I HAVE A 2001 AUDI A6 2.7T AND IT HAS ALMOST CAUSED ME TO GET INTO SEVERE ACCIDENTS WHERE I WOULD HAVE BEEN SERIOUSLY INJURED OR KILLED IN A SIDE IMPACT COLLISION. THE CULPRIT IS THIS: IF YOU DEPRESS THE BRAKE (AS IF YOU WERE STOPPING OR COMING TO A COMPLETE STOP) AND TRY TO REACCELERATE, THERE IS LITTLE TO NO ACCELERATION. THIS…
Read full complaint
I HAVE A 2001 AUDI A6 2.7T AND IT HAS ALMOST CAUSED ME TO GET INTO SEVERE ACCIDENTS WHERE I WOULD HAVE BEEN SERIOUSLY INJURED OR KILLED IN A SIDE IMPACT COLLISION. THE CULPRIT IS THIS: IF YOU DEPRESS THE BRAKE (AS IF YOU WERE STOPPING OR COMING TO A COMPLETE STOP) AND TRY TO REACCELERATE, THERE IS LITTLE TO NO ACCELERATION. THIS "HESITATION" HAS ALMOST GOT ME KILLED SEVERAL TIMES. THERE ARE HUNDREDS OF OTHER AUDI A6 CONSUMERS REGARDLESS OF MODEL ENGINE (2.8, 2.7T, 3.0 AND 4.2) THAT HAVE EXPERIENCED THIS PROBLEM. THUS, IT IS UNACCEPTABLE FOR AUDI USA TO SAY THIS IS "NORMAL" AND "INHERENT IN THE OPERATION OF TURBOCHARGERS" AS THIS IS WHAT THEY HAVE TOLD ME BEFORE WHILE THE CAR WAS BEING SERVICED. ALTHOUGH I DO UNDERSTAND THAT TURBOCHARGERS CREATE WHAT IS DEEMED AS "TURBO LAG" ON ACCELERATION, I EXPERIENCE MAJOR DELAYS IN ANY ACCELERATION IMMEDIATELY AFTER I HAVE DEPRESSED THE BRAKE (AT ANY SPEED) AND THEN TRY TO REACCELERATE. THIS IS A SERIOUS ISSUE AND NEEDS TO BE FIXED OR REMEDIED IMMEDIATELY. PLEASE SEE THE POSTING AT AUDIWORLD (THE LARGEST ONLINE FORUM FOR AUDI OWNERS). HERE IS THE POST URL: HTTP://FORUMS.AUDIWORLD.COM/A6/MSGS/304185.PHTML . *LA
NHTSA ODI #10042986
5 miles · Jun 27, 2003
Engine And Engine CoolingSteering
MY CAR HAS BEEN IN THE SHOP FOR REPAIRS EVERY 3000 MILES. SOME FOR MAJOR PROBLEMS SUCH AS REPLACING THE STEERING ASSEMBLY AND OTHER TIMES FOR MULTIPLE REPAIRS OF THE SAME PROBLEMS (ENGINE MALFUNCTION LIGHT ON). *JB
NHTSA ODI #10023890
14,048 miles · Jun 17, 2003
Engine And Engine CoolingService Brakes, Hydraulic
CAR BURNS OIL 1/2 QUART/1000 MI. ALMOST RUNS OUT BEFORE WARNING LIGHT COMES ON. AUDI SAYS THIS IS NORMAL- WE HAVE HAD TWO EMERGENCIES ON THE FREEWAY WHERE WE ALMOST RAN OUT OF OIL. ALSO, IT IS VERY HARD TO READ THE OIL DIP STICK- IT IS ARTFUL NOT USEFUL. ROTORS (ALL) FAILED AT 14K MILES AND HAD TO BE REPLACED. WE ARE ADVISED WE …
Read full complaint
CAR BURNS OIL 1/2 QUART/1000 MI. ALMOST RUNS OUT BEFORE WARNING LIGHT COMES ON. AUDI SAYS THIS IS NORMAL- WE HAVE HAD TWO EMERGENCIES ON THE FREEWAY WHERE WE ALMOST RAN OUT OF OIL. ALSO, IT IS VERY HARD TO READ THE OIL DIP STICK- IT IS ARTFUL NOT USEFUL. ROTORS (ALL) FAILED AT 14K MILES AND HAD TO BE REPLACED. WE ARE ADVISED WE ARE NOT ALONE. AUDI CORP ARROGANT AND WILL NOT RESPOND. THROWS EVERYTHING BACK TO DEALER. DEALER FIXED ROTOR PROBLEM AT NO COST. TRIED TO CHARGE FOR OIL TEST REPAIR. BELIEVE THERE ARE DESIGN ISSUES IN BOTH INSTANCES. AUDI HAS LEARNED NOTHING FROM THEIR PAST PROBLEMS- THEY ARE THE MOST ARROGANT BUSINESS I HAVE EVER EXPERIENCED. *JB
NHTSA ODI #10023239
Mileage unknown · Jun 12, 2002
Engine And Engine Cooling
WHILE DRIVING WITH NO INDICATION HAD NO INDICATION OF OIL LEAKING FROM ENGINE. DEALER NOTIFIED. CAUSE UNKNOWN. *AK
NHTSA ODI #8011674
Mileage unknown · Apr 8, 2002
Engine And Engine Cooling
THIS IS THE SECOND A6-4.2 THAT HAS THIS PROBLEM. THE CAR DUMPS ALL POWER FROM SLOW SPEEDS. IMAGINE PULLING OUT INTO TRAFFIC FROM A SIDE STREET OR ONRAMP AND TURNING THE IGNITION OFF. AUDI REPLACED MY FIRST A6 BECAUSE OF THIS PROBLEM AND NOW ACCORDING TO THE SERVICE MANAGERS AT THE DEALERSHIP HAS NUMEROUS OTHER 2000 AND 2001 A6'…
Read full complaint
THIS IS THE SECOND A6-4.2 THAT HAS THIS PROBLEM. THE CAR DUMPS ALL POWER FROM SLOW SPEEDS. IMAGINE PULLING OUT INTO TRAFFIC FROM A SIDE STREET OR ONRAMP AND TURNING THE IGNITION OFF. AUDI REPLACED MY FIRST A6 BECAUSE OF THIS PROBLEM AND NOW ACCORDING TO THE SERVICE MANAGERS AT THE DEALERSHIP HAS NUMEROUS OTHER 2000 AND 2001 A6'S AND A8'S WITH THE 4.2 ENGINE THAT ARE EXPERIENCING THIS PROBLEM. IT 'S ONLY A MATTER OF TIME BEFORE THERE IS GOING TO BE A HORRENDOUS T-BONE OR REAR-END CRASH WITH THESE CARS. ACCORDING TO THE DEALERSHIP, AUDI KNEW THAT THESE CARS HAVE THIS PROBLEM WHEN THEY TOOK BACK MY ORIGINAL A6 AND SOLD ME THE SECOND ONE. THE AUDI ZONE MGR ASKED THE SERVICE REP WHY THE HECK THEY SOLD ME ANOTHER ONE. THIS IS A RELATIVELY EXPENSIVE AND RARE CAR BUT THEY CONTINUED TO SELL THEM AFTER KNOWING FULL WELL THAT THERE IS A SERIOUS FLAW IN THE ECM AND THROTTLE COMBO THAT MORE THAN LIKELY WILL CAUSE SERIOUS ACCIDENTS. AFTER 5 WEEKS OF PHONE CALLS TO AUDI CUST RELATIONS IN MICHIGAN I HAVE GIVEN UP AND WILL HAVE TO GET LEGAL HELP. I HAVE IMPLORED THEM TO TAKE THE CAR BACK DUE TO THE SAFETY ISSUES AND CUST RELATIONS HAS PLAYED RUN-AROUND WITHOUT GIVING ME ANY ANSWERS UP TO THIS POINT TODAY. THE MOST ASTOUNDING POINT TO THIS IS THAT I HAVE PURCHASE 6 OR 7 AUDI'S OVER THE YEARS AND 4 NEW VW'S FOR MY KIDS IN THE PAST 6 YEARS AND THEY ABSOLUTELY DON'T CARE IF I GET HURT OR KILLED IN THIS CAR! THIS MODEL CAR WITH THIS ENGINE WILL KILL SOMEONE IF THEY DON'T DO A RECALL TO FIX THIS PROBLEM ASAP. I GUESS THEY ARE RELYING ON THE AIRBAGS SAVING THEIR CUSTOMERS
NHTSA ODI #760436
Mileage unknown · Dec 13, 2001
Engine And Engine CoolingPower Train
AUTOMOBILE SLOWS UP WHEN GOING UP A HILL, IT SEEM AS IF TURBO IS NOT FUNCTIONING. WAS TOLD THAT IT WAS TRANSMISSION OR TURBO HAD A HOLE IN IT. *AK
NHTSA ODI #8000703
Mileage unknown · Dec 10, 2001
Electrical SystemEngine And Engine CoolingPower Train
CONSUMER STATED THE TRANSMISSION IS INOPERATIVE, WHEN PUTTING VEHICLE IN DRIVE IT WILL MOVE 15 - 20 FEET THEN IT WILL STOP FOR ABOUT 4 SECONDS, THEN VEHICLE WILL ACCELERATE, VEHICLE WAS TAKEN INTO DEALER, THE VEHICLE IS NOT CONSISTENT IN SELECTING THE STARTING GEAR, SOMETIMES STARTING FAST AT OTHER TIMES, SLOW, THE SPEEDOMETER …
Read full complaint
CONSUMER STATED THE TRANSMISSION IS INOPERATIVE, WHEN PUTTING VEHICLE IN DRIVE IT WILL MOVE 15 - 20 FEET THEN IT WILL STOP FOR ABOUT 4 SECONDS, THEN VEHICLE WILL ACCELERATE, VEHICLE WAS TAKEN INTO DEALER, THE VEHICLE IS NOT CONSISTENT IN SELECTING THE STARTING GEAR, SOMETIMES STARTING FAST AT OTHER TIMES, SLOW, THE SPEEDOMETER IS NOT VISIBLE IN DIRECT SUNLIGHT, EVEN WITH SUNSHDES ON, CONSUMER ALSO STATED THE VEHICLE STALLS. *JG *AK
NHTSA ODI #6900632
Mileage unknown · Jun 26, 2001
Engine And Engine Cooling
VEHICLE WILL INTERMITTENTLY HESITATE AT LOW SPEED; VEHICLE HAS BEEN AT DEALER ON TWO OCCASIONS, AND PROBLEM STILL REOCCURRING. PROVIDE ANY FURTHER INFORMATION.*AK
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Consequence & remedy
Consequence: A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.7L ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE CALCULATED "VEHICLE NORMAL LOAD" EXCEEDS THE ALLOWABLE WEIGHT OF THE AXLE LOAD WITH TIRE DIMENSION 225/45R 17 91Y BY 19KG.
Consequence & remedy
Consequence: Not supplied
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN ON SEPTEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-800-822-2834.
VEHICLE DESCRIPTION: PASSENGER VEHICLES (ALLROAD). WHEN ACTIVATING THE WINDSHIELD WIPER UNDER HEAVY LOAD CONDITIONS SUCH AS FREEZING, SNOW OR HEAVY RAIN, ONE WIPER COULD BE DELAYED BEHIND THE OTHER WIPER.
Consequence & remedy
Consequence: IF THAT HAPPENS, THE WIPER BLADES, BECAUSE THEY OVERLAP WIPING AREAS, COULD BECOME ENTANGLED WITH EACH OTHER AND CEASE FUNCTIONING. THIS COULD IMPAIR THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL REPLACE THE ENTIRE DRIVER SIDE WIPER ARM. OWNER NOTIFICATION BEGAN JUNE 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
2001 Audi A6 Problems, Complaints & Recalls | Skip That Year
Illustration