IllustrationTHE LCD IN THE INSTRUMENT CLUSTER WHICH DISPLAYS ANY WARNING LAMPS WAS FAILING. THIS WAS A VERY COMMON PROBLEM. WITHOUT USE OF THIS DISPLAY I WILL NOT KNOW IF I HAVE A CHECK ENGINE LIGHT, BRAKE FAILURE LIGHT OR SO FORTH. I KNOW OVER 100 PEOPLE WITH THIS SAME PROBLEM ,AND I AM NOT MAKING THIS UP. *AK
2000 Audi A6
Owner reports · Recalls · Investigations
More warning signs than most A6 years
Owner complaints for the 2000 Audi A6 are substantially higher than the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
1525–50K
2250–75K
2375–100K
20100–150K
5150K+
87 reports with mileage · 61 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports8 fire reports5 injury reports
Electrical System complaints
36 reportsDT*: THE CONTACT STATED WHILE DRIVING THE VEHICLE BECAME VERY SMOKY INSIDE. THE POWER STEERING AND ALL THE DASH LIGHTS WENT OUT. THE VEHICLE WAS PULLED OFF THE SIDE OF THE ROAD. UPON INSPECTION IT COULD NOT BE DETERMINED WHERE THE SMOKE WAS COMING FROM. THE VEHICLE WAS DRIVEN FOR A SHORT DISTANCE AND THE CAB FILLED WITH SM…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING THE VEHICLE BECAME VERY SMOKY INSIDE. THE POWER STEERING AND ALL THE DASH LIGHTS WENT OUT. THE VEHICLE WAS PULLED OFF THE SIDE OF THE ROAD. UPON INSPECTION IT COULD NOT BE DETERMINED WHERE THE SMOKE WAS COMING FROM. THE VEHICLE WAS DRIVEN FOR A SHORT DISTANCE AND THE CAB FILLED WITH SMOKE AGAIN. THE VEHICLE WAS PARKED AND THEN TOWED TO AN INDEPENDENT REPAIR SHOP. AFTER INSPECTING THE VEHICLE THE BATTERY WAS ENGAGED; FLAMES WERE DETECTED FROM UNDER THE DASH BOARD. THE FIRE DEPARTMENT WAS CONTACTED TO EXTINGUISH THE FIRE BUT NO INSPECTION WAS MADE TO DETERMINE THE CAUSE OF THE FIRE. THE INSIDE OF THE VEHICLE WAS DESTROYED DUE TO FIRE AND SMOKE. THE VEHICLE HAD RECALL REPAIRS PERFORMED IN JULY 2005 FOR THE ELECTRICAL SYSTEM. THE NHTSA CAMPAIGN # 04V133000 CONCERNING THE ELECTRICAL SYSTEM. THE MANUFACTURER HAS BEEN ALERTED.
DT*: THE CONTACT STATED A RECALL NOTIFICATION WAS RECEIVED IN 2004 ON NHTSA CAMPAIGN ID # 04V133000, CONCERNING THE ELECTRICAL SYSTEM. THE RECALL WORK WAS PERFORMED BY THE DEALERSHIP; HOWEVER THE VEHICLE CAUGHT FIRE AND BURNED WHILE DRIVING. THE FIRE STARTED UNDER THE DASH ON THE DRIVER'S SIDE. THE FLAMES WERE FIRST NOTICED COMI…
Read full complaint
DT*: THE CONTACT STATED A RECALL NOTIFICATION WAS RECEIVED IN 2004 ON NHTSA CAMPAIGN ID # 04V133000, CONCERNING THE ELECTRICAL SYSTEM. THE RECALL WORK WAS PERFORMED BY THE DEALERSHIP; HOWEVER THE VEHICLE CAUGHT FIRE AND BURNED WHILE DRIVING. THE FIRE STARTED UNDER THE DASH ON THE DRIVER'S SIDE. THE FLAMES WERE FIRST NOTICED COMING FROM THE VENTS. THE FIRE DEPARTMENT WAS CONTACTED TO EXTINGUISH THE FIRE. THE MANUFACTURER WAS CONTACTED AND SENT A REPRESENTATIVE TO INVESTIGATE THE SCENE. THE REPRESENTATIVE COMMENTED THE RECALL WAS SUPPOSE TO PREVENT A FIRE FROM OCCURRING. THE DRIVER'S SIDE OF THE VEHICLE WAS SEVERELY DAMAGED AND THE INSURANCE COMPANY TOTALED THE VEHICLE. *NM
FUSE NUMBER 14 BLEW, DISABLING THE ELECTRIC WINDOWS AND MOONROOF. I CONSIDER IT DANGEROUS TO DRIVE WITH INOPERATIVE WINDOWS. FOUR VISITS TO THE AUDI DEALER WERE REQUIRED BEFORE THE PROBLEM WAS SUCCESSFULLY FIXED. THE PROBLEM TURNED OUT TO BE THE LUMBAR SUPPORT MECHANISM IN THE PASSENGER FRONT SEAT CHAFING AND EVENTUALLY SHORT-C…
Read full complaint
FUSE NUMBER 14 BLEW, DISABLING THE ELECTRIC WINDOWS AND MOONROOF. I CONSIDER IT DANGEROUS TO DRIVE WITH INOPERATIVE WINDOWS. FOUR VISITS TO THE AUDI DEALER WERE REQUIRED BEFORE THE PROBLEM WAS SUCCESSFULLY FIXED. THE PROBLEM TURNED OUT TO BE THE LUMBAR SUPPORT MECHANISM IN THE PASSENGER FRONT SEAT CHAFING AND EVENTUALLY SHORT-CIRCUITING THE WIRING TO THE REAR FOOTWELL LIGHTS, WHICH RUNS THROUGH THE FRONT SEATS. *JB
NEAR TOTAL LOSS OF POWER (INTERMITTENT) 17 ERROR CODES IN OBD. NEW TRIPTONIC TRANSMISSION 1 MONTH AFTER EXPIRATION OF WARENTEE. EXTENDED WARENTEE NEVER OFFERED BY AUDI. ERROR CODES INCLUDE THROTTLE HOUSING AND CAM ERROR. I HAVE SPENT NEARLY $7,000 IN 10 MONTHES ON MECHANICAL REPAIRS AND MECHANIC SAYS THAT I NEED APPROXIMATLY $6,…
Read full complaint
NEAR TOTAL LOSS OF POWER (INTERMITTENT) 17 ERROR CODES IN OBD. NEW TRIPTONIC TRANSMISSION 1 MONTH AFTER EXPIRATION OF WARENTEE. EXTENDED WARENTEE NEVER OFFERED BY AUDI. ERROR CODES INCLUDE THROTTLE HOUSING AND CAM ERROR. I HAVE SPENT NEARLY $7,000 IN 10 MONTHES ON MECHANICAL REPAIRS AND MECHANIC SAYS THAT I NEED APPROXIMATLY $6,300 MORE. AUDI SAID THAT I CAN HAVE THE DEALER RUN A DIGNOSTIC AT MY OWN EXPENSE. ADDITION TO THE $6,300 NEED. CHECK ENGINE LIGHT HAS CONSTANTLY COME ON SINCE PURCHASE. DEALER SIAD THAT HE ADVISES CUSTOMER MANY TIMES TO DISCONNECT LIGHT. CONSTANT REPAIRS SINCE OWNERSHIP. AUDI IS NOT HELPFULL.
INSTALL PLASTIC COVER ON DRIVER'S SIDE SUPPORT ON CROSS MEMBER AND APPLY FELT TO LEFT CROSS MEMBER END. CHECK FRONT SUSPENSION LOWER CONTROL ARMS. *BF THE CONSUMER REQUESTED REIMBURSEMENT. THERE WAS AN ELECTRICAL SHORT THAT DISABLED THE VEHICLE AND REQUIRED EXTENSIVE REPAIRS FOR SMOKE AND PARTS/WIRING REPLACEMENT. THE ELECT…
Read full complaint
INSTALL PLASTIC COVER ON DRIVER'S SIDE SUPPORT ON CROSS MEMBER AND APPLY FELT TO LEFT CROSS MEMBER END. CHECK FRONT SUSPENSION LOWER CONTROL ARMS. *BF THE CONSUMER REQUESTED REIMBURSEMENT. THERE WAS AN ELECTRICAL SHORT THAT DISABLED THE VEHICLE AND REQUIRED EXTENSIVE REPAIRS FOR SMOKE AND PARTS/WIRING REPLACEMENT. THE ELECTRICAL SHORT ON THE DRIVER'S SIDE BEHIND THE DASH RESULTED IN SMOKE AND A STRONG BURNING PLASTIC SMELL. RECALL# 04V133000. *SC THE CONSUMER HAD TO PAY TO HAVE THE RUBBER BOOT AND UPPER CONTROL ARMS REPLACED EVEN THOUGH THERE WAS A RECALL FOR THE CONTROL ARMS. *JB
04 V 133 000/WIRING HARNESS: CONSUMER NOTICE WHITE SMOKE AND A STRONG PLASTIC BURNING ODORS COMING FROM THE LEFT SIDE OF THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER REPLACED THE CLUSTER MODULE AND REPAIRS THE BURNED WIRES. WITHIN TWO MONTH THE PROBLEM HAS RECURRED. THE CONSUMER BROUGHT THIS RECALL INFORMATION …
Read full complaint
04 V 133 000/WIRING HARNESS: CONSUMER NOTICE WHITE SMOKE AND A STRONG PLASTIC BURNING ODORS COMING FROM THE LEFT SIDE OF THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER REPLACED THE CLUSTER MODULE AND REPAIRS THE BURNED WIRES. WITHIN TWO MONTH THE PROBLEM HAS RECURRED. THE CONSUMER BROUGHT THIS RECALL INFORMATION TO THE DEALER ATTENTION. THE DEALER INFORMED THE CONSUMER THAT WAS NOT THE PROBLEM HIS VEHICLE WAS EXPERIENCING. *NM
TURBO BYPASS AND MASS AIRFLOW REPLACED NUMEROUS TIMES DURING THE FIRST 30K MILES. CAR IN THE SHOP EVERY 2K...FOR ONE THING OR ANOTHER.*AK
VEHICLE FIRE: 2000 AUDI A6 CAUGHT FIRE APPROXIMATELY 30 MINUTES AFTER BEING PARKED IN A GARAGE. THE LOCAL FIRE DEPARTMENT DETERMINED THAT THE FIRE ORIGINATED FROM UNDER THE VEHICLE'S DASHBOARD...SIMILAR TO REPORTS MENTIONED IN NHTSA ACTION NUMBER EA03025. THE AUDI WAS COMPLETELY DESTROYED, AS WERE A 2000 CHEVROLET CORVETTE TH…
Read full complaint
VEHICLE FIRE: 2000 AUDI A6 CAUGHT FIRE APPROXIMATELY 30 MINUTES AFTER BEING PARKED IN A GARAGE. THE LOCAL FIRE DEPARTMENT DETERMINED THAT THE FIRE ORIGINATED FROM UNDER THE VEHICLE'S DASHBOARD...SIMILAR TO REPORTS MENTIONED IN NHTSA ACTION NUMBER EA03025. THE AUDI WAS COMPLETELY DESTROYED, AS WERE A 2000 CHEVROLET CORVETTE THAT WAS PARKED NEXT TO THE AUDI, THE ENTIRE GARAGE, AND FINISHED BASEMENT. THE REMAINDER OF THEHOME WAS SEVERLY DAMAGED BY SMOKE AND SOOT AND THE OCCUPANTS HAVE HAD TO LEAVE THE HOME UNTIL REPAIRS CAN BE MADE. NO ONE WAS INJURED IN THE INCIDENT, AS NO ONE WAS IN THE HOME AT THE TIME OF THE INCIDENT.*AK
THERE WERE OIL LEAKS, THE CONSUMER HAD TO REPLACE THE TURBO(S) AT 37000 MILES AND NEEDED A NEW TURBO(S) AGAIN, AND THE ENGINE AND BRAKE LIGHTS APPEARED ON DIFFERENT OCCASIONS. DEALER STATED THE OIL WASN'T CHANGED REGULARLY. THE INITIAL TURBO(S) WERE REPLACED WITH THE OLD OIL BECAUSE THE NEW OIL WASN'T COVERED UNDER WARRANTY. …
Read full complaint
THERE WERE OIL LEAKS, THE CONSUMER HAD TO REPLACE THE TURBO(S) AT 37000 MILES AND NEEDED A NEW TURBO(S) AGAIN, AND THE ENGINE AND BRAKE LIGHTS APPEARED ON DIFFERENT OCCASIONS. DEALER STATED THE OIL WASN'T CHANGED REGULARLY. THE INITIAL TURBO(S) WERE REPLACED WITH THE OLD OIL BECAUSE THE NEW OIL WASN'T COVERED UNDER WARRANTY. THE SERVICE DEALER STATED THAT 1 OUT OF 15 VEHICLE'S HAVE THE SAME PROBLEM. MR SCC *JB
Official recalls
420V056000 · Air Bags:frontal:driver Side:inflator Module
Jan 31, 2020
Volkswagen Group of America, Inc. (VW) is recalling certain 2000-2001 TT Roadster, 2000 TT Coupe, 1999 Audi A8, 1998-2000 Audi A6, and 1999-2000 Audi A4 vehicles equipped with Non-Azide Driver air bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, possibly causing the air bag to deploy improperly in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, the air bag may not properly protect the occupant, increasing the risk of serious injury or death.
Remedy: Dealers will replace the driver frontal air bag inflator with an alternative inflator when the parts become available, free of charge. Owner notifications were mailed September 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69BT.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
01V157000 · Fuel System, Gasoline:storage:tank Assembly
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ06003 · Driver's Side Dash Fire
Opened Feb 27, 2006 · Closed Jul 20, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:interior/under Dash
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
Additional source detail variants (2)
Electrical System
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
Electrical System:wiring:interior/under Dash
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
EA03025 · Drivers Side Dash Fire
Opened Nov 25, 2003 · Closed May 7, 2004
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Additional source detail variants (10)
Electrical System
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:front Underhood
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:front Underhood
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:fuses And Circuit Breakers
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:fuses And Circuit Breakers
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
PE03035 · Drivers Side Dashboard Fire
Opened Jul 25, 2003 · Closed Nov 25, 2003
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Additional source detail variants (4)
Electrical System
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring:fuses And Circuit Breakers
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring:interior/under Dash
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.