IllustrationTHE CHECK ENGINE LIGHT CAME ON. THE CODE FOR THE LIGHT INDICATED A FAILED CATALYTIC CONVERTER HAD FAILED, THIS WAS AT 78K MILES THE DEALER SAID THAT IT MUST FAIL AGAIN BEFORE 80K MILE TO BE COVER UNDER WARRANTY. IT FAILED AGAIN AT 87K MILE AND NOW THE DEALER WON'T REPLACE IT UNDER WARRANTY. *NM
2000 Audi A6
Owner reports · Recalls · Investigations
More warning signs than most A6 years
Owner complaints for the 2000 Audi A6 are substantially higher than the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
1525–50K
2250–75K
2375–100K
20100–150K
5150K+
87 reports with mileage · 61 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports8 fire reports5 injury reports
What owners actually said
148 reportsLTR FM (OR) OWNER OF AUDI VEHICLE DEFECTIVE ABS/BRAKE COMPUTER CONTROL MODULE SUGGEST NHTSA RECALL VEHICLES AND AUDI TO REPLACE ABS DEFECT AT THEIR EXPENSE REPLY TO THE PORTLAND, OREGON OFFICE. *TS *JB
FAILURE OF THE FRONT LEFT TIE ROD AND CONTROL ARM IN A 2000 AUDI A6 QUATTRO. SEVERE WOBBLE CAUSING NEAR ACCIDENT AND VEHICLE IN THE DITCH. *NM
DT*: THE CONTACT STATED A RECALL NOTIFICATION WAS RECEIVED IN 2004 ON NHTSA CAMPAIGN ID # 04V133000, CONCERNING THE ELECTRICAL SYSTEM. THE RECALL WORK WAS PERFORMED BY THE DEALERSHIP; HOWEVER THE VEHICLE CAUGHT FIRE AND BURNED WHILE DRIVING. THE FIRE STARTED UNDER THE DASH ON THE DRIVER'S SIDE. THE FLAMES WERE FIRST NOTICED COMI…
Read full complaint
DT*: THE CONTACT STATED A RECALL NOTIFICATION WAS RECEIVED IN 2004 ON NHTSA CAMPAIGN ID # 04V133000, CONCERNING THE ELECTRICAL SYSTEM. THE RECALL WORK WAS PERFORMED BY THE DEALERSHIP; HOWEVER THE VEHICLE CAUGHT FIRE AND BURNED WHILE DRIVING. THE FIRE STARTED UNDER THE DASH ON THE DRIVER'S SIDE. THE FLAMES WERE FIRST NOTICED COMING FROM THE VENTS. THE FIRE DEPARTMENT WAS CONTACTED TO EXTINGUISH THE FIRE. THE MANUFACTURER WAS CONTACTED AND SENT A REPRESENTATIVE TO INVESTIGATE THE SCENE. THE REPRESENTATIVE COMMENTED THE RECALL WAS SUPPOSE TO PREVENT A FIRE FROM OCCURRING. THE DRIVER'S SIDE OF THE VEHICLE WAS SEVERELY DAMAGED AND THE INSURANCE COMPANY TOTALED THE VEHICLE. *NM
DT*: THE CONTACT STATED THE VEHICLE LURCHED FORWARD AT A STOP SIGN. THE ABS AND BRAKE LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE ANTILOCK BRAKE CONTROL MODULE ASSEMBLY WAS REPLACED.*AK
FUSE NUMBER 14 BLEW, DISABLING THE ELECTRIC WINDOWS AND MOONROOF. I CONSIDER IT DANGEROUS TO DRIVE WITH INOPERATIVE WINDOWS. FOUR VISITS TO THE AUDI DEALER WERE REQUIRED BEFORE THE PROBLEM WAS SUCCESSFULLY FIXED. THE PROBLEM TURNED OUT TO BE THE LUMBAR SUPPORT MECHANISM IN THE PASSENGER FRONT SEAT CHAFING AND EVENTUALLY SHORT-C…
Read full complaint
FUSE NUMBER 14 BLEW, DISABLING THE ELECTRIC WINDOWS AND MOONROOF. I CONSIDER IT DANGEROUS TO DRIVE WITH INOPERATIVE WINDOWS. FOUR VISITS TO THE AUDI DEALER WERE REQUIRED BEFORE THE PROBLEM WAS SUCCESSFULLY FIXED. THE PROBLEM TURNED OUT TO BE THE LUMBAR SUPPORT MECHANISM IN THE PASSENGER FRONT SEAT CHAFING AND EVENTUALLY SHORT-CIRCUITING THE WIRING TO THE REAR FOOTWELL LIGHTS, WHICH RUNS THROUGH THE FRONT SEATS. *JB
DT: THE CONTACT PURCHASED A 2000 AUDI A6 IN AUGUST 2003. THE VEHICLE HAD 93,000 MILES ON IT WHEN PURCHASED. THE CONTACT WAS NOT SURE WEATHER OR NOT THE 90,000 MILES SERVICE WAS COMPLETED BECAUSE HE WAS NOT SUPPLIED WITH SERVICE RECORDS BY AUDI. A LOCAL DEALER COMPLETED THIS WORK SEVERAL MONTHS AFTER THIS CAR WAS PURCHASED. L…
Read full complaint
DT: THE CONTACT PURCHASED A 2000 AUDI A6 IN AUGUST 2003. THE VEHICLE HAD 93,000 MILES ON IT WHEN PURCHASED. THE CONTACT WAS NOT SURE WEATHER OR NOT THE 90,000 MILES SERVICE WAS COMPLETED BECAUSE HE WAS NOT SUPPLIED WITH SERVICE RECORDS BY AUDI. A LOCAL DEALER COMPLETED THIS WORK SEVERAL MONTHS AFTER THIS CAR WAS PURCHASED. LATER, THE VEHICLE FAILED INSPECTION BECAUSE OF WEAR ON THE CONTROL ARMS. THIS FAILURE OCCURRED IN JULY 2004. THE CONTROL ARMS WERE REPLACED BY A LOCAL REPAIR SHOP OR AUDI SPECIALIST, NOT THE DEALER. WITHIN A MONTH OF THE REPLACEMENT THE CONTACT RECEIVED A RECALL NOTICE FOR THE CONTROL ARMS. CONTACTED AUDI, AND WAS INSTRUCTED TO SUBMIT THE REPAIR INVOICE TO AUDI. NO ONE WAS CONTACTED FOR FOUR MONTHS. WHEN THE CONTACT FURTHER INQUIRED, HE WAS TOLD THE APPLICATION WAS DENIED BECAUSE AUDI CLAIMED THAT THEY WERE UNABLE TO CONTACT HIM BY PHONE. THE REIMBURSEMENT WAS REFUSED BECAUSE THEY VEHICLE SERVICE RECORDS WERE NOT INCLUDED. HOWEVER, THE VEHICLE WAS PREVIOUSLY AN AUDI LEASE VEHICLE AND THE RECORDS SHOULD HAVE BEEN AVAILABLE THROUGH AUDI WHERE THE CONTACT PURCHASED THIS VEHICLE TROUGH A BROKER. *AK
DT: CONSUMER STATES THAT THERE IS A MODULE THAT IS FAILING ON VEHICLE. THIS RESULTS IN THE ABS SYSTEM NOT WORKING. TO REPLACE THE MODULE WOULD COST $1,000-$1,300. CONSUMER HAS AN APPOINTMENT TO HAVE THE VEHICLE FIXED THIS FRIDAY. THE PROBLEM HAS BEEN SPORADIC OVER THE LAST 6 WEEKS. WHEN THE VEHICLE WAS TAKEN TO THE DEALERS…
Read full complaint
DT: CONSUMER STATES THAT THERE IS A MODULE THAT IS FAILING ON VEHICLE. THIS RESULTS IN THE ABS SYSTEM NOT WORKING. TO REPLACE THE MODULE WOULD COST $1,000-$1,300. CONSUMER HAS AN APPOINTMENT TO HAVE THE VEHICLE FIXED THIS FRIDAY. THE PROBLEM HAS BEEN SPORADIC OVER THE LAST 6 WEEKS. WHEN THE VEHICLE WAS TAKEN TO THE DEALERSHIP THEY COULD NOT FIND THE CAUSE OF THE PROBLEM , AND HE WAS TOLD TO DRIVE IT UNTIL IT FAILED AGAIN. CONSUMER WAS CONCERNED THAT THIS WAS HAPPENING ON OTHER VEHICLES. HE FOUND THIS INFORMATION ONLINE.*AK
NEAR TOTAL LOSS OF POWER (INTERMITTENT) 17 ERROR CODES IN OBD. NEW TRIPTONIC TRANSMISSION 1 MONTH AFTER EXPIRATION OF WARENTEE. EXTENDED WARENTEE NEVER OFFERED BY AUDI. ERROR CODES INCLUDE THROTTLE HOUSING AND CAM ERROR. I HAVE SPENT NEARLY $7,000 IN 10 MONTHES ON MECHANICAL REPAIRS AND MECHANIC SAYS THAT I NEED APPROXIMATLY $6,…
Read full complaint
NEAR TOTAL LOSS OF POWER (INTERMITTENT) 17 ERROR CODES IN OBD. NEW TRIPTONIC TRANSMISSION 1 MONTH AFTER EXPIRATION OF WARENTEE. EXTENDED WARENTEE NEVER OFFERED BY AUDI. ERROR CODES INCLUDE THROTTLE HOUSING AND CAM ERROR. I HAVE SPENT NEARLY $7,000 IN 10 MONTHES ON MECHANICAL REPAIRS AND MECHANIC SAYS THAT I NEED APPROXIMATLY $6,300 MORE. AUDI SAID THAT I CAN HAVE THE DEALER RUN A DIGNOSTIC AT MY OWN EXPENSE. ADDITION TO THE $6,300 NEED. CHECK ENGINE LIGHT HAS CONSTANTLY COME ON SINCE PURCHASE. DEALER SIAD THAT HE ADVISES CUSTOMER MANY TIMES TO DISCONNECT LIGHT. CONSTANT REPAIRS SINCE OWNERSHIP. AUDI IS NOT HELPFULL.
BRAKES RUSTED AND WARPED ROTORS 5 TIMES IN 25000 MILES
Official recalls
420V056000 · Air Bags:frontal:driver Side:inflator Module
Jan 31, 2020
Volkswagen Group of America, Inc. (VW) is recalling certain 2000-2001 TT Roadster, 2000 TT Coupe, 1999 Audi A8, 1998-2000 Audi A6, and 1999-2000 Audi A4 vehicles equipped with Non-Azide Driver air bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, possibly causing the air bag to deploy improperly in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, the air bag may not properly protect the occupant, increasing the risk of serious injury or death.
Remedy: Dealers will replace the driver frontal air bag inflator with an alternative inflator when the parts become available, free of charge. Owner notifications were mailed September 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69BT.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
01V157000 · Fuel System, Gasoline:storage:tank Assembly
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ06003 · Driver's Side Dash Fire
Opened Feb 27, 2006 · Closed Jul 20, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:interior/under Dash
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
Additional source detail variants (2)
Electrical System
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
Electrical System:wiring:interior/under Dash
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
EA03025 · Drivers Side Dash Fire
Opened Nov 25, 2003 · Closed May 7, 2004
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Additional source detail variants (10)
Electrical System
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:front Underhood
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:front Underhood
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:fuses And Circuit Breakers
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:fuses And Circuit Breakers
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
PE03035 · Drivers Side Dashboard Fire
Opened Jul 25, 2003 · Closed Nov 25, 2003
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Additional source detail variants (4)
Electrical System
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring:fuses And Circuit Breakers
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring:interior/under Dash
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.