Illustration2002 AUDI A6 BRAKE EQUIPMENT FAILS IN COLD WEATHER. *MR THIS WOULD OCCUR WHEN THE TEMPERATURES BELOW 10 DEGREES. *SC
2002 Audi A6
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Audi A6 do not stand out strongly from the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
825–50K
1450–75K
1575–100K
12100–150K
2150K+
62 reports with mileage · 26 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports5 injury reports
What owners actually said
88 reportsWHILE DRIVING THE VEHICLE WILL SHUT DOWN, AND THE STEERING WILL LOCK UP. THIS HAPPENED FOUR TIMES.*AK
WET ROADS, ACCELERATION UP HILL, CAR SLID OVER HILL CRASHED INTO SEVERAL TREES, RESTRAINED FS PASSENGER WITH SEVERE BONE, SOFT TISSUE AND NERVE DAMAGE. NO AIRBAG DEPLOYMENT, QUESTION OF SEATBELT FAILURE. STATUTE SOON TO EXPIRE, MANUFACTURER WILL NOT RESPOND RE:TESTING POSSIBLE FAULTY PARTS. *JB
WET ROADS, LARGE HILL CAR OVER CLIFF T BONE TREE, NO AIRBAG DEPLOYMENT, QUESTION OF SEAT BELT FAILURE. *JB
AUDI A-6, 2000, WET ROAD CONDITIONS, APROXIMATELY 36 DEGREES, STEEP HILL CAR SLID OFF ROAD, DOWN EMBANKMENT FRONT/SIDE CRASH NO AIRBAG DEPLOYMENT AND QUESTION OF SEATBELT FAILURE RESTRAINED FS PASSENGER WITH COMMINUTED, SEGMENTAL HUMERUS FRACTURE, NERVE AND SOFT TISSUE DAMAGE CAR SAT IN GARAGE FOR 10 MONTHS, AUDI REFUSED TO R…
Read full complaint
AUDI A-6, 2000, WET ROAD CONDITIONS, APROXIMATELY 36 DEGREES, STEEP HILL CAR SLID OFF ROAD, DOWN EMBANKMENT FRONT/SIDE CRASH NO AIRBAG DEPLOYMENT AND QUESTION OF SEATBELT FAILURE RESTRAINED FS PASSENGER WITH COMMINUTED, SEGMENTAL HUMERUS FRACTURE, NERVE AND SOFT TISSUE DAMAGE CAR SAT IN GARAGE FOR 10 MONTHS, AUDI REFUSED TO RESPOND TO CORRESPONDANCE ABOUT POSSIBLE FAILURE OF VEHICLE. *AK
2002 AUDI A6 WAS TAKEN TO SUNSET AUDI IN PORTLAND OR IN DEC.2003 BECAUSE APPEARED TIRES WERE WEARING-SHAVING ON EDGES AND MIDDLE,THEY ALIGNED THE CAR. ON AUGUST 11TH ONE OF THE TIRES WENT FLAT. ON THE NEXT FRIDAY THE CAR WAS TAKEN TO LES SCHWAB WHICH IS THE WARRANTY AGENT FOR PIRELLI.LES SCHWAB TIRE STORE SAID THAT THEY JUST…
Read full complaint
2002 AUDI A6 WAS TAKEN TO SUNSET AUDI IN PORTLAND OR IN DEC.2003 BECAUSE APPEARED TIRES WERE WEARING-SHAVING ON EDGES AND MIDDLE,THEY ALIGNED THE CAR. ON AUGUST 11TH ONE OF THE TIRES WENT FLAT. ON THE NEXT FRIDAY THE CAR WAS TAKEN TO LES SCHWAB WHICH IS THE WARRANTY AGENT FOR PIRELLI.LES SCHWAB TIRE STORE SAID THAT THEY JUST HAD ANOTHER AUDI IN THE SAME THING ON THE EXACT SAME TYPE OF CAR AND THEY HAD SEE MANY OTHERS THAT HAD BEEN COMING IN FORTHE SAME PROBLEM. PIRELLI HAS THEM SEND BACK THE TIRES AND WOULD DETERMINE IF ANY MONEYWOULD BE RETURNED. BESIDES THE FLAT TIRE ALL THE TIRES HAD TO BE REPLACED.LES SCHWAB SAID THAT IT DID NOT IN ANY WAY LOOK LIKE ALIGNMENT PROBLEM THAT INSTEAD THEY THOUGHT THAT THE RUBBER COMPOUND WAS NOT ADEQUATE. MY CAR IS 2 YEARS OLD WITH ONLY 10,000 MI AUDI SAYS THEY HAVE NO RESPONSIBILITY FOR THE TIRES AS THAT IS A WARRANTY WITH PIRELLI HOWEVER SINCE IT MAY BE THAT EITHER AUDI DID NOT SPECIFY THE RIGHT TIRE OR PIRELLI GAVE TIRES IN ADEQUATE IN THE THICKNESS OF THE RUBBER. THE BOTTOM LINE WAS THAT I A 77 YEAR OLD FEEL THAT I HAVE BEEN TAKEN,I HAD TO PAYOUT A LITTLE OVER $400 FOR FOUR NEW TIRES ON MY LOW MILEAGE CAR. IN ADDITION I ONLY DRIVE ON WELL PAVED ROADS AND NO FREEWAYS. I FEE THAT SOMEONE IS NOT BEING ACCOUNTABLE FOR THE SAFEY OF MYSELF AND OTHERS. SINCE AUDI SENDS ALL THE TIRE PROBLEMS TO PERRILE THEY NEVER HEAR BACK IF THERE ARE PROBLEMS. MY CONCERN IS THAT NOT ONLY ONE TIRE BLEW OUT BUT ALL F OUR COULD HAVE GONE OUT AT ONCE--HOW MANY OTHER AUDI OWNERS ARE OUT THERE WITH TIRES SHREDDING. I HAVE ASKED AUDI TO FIND OUT IF THE TIRE COMPANY WILL BE GIVING ME MY MONEYBACK--THEY TOLDME AT THE DEALER THAT THE ONLY MONEY THE TIRE COMPANY GIVES BACK IS IF THERE IS A DEFECT AND THEY HAVE NEVER KNOW THIS TIRE COMPANY TO FIND DEFECTS--THUS AUDI DOES NOT HAVE TO PAY FOR TIRES AND NEITHER WILL THE TIRE CO. *AK
WHILE PULLING INSIDE OF THE GARAGE, THE VEHICLE SUDDENLY ACCELERATED. THIS CAUSED THE VEHICLE TO SKID INTO THE BACK WALL OF THE CONSUMERS HOME. NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. *AK *SC *JB
WHENEVER I ATTEMPT TO ACCELERATE IMMEDIATELY AFTER USING THE BRAKES, NOTHING HAPPENS. THE CAR'S THROTTLE APPEARS TO HAVE NO EFFECT FOR 2+ SECONDS, EVEN WHEN PRESSED ALL THE WAY TO THE FLOOR. ON SEVERAL SEPARATE OCCAISIONS, WHILE TRYING TO MERGE INTO TRAFFIC, I HAVE NEARLY BEEN HIT BY AN ONCOMING VEHICLE WHILE WAITING FOR MY CAR…
Read full complaint
WHENEVER I ATTEMPT TO ACCELERATE IMMEDIATELY AFTER USING THE BRAKES, NOTHING HAPPENS. THE CAR'S THROTTLE APPEARS TO HAVE NO EFFECT FOR 2+ SECONDS, EVEN WHEN PRESSED ALL THE WAY TO THE FLOOR. ON SEVERAL SEPARATE OCCAISIONS, WHILE TRYING TO MERGE INTO TRAFFIC, I HAVE NEARLY BEEN HIT BY AN ONCOMING VEHICLE WHILE WAITING FOR MY CAR TO UNDERSTAND THAT I INTENDED TO ACCELERATE. THIS IS NOT TURBO LAG; IT IS COMPUTER-INDUCED THROTTLE LAG. (THE ENGINE RPMS DO NOT CHANGE DURING THESE OCCURRENCES.) THIS IS A CLEAR SAFETY ISSUE THAT AUDI MUST ADDRESS. (A REPRESENTATIVE OF MY DEALERSHIP TOLD ME HE IS QUITE AWARE OF THE PROBLEM AND HAS PERSONALLY EXPERIENCED IT. BUT AUDI INFORMED HIM IT DOES NOT SEE THIS AS A PROBLEM.) *AK
WIPER BLADES NOT FUNCTIONAL IN WINTRY CONDITIONS. BLADE DOES NOT REMOVE SNOW AND THUS FREEZES AND BECOMES A LAYER OF ICE. CAN'T SEE. VERY DANGEROUS. DEFROSTER MELTS THE SNOW HOWEVER THE OEM BLADE ISN'T STRONG ENOUGH TO REMOVE & THUS MORE ICE. NO WINTER BLADES ARE AVAILABLE AS THE MANUFACTURER - AUDI- HAS REDESIGNED THE BLADE…
Read full complaint
WIPER BLADES NOT FUNCTIONAL IN WINTRY CONDITIONS. BLADE DOES NOT REMOVE SNOW AND THUS FREEZES AND BECOMES A LAYER OF ICE. CAN'T SEE. VERY DANGEROUS. DEFROSTER MELTS THE SNOW HOWEVER THE OEM BLADE ISN'T STRONG ENOUGH TO REMOVE & THUS MORE ICE. NO WINTER BLADES ARE AVAILABLE AS THE MANUFACTURER - AUDI- HAS REDESIGNED THE BLADE CONNECTION. *JB
THERE IS A SOUND OF METAL RATTLING TOWARDS THE FRONT END OF THE CAR. SOUNDS AS IF SOMETHING IS GOING TO FALL OFF THE CAR. AUDI COULD NOT IDENTIFY THE PROBLEM FOR 10 DAYS AND THEN SAID THEY IDENTIFIED THE PROBLEM AS FRONT BREAK PADS COMING LOOSE. THEY REPAIRED WHAT THEY THOUGHT TO BE THE PROBLEM. WE RETURNED TO CAR TO THEIR S…
Read full complaint
THERE IS A SOUND OF METAL RATTLING TOWARDS THE FRONT END OF THE CAR. SOUNDS AS IF SOMETHING IS GOING TO FALL OFF THE CAR. AUDI COULD NOT IDENTIFY THE PROBLEM FOR 10 DAYS AND THEN SAID THEY IDENTIFIED THE PROBLEM AS FRONT BREAK PADS COMING LOOSE. THEY REPAIRED WHAT THEY THOUGHT TO BE THE PROBLEM. WE RETURNED TO CAR TO THEIR SERVICE CENTER 5 WEEKS LATER WITH THE SAME PROBLEM. THEY CAN NOT IDENTIFY WHAT IS WRONG WITH THE CAR AND WILL NOT GIVE US A GUARANTEE IN WRITING THAT THE VEHICLE IS SAFE TO DRIVE. MY WIFE IS 4 MONTHS PREGNANT AND WE ARE NOT COMFORTABLE HAVING HER DRIVE A CAR WITH A FRONT BRAKE PROBLEM. AUDI IS REFUSING TO BUY THE CAR BACK.
Official recalls
411V267000 · Fuel System, Other:storage:tank Assembly
May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
08V157000 · Fuel System, Gasoline:storage:tank Assembly
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.