IllustrationWATER FROM AIR CONITIONING SYSTEM LEAKED INTO PASSENGER COMPARTMENT AND FLOODED AND DISABLED TRANSMISSION CONTROL MODULE. TRANSMISSION WENT INTO "LIMP MODE,' ALLOWING VEHICLE TO ONLY OPERATE IN 4TH GEAR. *TR
2002 Audi A6
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Audi A6 do not stand out strongly from the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
825–50K
1450–75K
1575–100K
12100–150K
2150K+
62 reports with mileage · 26 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports5 injury reports
What owners actually said
88 reportsBRAKE LIGHT SWITCH (DIRECTLY ATTACHED TO BRAKE PEDAL) HAS FAILED TWICE. ONCE IT ALLOWED THE BRAKE LIGHTS TO COME ON AT ANY TIME, EVEN WHEN THE VEHICLE WAS NOT BEING OPERATED. THE SECOND TIME IT WAS NOT ACTIVATING THE BRAKE LIGHTS WHEN THE PEDAL WAS DEPRESSED. IT HAS BEEN REPLACED BOTH TIMES. VOLKSWAGEN VEHICLES HAVE BEEN REC…
Read full complaint
BRAKE LIGHT SWITCH (DIRECTLY ATTACHED TO BRAKE PEDAL) HAS FAILED TWICE. ONCE IT ALLOWED THE BRAKE LIGHTS TO COME ON AT ANY TIME, EVEN WHEN THE VEHICLE WAS NOT BEING OPERATED. THE SECOND TIME IT WAS NOT ACTIVATING THE BRAKE LIGHTS WHEN THE PEDAL WAS DEPRESSED. IT HAS BEEN REPLACED BOTH TIMES. VOLKSWAGEN VEHICLES HAVE BEEN RECALLED FOR A SIMILAR PROBLEM. *JB
MY ENGINE FAILED WHILE DRIVING AT 35 MPH ON ROUTE 375 IN WOODSTOCK, NY. THE FAILURE WAS A RESULT OF ASSEMBLY BOLTS ON THE REVERSE SIDE OF THE EXHAUST CAM SHAFT VARIABLE VALVE TIMING SPROCKET LOOSENING AND FALLING OUT AGAINST THE CYLINDER HEAD, STALLING THE THE CAMSHAFT AND BREAKING THE TIMING BELT. INSPECTION OF BOLTS SHOW NEITH…
Read full complaint
MY ENGINE FAILED WHILE DRIVING AT 35 MPH ON ROUTE 375 IN WOODSTOCK, NY. THE FAILURE WAS A RESULT OF ASSEMBLY BOLTS ON THE REVERSE SIDE OF THE EXHAUST CAM SHAFT VARIABLE VALVE TIMING SPROCKET LOOSENING AND FALLING OUT AGAINST THE CYLINDER HEAD, STALLING THE THE CAMSHAFT AND BREAKING THE TIMING BELT. INSPECTION OF BOLTS SHOW NEITHER A LOCK WASHER OR THREAD LOCK ADHESIVE WERE PRESENT TO PREVENT THE LOOSENING DUE TO HEATING AND COOLING OR VIBRATION. FURTHER SERVICE OF BOLTS CANNOT BE PERFORMED AS THERE ARE NO TIGHTENING SPECIFICATION FOR THESE BOLTS. AN EASY FIX FOR THIS MECHANICAL FAILURE WOULD BE TO REMOVE BOTH VALVE COVERS AND REPLACE THE BOLTS ON THE TIMING GEAR SPROCKETS WITH NEW BOLTS WITH ADHESIVE ON THE THREADS. THIS IS AN INTERFERENCE ENGINE, WHICH RESULTS IN A CATASTROPHIC FAILURE IN THE BENDING OF VALVES AND TOTAL ENGINE DESTRUCTION. *TR
TL*THE CONTACT OWNS A 2002 AUDI A6. THE CONTACT STATED THAT DURING THE COLD WEATHER SEASON THE BRAKE BOOSTER FILLED WITH WATER AND CAUSED THE BRAKES TO FAIL. THE ABS INDICATOR ILLUMINATED. THE CONTACT DISCOVERED THAT THE MASTER CYLINDER WAS RUSTED AND NEEDED TO BE REPLACED ALONG WITH THE BRAKE BOOSTER. THE MANUFACTURER WI…
Read full complaint
TL*THE CONTACT OWNS A 2002 AUDI A6. THE CONTACT STATED THAT DURING THE COLD WEATHER SEASON THE BRAKE BOOSTER FILLED WITH WATER AND CAUSED THE BRAKES TO FAIL. THE ABS INDICATOR ILLUMINATED. THE CONTACT DISCOVERED THAT THE MASTER CYLINDER WAS RUSTED AND NEEDED TO BE REPLACED ALONG WITH THE BRAKE BOOSTER. THE MANUFACTURER WILL NOT REIMBURSE THE CONTACT FOR THE REPAIRS BECAUSE THEY WERE NOT DONE AT AN AUDI DEALER. THE CONTACT POSSESSES THE REPAIR INVOICES. THE CURRENT MILEAGE WAS 56,000, AND FAILURE MILEAGE WAS 54,000.*AK
BRAKE LIGHT SWITCH FAILURE. 2002 AUDI A6. CAR WAS HAVING PROBLEMS RUNNING, BRAKE LIGHTS WOULD STAY ON EVEN WHEN CAR WAS OFF, WAS WONDERING WHY VEHICLES WERE HONKING AT ME WHEN I WAS DRIVING. SINCE CAR IS MADE BY VW AND THEY HAVE A MAJOR RECALL ONGOING WITH BRAKE SWITCH FAILURES JUST LIKE I ENCOUNTERED, AUDI SHOULD RECALL ALL …
Read full complaint
BRAKE LIGHT SWITCH FAILURE. 2002 AUDI A6. CAR WAS HAVING PROBLEMS RUNNING, BRAKE LIGHTS WOULD STAY ON EVEN WHEN CAR WAS OFF, WAS WONDERING WHY VEHICLES WERE HONKING AT ME WHEN I WAS DRIVING. SINCE CAR IS MADE BY VW AND THEY HAVE A MAJOR RECALL ONGOING WITH BRAKE SWITCH FAILURES JUST LIKE I ENCOUNTERED, AUDI SHOULD RECALL ALL THEIR MODELS TO FIX THIS PROBLEM TOO (FREE OF CHARGE!) UNLIKE ME WHO HAS TO PAY. *JB
DT*: THE CONTACT STATED WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE ACCELERATED SUDDENLY WITHOUT WARNING. THE BRAKE PEDAL WAS DEPRESSED WHICH STOPPED THE VEHICLE. THIS OCCURRED ON THREE OCCASIONS. IT WAS TAKEN TO THE SERVICE DEALER, WHO WAS NOT ABLE TO IDENTIFY THE PROBLEM.
DT*: THE CONTACT STATED WHILE TRAVELING 30 MPH THE VEHICLE STOPPED AND HAD TO BE PULLED OVER. THE CONTACT ATTEMPTED TO MOVE FORWARD WHEN THE FRONT END BEGAN TO SMOKE. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT REPAIR SHOP AT A SLOW SPEED WHERE IT WAS DETERMINED THAT THE BRAKES LOCKED UP. THE VEHICLE WAS TOWED TO ANOTHER INDEPE…
Read full complaint
DT*: THE CONTACT STATED WHILE TRAVELING 30 MPH THE VEHICLE STOPPED AND HAD TO BE PULLED OVER. THE CONTACT ATTEMPTED TO MOVE FORWARD WHEN THE FRONT END BEGAN TO SMOKE. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT REPAIR SHOP AT A SLOW SPEED WHERE IT WAS DETERMINED THAT THE BRAKES LOCKED UP. THE VEHICLE WAS TOWED TO ANOTHER INDEPENDENT REPAIR SHOP WHO DETERMINED THE ABS PUMP FAILED AND WAS REPLACED. UPDATED 10/6/2006 - *NM
DT*: THE CONTACT STATED RECALL NOTICE #04V133000 WAS RECEIVED FOR A 2000 AUDI A6 PERTAINING TO ELECTRICAL SYSTEM. THE CONTACT ALSO OWNS A 2002 AUDI A6 WHICH A RECALL NOTICE WAS NOT RECEIVED FOR. WHEN THE CONTACT RESEARCHED THE RECALL ON THE NHTSA WEBSITE, A LETTER IN THE DOCUMENT SEARCH FROM VOLKSWAGEN TO THE NHTSA IDENTIFIED T…
Read full complaint
DT*: THE CONTACT STATED RECALL NOTICE #04V133000 WAS RECEIVED FOR A 2000 AUDI A6 PERTAINING TO ELECTRICAL SYSTEM. THE CONTACT ALSO OWNS A 2002 AUDI A6 WHICH A RECALL NOTICE WAS NOT RECEIVED FOR. WHEN THE CONTACT RESEARCHED THE RECALL ON THE NHTSA WEBSITE, A LETTER IN THE DOCUMENT SEARCH FROM VOLKSWAGEN TO THE NHTSA IDENTIFIED THAT THE VIN FOR THE 2002 AUDI A6 MODEL WAS INCLUDED IN THE RECALL. WHEN THE CONTACT ALERTED THE MANUFACTURER WITH THE VIN, THEY INDICATED THERE WAS NO INFORMATION REGARDING THE RECALL OR VEHICLE IN QUESTION.
ON AROUND MAY 28TH 2006- UPON RETURN FROM WORK THAT EVENING, THE FLOOR OF MY CAR WAS FLOODED- I WAS IN TOTAL SHOCK. I WAS ABOUT TO GO ON VACATION, I DRIED ALL THE FLOOR AND AIRED IT OUT ETC. UPON MY RETURN FROM VACATION, IT WAS WORSE THAN EVER- THE FLOOR WAS AGAIN SOAKED, IT IN TURN HAD DAMAGED THE COMPUTER SYSTEM IN MY CAR AND…
Read full complaint
ON AROUND MAY 28TH 2006- UPON RETURN FROM WORK THAT EVENING, THE FLOOR OF MY CAR WAS FLOODED- I WAS IN TOTAL SHOCK. I WAS ABOUT TO GO ON VACATION, I DRIED ALL THE FLOOR AND AIRED IT OUT ETC. UPON MY RETURN FROM VACATION, IT WAS WORSE THAN EVER- THE FLOOR WAS AGAIN SOAKED, IT IN TURN HAD DAMAGED THE COMPUTER SYSTEM IN MY CAR AND THAT IN TURN HAD CAUSED THE BATTERY TO DRAIN. I HAD IT TOWED TO MY MECHANICS SHOP- THE FOLLOWING HAPPENED, THE ENGINE SEIZED AS A RESULT OF ALL THE WATER THAT MADE ITS WAY INTO THE CAR, AND COMPUTER SYSTEM TOTALLY DESTROYED. THEY DRAINED AT LEAST 15 GALLONS OF WATER FROM THE CAR. THIS IS INCREDIBLE AND UNBELIEVABLE. THE MECHANIC SAID THE CAR WAS CLOGGED AND EVEN HE HAD A HARD TIME ACCESSING, AND I AS OWNER HAD NO WAY OF FINDING OUT. I BOUGHT THE CAR IN 05, IT IS AN A6 3.0 YEAR 2002. WITH AROUND 54 THOUSAND MILES UP, AND I HAD ONLY PUT 1000 MILES UP ON THE CAR. THE WARRANTY - EXTENDED, SAID IN TURN THE CAR IS NOT COVERED DUE TO MOTOR DAMAGE, AND A NEW ENGINE WOULD COST $8700 NOT TO MENTION THE MECHANIC FEES. UPON FURTHER INVESTIGATION ONLINE, I SEE THAT THERE ARE SEVERAL REPORTS OF THIS PROBLEM WITH THIS YEAR AUDI AND OTHER YEARS AND VW PASSATS ALSO. I PAID NEARLY $26000 FOR THIS CAR AND FEEL I HAVE BEEN SCAMED BY AUDI, MAJOR AUTOMOTIVE WHO SOLD ME THE CAR AND THE GM PROTECTION PLAN WHO PROVIDES THE EXTENDED WARRANTY, - THE SALES PERSON ADVISED IT WAS BUMPER TO BUMPER COVERAGE- I NOW FIND OUT THAT I HAVE TO PAY FOR MY NEW ENGINE?? I FEEL ALL PARTIES SHOULD BE HELD RESPONSIBLE AND WANT TO KNOW IF ANYONES IS FILING A CLASS ACTION LAW OR DOING ANYTHING ABOUT THIS, WHERE IS THE PROTECTION FOR THE CONSUMER, PLEASE HELP ME, I AM NOT RICH, I SPENT ALL MY SAVINGS FOR THIS CAR, I AM CURRENTLY PAYING INSURANCE AND ALSO CAR PAYMENTS ON THIS CAR, I CANT AFFORD A NEW ENGINE, EVEN IF I COULD IS THE SAME PROBLEM GOING TO ARISE AGAIN. PLEASE HELP ME. THANK YOU, E. MORRISSEY (THERE IS NOT A SELECTION FOR AUDI UNDER VEHICLE. *JB
DT*: THE CONTACT STATED A PUDDLE OF GAS WAS OBSERVED UNDER THE VEHICLE. IT WAS TAKEN TO THE DEALER WHERE THEY DISCOVERED A GAS LEAK. A SEALANT WAS PLACED ON THE GAS TANK HOWEVER THE PROBLEM PERSISTED. UPDATED 09/12/06.*JB
Official recalls
411V267000 · Fuel System, Other:storage:tank Assembly
May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
08V157000 · Fuel System, Gasoline:storage:tank Assembly
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.