Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 12 of 17 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel/propulsion System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
17 reports
Mileage unknown · Oct 25, 2005
Engine And Engine CoolingPower Train
DT:THE VEHICLE HAS DEVELOPED A CAM SHAFT GASKET LEAK AT ONLY 60,000 MILES. ALSO, ONE OF THE CV AXLES CRACKED. THERE WHERE NO PROBLEMS WITH THE VEHICLE PRIOR TO THE DEALERSHIP FINDING THESE PROBLEMS. THE DEALERSHIP DESCRIBED TO THE CONTACT THAT THIS PROBLEM WITH THE CAM SHAFT GASKET COULD CAUSE A MAJOR OIL LEAK. IF THIS WERE T…
Read full complaint
DT:THE VEHICLE HAS DEVELOPED A CAM SHAFT GASKET LEAK AT ONLY 60,000 MILES. ALSO, ONE OF THE CV AXLES CRACKED. THERE WHERE NO PROBLEMS WITH THE VEHICLE PRIOR TO THE DEALERSHIP FINDING THESE PROBLEMS. THE DEALERSHIP DESCRIBED TO THE CONTACT THAT THIS PROBLEM WITH THE CAM SHAFT GASKET COULD CAUSE A MAJOR OIL LEAK. IF THIS WERE TO OCCUR THE ENGINE COULD SEIZE BECAUSE OF LOSS OF OIL. THE VEHICLE HAS NOT CURRENTLY BEEN REPAIRED BECAUSE OF THE COST.*AK
NHTSA ODI #10140732
55,700 miles · Mar 24, 2005
Power Train
OWNER COMPLAINED ABOUT A TRANSMISSION PROBLEM. OWNER WAS DRIVING THE VEHICLE AND WHEN CHANGING GEARS THE VEHICLE WOULD NOT GO INTO DRIVE. IT WAS STUCK IN REVERSE. OWNER TOOK THE VEHICLE TO THE DEALER, AND WAS TOLD THAT IT WAS A SEALED UNIT, AND THERE WAS NO WAY THEY COULD REPAIR THE DEFECT. MANUFACTURER SENT A REGIONAL REPRE…
Read full complaint
OWNER COMPLAINED ABOUT A TRANSMISSION PROBLEM. OWNER WAS DRIVING THE VEHICLE AND WHEN CHANGING GEARS THE VEHICLE WOULD NOT GO INTO DRIVE. IT WAS STUCK IN REVERSE. OWNER TOOK THE VEHICLE TO THE DEALER, AND WAS TOLD THAT IT WAS A SEALED UNIT, AND THERE WAS NO WAY THEY COULD REPAIR THE DEFECT. MANUFACTURER SENT A REGIONAL REPRESENTATIVE, WHO OFFERED TO ABSORB 75% OF THE REPAIR COST. *AK *NM
NHTSA ODI #10111646
47,900 miles · Oct 20, 2004
EquipmentEquipment Adaptive/mobilityFuel System, Other
2001 AUDI A6 ALLROAD HAS HAD A BRAKE/THROTTLE LAG ISSUE SINCE IT WAS PURCHASED. THE CAR CAN BE EXTREMELY DANGEROUS TO DRIVE. MY WIFE WAS DRIVING THE ALLROAD AND SHE TOLD ME THAT SHE WAS ALMOST HIT BY AN ONCOMING VEHICLE WHEN THE CAR DID NOT "GO" AS SHE EXPECTED IT TOO, BASED ON HER THROTTLE INPUTS. AT ANOTHER INTERSECTION SHE L…
Read full complaint
2001 AUDI A6 ALLROAD HAS HAD A BRAKE/THROTTLE LAG ISSUE SINCE IT WAS PURCHASED. THE CAR CAN BE EXTREMELY DANGEROUS TO DRIVE. MY WIFE WAS DRIVING THE ALLROAD AND SHE TOLD ME THAT SHE WAS ALMOST HIT BY AN ONCOMING VEHICLE WHEN THE CAR DID NOT "GO" AS SHE EXPECTED IT TOO, BASED ON HER THROTTLE INPUTS. AT ANOTHER INTERSECTION SHE LIFTED HER FOOT OFF OF THE GAS, REAPPLIED THE GAS AND THIS TIME THE CAR WENT SO FAST THAT SHE ALMOST HIT THE CAR IN FRONT OF HER AT THE UPCOMING INTERSECTION. SHE TOLD ME THAT SHE WAS ALMOST CRYING BECAUSE "I DID NOT TELL HER THE CAR 'DROVE LIKE THAT!'" THE PROBLEMS ARE: 1). AOA ISSUED A TECHNICAL SERVICE BULLETIN DATED SEPTEMBER 9TH OF 2004 ON THIS ISUE., NOT A RECALL. 2) I COMPLAINED FOR OVER 1 YEAR ABOUT THIS PROBLEM TO THE DEALER BEFORE THE ECU WAS REPLACED ON MAY 15TH OF 2004. (I HAVE COPIES OF LETTERS SENT TO AUDI) 3) THE NEW CONTROL UNIT PUT IN THE CAR IN MAY OF 2004 DOES NOT WORK CORRECTLY EITHER, BY REASONABLE SPECIFICATIONS, OR ELSE MY WIFE WOULD NOT HAVE HAD THIS PROBLEM. 4) A "JUDDER HAPPENS WHEN TURING SLOWLY AND GIVING THE CAR GAS, TOO. THIS MAY BE THE REASON THAT THE VEHICLE HAS HAD TO HAVE SEALS REPLACED IN THE MOTOR AND TRANSMISSION, TOO, FROM THE ELECTRICAL MISCOMMUNICATIONS BETWEEN THE ECU AND THE TRANSMISSION. 5) THIS IS AN EXTREMELY DANGEROUS PROBLEM AND NEEDS TO BE FIGURED OUT BY AOA AS WELL AS UNDER A NATIONAL RECALL CAMPAIGN. 6) AUDI TOLD ME TODAY THAT THE CAR IS "PERFORMING TO SPECS," WHICH IS A LIE. THIS CAR HAS BEEN TO THE DEALERSHIP OVER 100 DOCUMENTED TIMES, BUT AOA JUST SAYS, "WE ARE SURE THE CAR CAN BE REAPAIRED UNDER YOUR NEW CAR/CERTIFIED USED CAR WARRANTY, THANK YOU!"
NHTSA ODI #10096109
49,400 miles · Oct 20, 2004
Suspension
2001 AUDI A6 ALLROAD. AFTER THE CAR SITS FOR A PERIOD OF 5+DAY UNDRIVEN, THE AIRBAG SUSPENSION OF THIS CAR LEAKS, LENDING THE CAR UNDRIVEABLE UNLESS THE POWER SYSTEM FROM THE CAR CAN AUTO LEVEL THE VEHICLE AGAIN. NO FAULT CODES ARE SHOWN IN THE ECU. II HAVE PICTURES OF THE VEHICLE WITH THE SUSPENSION NOT LEVEL. DANGEROUS! THE DE…
Read full complaint
2001 AUDI A6 ALLROAD. AFTER THE CAR SITS FOR A PERIOD OF 5+DAY UNDRIVEN, THE AIRBAG SUSPENSION OF THIS CAR LEAKS, LENDING THE CAR UNDRIVEABLE UNLESS THE POWER SYSTEM FROM THE CAR CAN AUTO LEVEL THE VEHICLE AGAIN. NO FAULT CODES ARE SHOWN IN THE ECU. II HAVE PICTURES OF THE VEHICLE WITH THE SUSPENSION NOT LEVEL. DANGEROUS! THE DEALERSHIP CANNOT RECREATE THIS OCCURANCE WHICH HAS BEEN PHOTOGRAPHED ON MORE THAN ONE OCCASION. THEREFORE, I AM LEFT TO DRIVE A CAR WITH A LEAKING SUSPENSION, WHICH MAY RESULT IN IMPROPER HANDLING, DRIVING OR SUSPENSION FAILURE. THIS IS NOT ACCEPTABLE FOR THIS TO BE OCCURRING. AOA TOLD ME TODAY THAT THE CAR IS "PERFORMING TO SPECIFICATION," WHICH IS A LIE, OR ALL OF THESE A6 ALLROADS WOULD HAVE LLEAKING SUSPENSIONS.
NHTSA ODI #10096106
53,250 miles · Apr 26, 2004
EquipmentFuel System, Other
FAILURE OF FUEL GAUGE LEFT ME, ME WIFE AND TWO CHILDREN ON THE SIDE OF THE INTERSTATE IN ATLANTA, GA. FUEL LEVEL SENDING UNIT WAS REPLACED IN RECALL NOTICE IN DEC, 2001. THE REPLACEMENT PART FAILED.*AK
NHTSA ODI #10067810
45,350 miles · Apr 22, 2004
Vehicle Speed Control
THIS CAR HESITATES UPON ACCELERATION, REQUIRING ME TO RE-APPLY THE THROTTLE IN ORDER HAVE "NORMAL ACCLERATION." I HAVE COMPLAINED TO THE DEALERSHIP FOR OVER 1 YEAR ABOUT THIS PROBLEM. I AM AFRAID TO DRIVE THE VEHICLE DUE TO MY BEING HANDICAPPED; IF I GET HIT, I MAY DIE DUE TO MY SPINAL CORD DISEASE. *AK
NHTSA ODI #10067658
Mileage unknown · Aug 13, 2003
Tires
PROBLEMS WITH GOODYEAR WRANGLER F1 TIRES ON 2001 AUDI ALLROAD.*MR *CB
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
2001 Audi Allroad Problems, Complaints & Recalls | Skip That Year
Illustration