE BRAKES AS HARD AS I COULD AND I STOPED THE CAR AFTER I HIT THE CAR IN FRONT WHEN I WAS ABLE TO TURN THE IGNITION KEY OFF. THIS SUDDEN UNINTENDED ACCELERATION MALFUN…
Read full complaint
ON AUG. 09 2014 COMMING TO A STOP I APPLIED THE BRAKES. ALL OF A SUUDEN THE ENGINE STARTED TO ACCELERATE UNCONTROLABLE TRYING TO MOVE THE CAR FORWARD. I PRESSED THE BRAKES AS HARD AS I COULD AND I STOPED THE CAR AFTER I HIT THE CAR IN FRONT WHEN I WAS ABLE TO TURN THE IGNITION KEY OFF. THIS SUDDEN UNINTENDED ACCELERATION MALFUNCTION ALSO HAPPENED ON JAN. 29, 2006 AND JAN. 30, 2011, ALSO REPORTED TO NHTSA AT THOSE TIMES. IT IS A LIFE SAFETY ISSUE AND SHOULD BE ADDRESSED A.S.A.P. THE MANUFACTURER REFUSE TO TAKE ANY ACTION. *TR
NHTSA ODI #10629613
38,840 miles · Aug 11, 2014
EngineVehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT THE BRAKES FAILED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THE FAILURE COULD NOT BE DUPLICATED. WHILE DRIVING 30 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE DID NOT STOP. THE FAILURE CAUSED THE CONTACT TO REAR END ANOTH…
Read full complaint
TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT THE BRAKES FAILED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THE FAILURE COULD NOT BE DUPLICATED. WHILE DRIVING 30 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE DID NOT STOP. THE FAILURE CAUSED THE CONTACT TO REAR END ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING ON THE RESULTS OF THE DIAGNOSTIC TEST FROM THE DEALER. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 10,848. UPDATED 09/15/14*LJ THE CONSUMER STATED THE FAILURE IS UNINTENDED ACCELERATION NOT BRAKE FAILURE. MANUFACTURER REFUSED ASSISTANCE. UPDATED 1/16/15 *JS
NHTSA ODI #10621341
102,000 miles · Jun 27, 2014
SeatsFire
TL * THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A FIRE ERUPTED IN THE VEHICLE DUE TO THE HEATED SEATS. THE VEHICLE WAS TAKEN TO DEALER WHERE THE REPAIRS WERE UNKNOWN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000 AND T…
Read full complaint
TL * THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A FIRE ERUPTED IN THE VEHICLE DUE TO THE HEATED SEATS. THE VEHICLE WAS TAKEN TO DEALER WHERE THE REPAIRS WERE UNKNOWN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 108,000.
NHTSA ODI #10606513
Mileage unknown · Apr 30, 2012
SuspensionTires
THE SUSPENSION IN FRONT TIRES KEEP GOING OUT. AND WHEN I DID THE RESEARCH AS TO HOW TO FIX THIS PROBLEM ON AN AUDI IT STATED THAT THEY ARE FAMILIAR WITH THE PROBLEM AND ARE OF THIS PROBLEM BUT SEE ANY REASON AS TO WHY THEY SHOULD FIX IT. EVEN THOUGH THE PROBLEM EXISTED WHEN THE CAR REACHED A CERTAIN PART. *JS
NHTSA ODI #10456964
27,745 miles · Feb 7, 2011
Unknown Or Other
SUDDEN UNINTENDED ACCELERATION , COMING TO A STOP SIGN, APPLYING THE BRAKES, THE ENGINE STARTED TO ACCELERATE UNCONTROLLED. I WAS ABLE TO STOP IT AFTER I PUSHED THE CAR IN FRONT. I SHIFTED IN PARK, THE ENGINE CONTINUED TO ACCELERATE AT HIGHER RATE WHEN I WAS ABLE TO TURN THE KEY OFF. *LN
NHTSA ODI #10380950
27,745 miles · Jan 31, 2011
Vehicle Speed ControlCrashInjury
TL*THE CONTACT OWNS A 2004 AUDI ALLROAD 4.2(NA). WHILE COMING TO A STOP AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE CONTINUED TO MOVE FORWARD. THE RPMS INCREASED RAPIDLY AND THE CONTACT REAR ENDED THE VEHICLE IN FRONT. ONE PERSON WAS INJURED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CONTACT PLANNED TO WRITE THE MANUFACTURE…
Read full complaint
TL*THE CONTACT OWNS A 2004 AUDI ALLROAD 4.2(NA). WHILE COMING TO A STOP AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE CONTINUED TO MOVE FORWARD. THE RPMS INCREASED RAPIDLY AND THE CONTACT REAR ENDED THE VEHICLE IN FRONT. ONE PERSON WAS INJURED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CONTACT PLANNED TO WRITE THE MANUFACTURER. THE FAILURE MILEAGE WAS 27,745. UPDATED 03/15/11*LJ UPDATED 12/30/11 *CN
NHTSA ODI #10379663
46,000 miles · Apr 5, 2010
Vehicle Speed Control
TL* THE CONTACT OWNS A 2004 AUDI QUATTRO 4 (N/A) THE CONTACT STATED THAT VEHICLE GAS PEDAL STICKS. THE FIRST OCCURRENCE WAS ABOUT 3 YEARS AGO. THE CONTACT WAS ENTERING HIGHWAY GOING ABOUT 60 MPH ON A DRY DAY , HE TOOK HIS FOOT OFF THE ACCELERATOR AND THE VEHICLE JUST "TOOK OFF". HE MANAGED TO GET THE VEHICLE STOPPED. THE PRO…
Read full complaint
TL* THE CONTACT OWNS A 2004 AUDI QUATTRO 4 (N/A) THE CONTACT STATED THAT VEHICLE GAS PEDAL STICKS. THE FIRST OCCURRENCE WAS ABOUT 3 YEARS AGO. THE CONTACT WAS ENTERING HIGHWAY GOING ABOUT 60 MPH ON A DRY DAY , HE TOOK HIS FOOT OFF THE ACCELERATOR AND THE VEHICLE JUST "TOOK OFF". HE MANAGED TO GET THE VEHICLE STOPPED. THE PROBLEM HAS REOCCURED ON AND OFF SINCE THEN. THE VEHICLE WAS TAKEN TO DEALER AND THE TECHNICIAN STATED THAT THE PROBLEM WAS THE FLOOR MATS. THE MATS WERE RE-ADJUSTED AND THE PROBLEM CONTINUED. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND WAS STILL AT THE DEALER AT THE TIME OF THE COMPLAINT. AUDI HAS CALLED IN AN EXPERT TO DIAGNOSE THE PROBLEM. THE FAILURE MILEAGE WAS APPROXIMATELY 46,000. THE CURRENT MILEAGE IS APPROXIMATELY 110,000. THE VIN UNKNOWN.
NHTSA ODI #10323748
Official recalls
3Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Illustration