IllustrationON 2 SEPARATE OCCASIONS I HAD TO PAY FOR A PARKING BRAKE MODULE OR MOTOR. THE COST WAS 900.00 BOTH TIMES. I GOOGLE THIS AND FOUND MORE COMPLAINTS ABOUT THIS SAME ISSUE. *TR
2005 Audi A6
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Audi A6 do not stand out strongly from the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
725–50K
1250–75K
475–100K
22100–150K
2150K+
52 reports with mileage · 39 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports1 injury reports
Service Brakes complaints
5 reportsON OUR 2005 AUDI A6 WE PURCHASED CERTIFIED PRE-OWNED (CPO) WE ARE THE SECOND OWNERS OF THE VEHICLE. WHEN WE PURCHASED THIS A6 IT HAD ONLY 30,330 MILES. WHEN WE GOT TO AROUND 90K+ MILES IS WHEN WE STARTED TO HAVE SOME ISSUES WITH THE CARS BRAKING SYSTEM. WE TOOK IT TO AUDI WHICH IS THE ONLY PLACE WE HAVE HAD IT SERVICED AND WHERE…
Read full complaint
ON OUR 2005 AUDI A6 WE PURCHASED CERTIFIED PRE-OWNED (CPO) WE ARE THE SECOND OWNERS OF THE VEHICLE. WHEN WE PURCHASED THIS A6 IT HAD ONLY 30,330 MILES. WHEN WE GOT TO AROUND 90K+ MILES IS WHEN WE STARTED TO HAVE SOME ISSUES WITH THE CARS BRAKING SYSTEM. WE TOOK IT TO AUDI WHICH IS THE ONLY PLACE WE HAVE HAD IT SERVICED AND WHERE WE PURCHASED THE VEHICLE. THEY SAID THERE WAS A PROBLEM WITH THE BRAKE MODULE CAUSING THE BLINKING BRAKE LIGHT AND THE ABS LIGHT TO COME ON ALONG WITH A LOUD BEEPING FROM TIME TO TIME. THEY THOUGHT IT COULD ALSO BE LOW ON BRAKE FLUID AND CAPPED IT OFF. THE PROBLEM WENT AWAY FOR A WHILE BUT THEN CAME BACK ALONG WITH THE CHECK ENGINE LIGHT. THIS TIME IT WAS SAID WE HAVE A FAULT ECU MODULE. WE HAD THIS SERVICE DONE WHICH COSTS $2,200.USD BUT THIS WAS JUST TO REPAIR THE CHECK ENGINE LIGHT BUT NOT THE BRAKE MODULE. WE ASKED IF THIS REPAIR WOULD RESOLVE BOTH ISSUES AND THE ANSWER WAS YES. THERE ARE THOUSANDS OF COMPLAINTS ABOUT THE BOSCH BRAKE MODULE WHICH SEEMS TO BE AN ONGOING PROBLEM WITH AUDI. THIS NEEDS TO BE RECALLED AND EVERYONE GET THEIR MONEY REFUNDED TO THEM FOR THE PAIN AND ANGUISH THIS HAS CAUSED. THERE ALSO NEEDS TO BE A CLASS ACTION LAWSUIT AGAINST AUDI!! *TR
AUDI 2005 A6 STARTED TO HAVE INTERMITTENT WARNING FOR ABS, STABILITY, HAND BRAKE AT ~55K MILES. TOOK CAR TO DEALER TO DIAGNOSE IT . DEALER CALLED WITH AN ESTIMATE OF $2800 TO REPLACE ABS MODULE. HE ALSO PROVIDED AN ESTIMATE OF $1100 FOR ANOTHER ERROR CODE FOR AIRBAG TO REPLACE THE CENTER REAR SEAT BELT. I'M NOT UNDERSTANDI…
Read full complaint
AUDI 2005 A6 STARTED TO HAVE INTERMITTENT WARNING FOR ABS, STABILITY, HAND BRAKE AT ~55K MILES. TOOK CAR TO DEALER TO DIAGNOSE IT . DEALER CALLED WITH AN ESTIMATE OF $2800 TO REPLACE ABS MODULE. HE ALSO PROVIDED AN ESTIMATE OF $1100 FOR ANOTHER ERROR CODE FOR AIRBAG TO REPLACE THE CENTER REAR SEAT BELT. I'M NOT UNDERSTANDING WHY THESE WARNING CODES COME SO RANDOMLY AND CLEAR SO RANDOMLY. NOT SURE WHY AN AUDI A6 WILL NEED SUCH REPAIRS THAT CLEARLY POINT TO FLAWS IN DESIGN AND UNRELIABLE PARTS AFTER ONLY 55K MILES. THERE ARE TONS FOR ONLINE COMPLAINTS FROM AUDI DRIVERS THAT USE THE BOSCH 8.0 ABS MODULE. AUDI SHOULD EITHER RECALL THIS PART OR OFFER TO PAY FOR THE REPAIRS. WHEN I COMPLAINED TO AUDI USA, BASICALLY THEY ASKED IF I WAS FIRST OWNER AND IF I TAKE IT TO DEALER FOR MAINTENANCE. THE ANSWERS FOR BOTH IS NO. I'M THE 2ND DRIVER. BOUGHT THE CAR WITH ONLY 20K MILES AND SINCE RELOCATING TO HOUSTON, I TAKE THE CAR TO A LOCAL GARAGE FOR OIL CHANGE. I'M LOOKING FOR SAFECAR.GOV TO RECTIFY THE ISSUE WITH AUDI. AUDI DOESN'T EVEN SELL THE ABS MODULE PART ALONE. YOU WILL HAVE TO BUY THE BRAKE PUMP AS WELL. *TR
I WAS DRIVING MY CAR IN MY WORK PARKING LOT WHEN A LOUD BEEP OCCURRED AND MY CAR ISSUED A WARNING FOR "PARKING BREAK MALFUNCTION." TWO LIGHTS, ESC AND ABS ALSO LIT UP WHEN THE BEEP SOUNDED. I IMMEDIATELY STOPPED DRIVING, ENGAGED THE PARKING BRAKE (WHICH WORKED) AND DISENGAGED IT. I AM THE SECOND OWNER OF THE CAR AND AFTER SOME R…
Read full complaint
I WAS DRIVING MY CAR IN MY WORK PARKING LOT WHEN A LOUD BEEP OCCURRED AND MY CAR ISSUED A WARNING FOR "PARKING BREAK MALFUNCTION." TWO LIGHTS, ESC AND ABS ALSO LIT UP WHEN THE BEEP SOUNDED. I IMMEDIATELY STOPPED DRIVING, ENGAGED THE PARKING BRAKE (WHICH WORKED) AND DISENGAGED IT. I AM THE SECOND OWNER OF THE CAR AND AFTER SOME RESEARCH FOUND THAT THE BRAKE MODULE AND MMI BOTH HAD BEEN UPGRADED BY THE PREVIOUS OWNER. I CONTINUED TO WITNESS THESE SYMPTOMS AND AM WAITING FOR MY DEALERSHIP TO RUN A DIAGNOSTIC. I HAVE READ ENOUGH CONSUMER COMPLAINTS ABOUT THIS SPECIFIC PROBLEM TO KNOW THAT AUDI SHOULD TAKE A DEEPER LOOK INTO IT.
ELECTROMECHANIC PARKING BRAKE BROKE 6 TIMES IN 4 YEARS. A FEW TIMES THE BRAKE WON'T DISENGAGE, HAVING TO LITERALLY DRAG THE CAR ON A PLATFORM TO BE ABLE TO TAKE IT TO THE DEALER. SINCE THE FIRST EVENT I'VE NEVER USED THE PARKING BRAKE ON PURPOSE (THE CAR IS AUTOMATIC) TO AVOID ANOTHER MALFUNCTION BUT IT WOULD STILL BREAK EVERY F…
Read full complaint
ELECTROMECHANIC PARKING BRAKE BROKE 6 TIMES IN 4 YEARS. A FEW TIMES THE BRAKE WON'T DISENGAGE, HAVING TO LITERALLY DRAG THE CAR ON A PLATFORM TO BE ABLE TO TAKE IT TO THE DEALER. SINCE THE FIRST EVENT I'VE NEVER USED THE PARKING BRAKE ON PURPOSE (THE CAR IS AUTOMATIC) TO AVOID ANOTHER MALFUNCTION BUT IT WOULD STILL BREAK EVERY FEW MONTHS. IT'S EITHER THE MOTORS OR WIRING OR BOTH. IT NEVER HAPPENED TO ME WHILE DRIVING BUT DEALER WARNED ME THAT IT COULD. THE REASON I'M FILING THE COMPLAINT IS THAT IT IS NOT AN ISOLATED CASE. A QUICK GOOGLE SEARCH "AUDI PARKING BRAKE MALFUNCTION" WILL PROVE THAT THE PROBLEM IS WIDESPREAD AND IT MAKES ME THINK THAT THEY SHOULD HAVE ISSUED A RECALL BUT THEY DIDN'T. *TR
Official recalls
318V427000 · Air Bags:frontal:passenger Side:inflator Module
Jun 22, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2005-2008 Audi A4 Sedan, A4 Avant, S4 Avant and S4 Sedan, 2007-2008 RS4 Sedan, 2004 RS4 Cabriolet, 2007-2009 A4 Cabriolet and S4 Cabriolet, 2005-2011 A6 Sedan, 2006-2011 A6 Avant, and 2007-2011 S6 Sedan vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Audi has notified owners, and dealers will replace the passenger frontal air bag with an alternate remedy part, free of charge. The recall began June 29, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69R7. Note: This recall supersedes recalls 16V382, 17V032 and 18V004 and includes vehicles that may have had their air bag previously replaced under one of those campaigns.
17V032000 · Air Bags:frontal:passenger Side:inflator Module
Jan 11, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009 Audi A4 Cabriolet, S4 Cabriolet, A6 Avant, A6 Sedan and S6 Sedan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, the District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone B" above, Volkswagen is recalling certain 2005-2008 Audi A4 Avant, A4 Sedan, A6 Sedan, S4 Avant and S4 Sedan vehicles, 2007-2008 A4 Cabriolet, RS4 Sedan, S4 Cabriolet and S6 Sedan vehicles, and 2006-2008 A6 Avant and 2008 RS4 Cabriolet vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Audi will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began March 30, 2018. Owners may contact Audi customer service at 1-800-253-2834. Note: This recall has been superseded by recall number 18V427.
16V382000 · Air Bags:frontal:passenger Side:inflator Module
Jun 1, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2004-2008 Audi A4, and 2005-2011 Audi A6 vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Volkswagen is recalling certain model year 2004-2008 Audi A4, and 2005-2008 Audi A6 vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Volkswagen is recalling model year 2004 Audi A4 vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Audi will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Owner notification letters were mailed April 28, 2017. Owners may contact Audi customer service at 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.