NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
11 reportsClear category filter35,000 miles · Jan 12, 2012
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2001 AUDI A6 AVANT. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE SMELLED A STRONG ODOR OF GASOLINE. THE FAILURE PROGRESSED OVER TIME AND THE CONTACT FOUND A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT FUEL WAS LEAKING FROM THE TOP OF THE FUEL TANK.…
Read full complaint
TL* THE CONTACT OWNS A 2001 AUDI A6 AVANT. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE SMELLED A STRONG ODOR OF GASOLINE. THE FAILURE PROGRESSED OVER TIME AND THE CONTACT FOUND A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT FUEL WAS LEAKING FROM THE TOP OF THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 35,000. UPDATED 02/01/12 *BF UPDATED 02/07/12*BF THE CONSUMER STATED AUDI AGREED TO PAY THE COST OF REPLACING THE FUEL TANK. UPDATED 02/22/12
NHTSA ODI #10443555
85,000 miles · Nov 17, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2001 AUDI A6. THE CONTACT STATED THAT HE NOTICED A FUEL LEAK NEAR THE FUEL TANK FROM UNDER THE VEHICLE. THE DEALER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 08V157000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE VEHICLE WAS TAKEN TO AN INDEPENDEN…
Read full complaint
TL* THE CONTACT OWNS A 2001 AUDI A6. THE CONTACT STATED THAT HE NOTICED A FUEL LEAK NEAR THE FUEL TANK FROM UNDER THE VEHICLE. THE DEALER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 08V157000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT HE NEEDED TO HAVE THE NIPPLE ON TOP OF THE TANK REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10436204
100,000 miles · May 9, 2011
Fuel System, Gasoline
CHECK ENGINE LIGHTS FOR EVAPORATIVE SYSTEM LEAK. FIRST SMALL LEAK CODES EVERY WEEK OR SO, THEN "GROSS LEAK" CODE. INFORMED BY DEALER THAT THERE IS A LEAK ON THE TOP OF THE PLASTIC GAS TANK AND THERE HAS BEEN SOME SPILLAGE. RISK OF FIRE. DEALER INFORMS $2800 TO REPLACE GAS TANK. *TR
NHTSA ODI #10399588
122,980 miles · Feb 11, 2010
Fuel System, Gasoline
MY VEHICLE QUALIFIES FOR A FEW RECALLS BUT IS NOT LISTED AS ONE OF THE RECALLED CARS. I SUFFER SOME THE EXACT ISSUES THE FACTORY RECALLED BUT MY CAR IS NOT A RECALLED CAR. ITS REALLY INCONVENIENT TO DRIVE AROUND WITH THESE ISSUES BECAUSE I AM WORRIED I COULD GET STRANDED SOMEWHERE. *TR
NHTSA ODI #10308832
138,000 miles · Aug 4, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 AUDI A6. WHENEVER THE CONTACT DISPENSED GASOLINE INTO THE FUEL TANK, HE SMELLED A STRONG ODOR OF FUEL INSIDE AND OUTSIDE OF THE VEHICLE. HE ALSO OBSERVED A LARGE AMOUNT OF FUEL LEAKING ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THE FAILURE WAS …
Read full complaint
TL*THE CONTACT OWNS A 2001 AUDI A6. WHENEVER THE CONTACT DISPENSED GASOLINE INTO THE FUEL TANK, HE SMELLED A STRONG ODOR OF FUEL INSIDE AND OUTSIDE OF THE VEHICLE. HE ALSO OBSERVED A LARGE AMOUNT OF FUEL LEAKING ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THE FAILURE WAS RELATED TO THE FUEL TANK NIPPLE. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 08V157000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 138,000 AND CURRENT MILEAGE WAS 140,000.
NHTSA ODI #10279387
125,000 miles · Sep 16, 2008
Fuel System, Gasoline
THE VEHICLE STARTED LEAKING GAS AFTER FILLING UP AT GAS STATION. GASOLINE ODOR ALSO INSIDE PASSENGER COMPARTMENT. NO PREVIOUS INDICATIONS, NO ACCIDENTS, NO DAMAGE TO CAR. *TR
NHTSA ODI #10242446
70,000 miles · Aug 30, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 AUDI 6. THE CONTACT DISCOVERED A LARGE PUDDLE OF GASOLINE UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE CHECK VALVE FOR THE FUEL TANK WAS BENT AND CRACKED. THE FUEL TANK WAS REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 70,000. UPDATED 10/11/07…
Read full complaint
TL*THE CONTACT OWNS A 2001 AUDI 6. THE CONTACT DISCOVERED A LARGE PUDDLE OF GASOLINE UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE CHECK VALVE FOR THE FUEL TANK WAS BENT AND CRACKED. THE FUEL TANK WAS REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 70,000. UPDATED 10/11/07. *JB
NHTSA ODI #10201211
Mileage unknown · Oct 17, 2003
Fuel System, GasolinePower TrainService Brakes, Hydraulic
AUDI 2001 A6 2.7T TIPTRONIC WHILE IN D TRANSMISSION MODE, CAR DOES NOT ACCELERATE PER ACCELERATOR INPUT AFTER USING THE BRAKES. THERE IS A DELAY OF ABOUT A COUPLE OF SECONDS BEFORE CAR ACCELERATES. THIS HAPPENS AFTER BRAKING FROM LOW SPEEDS FOLLOWED BY GENTLE ACCELERATION AND ALSO WHEN BRAKING FROM HIGHER SPEEDS FOLLOWED BY…
Read full complaint
AUDI 2001 A6 2.7T TIPTRONIC WHILE IN D TRANSMISSION MODE, CAR DOES NOT ACCELERATE PER ACCELERATOR INPUT AFTER USING THE BRAKES. THERE IS A DELAY OF ABOUT A COUPLE OF SECONDS BEFORE CAR ACCELERATES. THIS HAPPENS AFTER BRAKING FROM LOW SPEEDS FOLLOWED BY GENTLE ACCELERATION AND ALSO WHEN BRAKING FROM HIGHER SPEEDS FOLLOWED BY EITHER GENTLE OR AGGRESSIVE ACCELERATION. OFTEN THERE WILL BE A PRONOUNCED JERK WHEN THE CAR STARTS TO ACCELERATE AFTER THE DELAY. *LA SAFETY ISSUE TYPICAL SITUATION: WHEN CROSSING MEDIANS TO MERGE WITH TRAFFIC IN THE OPPOSITE DIRECTION, ONCOMING TRAFFIC HAVE TO BRAKE HEAVILY TO AVOID A COLLISION BECAUSE THE CAR IS UNABLE TO ACCELERATE SMARTLY AFTER BRAKING. THE SAME CROSSING IN PREVIOUSLY OWNED AUDI A4 1.8T AND AUDI A4 2.8 (BOTH WITHOUT FLY BY WIRE THROTTLE) COULD BE SAFELY NEGOTIATED WITHOUT ANY ACCELERATION DELAY. THIS SITUATION IS UNACCEPTABLE AND HIGHLY DANGEROUS IN NORMAL EVERYDAY DRIVING. REFERENCES FROM AUDIWORLD.COM FORUMS IT IS APPARENT THAT THERE ARE MANY OWNERS EXPERIENCING THIS PROBLEM. ALL HAVE THE AUDI TIPTRONIC TRANSMISSION AND FLY BY WIRE THROTTLE SYSTEM, NOT LIMITED TO THE 2.7T MODEL. HERE IS THE LINK TO THE LATEST MESSAGES HTTP://FORUMS.AUDIWORLD.COM/A6/MSGS/304185.PHTML ALSO, CONSUMER REPORTS HAVE NOTED THE DELAY IN ACCELERATION WHEN TESTING THIS CAR. HERE IS THE LINK. HTTP://WWW.CONSUMERREPORTS.ORG/MAIN/DETAILV2.JSP?CONTENT%3C%3ECNT_ID=302773&FOLDER%3C%3EFOLDER_ID=97851&ASSORTMENT%3C%3EAST_ID=333137&BMUID=1066370138539 SEVERAL OTHER REVIEWS IN THE U.S. AUTOMOBILE PRESS HAVE ALSO NOTED THE DELAY. REPAIR LOCAL AUDI DEALER IS UNABLE TO OFFER A SOLUTION SINCE THEIR TROUBLESHOOTING TECHNIQUES ONLY INDICATE A "NO FAULT FOUND" OR "UNABLE TO DUPLICATE" SITUATION (SEVERAL VISITS). ESCALATION TO AUDI HEADQUARTERS ELICITS STATEMENTS SUCH AS "WORKING AS PER DESIGN, "SAFETY FEATURE (PREVENT OVER REVVING DAMAGE TO ENGINE/TRANSMISSION)", AND "SYSTEM HAS TO PROCESS A LOT OF DATA". *LA
NHTSA ODI #10043073
23,000 miles · Jan 8, 2003
Fuel System, GasolineService Brakes, Hydraulic
WHEN THE BRAKES WERE APPLIED, THE PEDAL HAD GONE TO THE FLOOR CAUSING EXTENDED STOPPING DISTANCE. THE DEALER WAS NOTIFIED. TS THE FUEL DOOR ASSEMBLY WAS FOUND TO BE FAULTY. SCC
NHTSA ODI #10002362
Mileage unknown · Jul 26, 2001
Fuel System, Gasoline
CONSUMER RECEIVED RECALL #LH, HOWEVER WAS INFORMED THAT AN APPOINTMENT COULD NOT BE MADE UNTIL PARTS CAME, WHEN CONSUMER ATTEMPTED TO MAKE AN APPOINTMENT WHEN PARTS BECAME AVAILABLE, DELAER STATED NO APPOINTMETS WERE AVAILABLE AT THAT TIME, CONSUMER STILL HAS NOT HEARD FROM DEALER WHICH HAS ALREADY BEEN TWO WEEKS AND VEHICLE HAS…
Read full complaint
CONSUMER RECEIVED RECALL #LH, HOWEVER WAS INFORMED THAT AN APPOINTMENT COULD NOT BE MADE UNTIL PARTS CAME, WHEN CONSUMER ATTEMPTED TO MAKE AN APPOINTMENT WHEN PARTS BECAME AVAILABLE, DELAER STATED NO APPOINTMETS WERE AVAILABLE AT THAT TIME, CONSUMER STILL HAS NOT HEARD FROM DEALER WHICH HAS ALREADY BEEN TWO WEEKS AND VEHICLE HAS NOT BEEN REPAIRED.*YD
NHTSA ODI #562245
Official recalls
7May 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Apr 8, 2008
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Apr 7, 2003
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.7L ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE CALCULATED "VEHICLE NORMAL LOAD" EXCEEDS THE ALLOWABLE WEIGHT OF THE AXLE LOAD WITH TIRE DIMENSION 225/45R 17 91Y BY 19KG.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN ON SEPTEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-800-822-2834.
Jun 18, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES (ALLROAD). WHEN ACTIVATING THE WINDSHIELD WIPER UNDER HEAVY LOAD CONDITIONS SUCH AS FREEZING, SNOW OR HEAVY RAIN, ONE WIPER COULD BE DELAYED BEHIND THE OTHER WIPER.
Consequence & remedy
Consequence: IF THAT HAPPENS, THE WIPER BLADES, BECAUSE THEY OVERLAP WIPING AREAS, COULD BECOME ENTANGLED WITH EACH OTHER AND CEASE FUNCTIONING. THIS COULD IMPAIR THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL REPLACE THE ENTIRE DRIVER SIDE WIPER ARM. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration