IllustrationTHE INFORMATION ON THE DIGITAL READOUT IS ALL SCREWED UP. SOMETIMES THE TOPS OF THE LETTERS ARE MISSING, OTHER TIMES THE BOTTOMS ARE MISSING. MAKES IT IMPOSSIBLE TO READ INFORMATION ON DASHBOARD. *TR
2000 Audi A6
Owner reports · Recalls · Investigations
More warning signs than most A6 years
Owner complaints for the 2000 Audi A6 are substantially higher than the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
1525–50K
2250–75K
2375–100K
20100–150K
5150K+
87 reports with mileage · 61 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports8 fire reports5 injury reports
Electrical System complaints
36 reportsTL*THE CONTACT OWNS A 2000 AUDI A6 AVANT. THE CONTACT STATED THAT THE INSTRUMENT PANEL CLUSTER FAILED. THE COOLANT AND OIL TEMPERATURE GAUGES WERE NO LONGER OPERATIVE. HALF OF THE DISPLAY WAS VISIBLE, WHICH MEANT THAT CRITICAL INFORMATION THAT NEEDED TO BE DISPLAYED WAS NO LONGER ABLE TO BE SEEN. THE CONTACT TOOK THE VEHICLE…
Read full complaint
TL*THE CONTACT OWNS A 2000 AUDI A6 AVANT. THE CONTACT STATED THAT THE INSTRUMENT PANEL CLUSTER FAILED. THE COOLANT AND OIL TEMPERATURE GAUGES WERE NO LONGER OPERATIVE. HALF OF THE DISPLAY WAS VISIBLE, WHICH MEANT THAT CRITICAL INFORMATION THAT NEEDED TO BE DISPLAYED WAS NO LONGER ABLE TO BE SEEN. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THEY CONFIRMED THAT THE INSTRUMENT CLUSTER FAILED, BUT DID NOT OFFER ANY ASSISTANCE OR A FREE REPAIR. THE CONTACT HAS NOT YET NOTIFIED THE MANUFACTURER. THE CURRENT MILEAGE WAS 102,405 AND FAILURE MILEAGE WAS APPROXIMATELY 75,000.
DASH DOES NOT SHOW IMPORTANT INFO TO MAINTAIN THE CAR PROPERLY. THE DIGITAL LETTERS HAVE DISAPPEARED. I HAVE NO IDEA WHAT'S GOING ON WITH MY A-6.. THE DEALERSHIP TOLD ME THAT ALL AUDI WITH THAT SAME FEATURE HAS THAT SAME PROBLEM. ALSO THERE IS A OIL LEAK THAT IS COMMON IN THE SAME MODELS AS MINE. *TR
THIS IS ABOUT MY 2000 AUDI A6. THE CENTRAL DISPLAY LCD ON THE INSTRUMENT CLUSTER FAILED TO DISPLAY ANY INFORMATION INCLUDING IMPORTANT WARNINGS SUCH AS COOLANT LEVEL, ENGINE TEMPERATURE, ENGINE OIL PRESSURE, BRAKE/ TURN LIGHTS OUT, GEAR POSITION ETC. ALL ARE IMPORTANT TO DRIVING SAFETY. I ONCE HAD LEAKAGE IN MY RADIATOR BUT I …
Read full complaint
THIS IS ABOUT MY 2000 AUDI A6. THE CENTRAL DISPLAY LCD ON THE INSTRUMENT CLUSTER FAILED TO DISPLAY ANY INFORMATION INCLUDING IMPORTANT WARNINGS SUCH AS COOLANT LEVEL, ENGINE TEMPERATURE, ENGINE OIL PRESSURE, BRAKE/ TURN LIGHTS OUT, GEAR POSITION ETC. ALL ARE IMPORTANT TO DRIVING SAFETY. I ONCE HAD LEAKAGE IN MY RADIATOR BUT I COULD NOT SEE THE WARNING OF DROPPING WATER LEVEL AND THAT CAUSED DAMAGE TO MY ENGINE AND WATER PUMP AND I WAS BURNED WHEN CHECKING ENGINE. IT ALMOST CAUSED A ACCIDENT BECAUSE IT STOPPED MY CAR IN THE MIDDLE OF THE HIGH WAY. AS FAR AS I KNOW, ALMOST EVERY AUDI A4/A6 IN BETWEEN 1998-2004 MODEL YEAR HAD THE SAME DISPLAY PROBLEM. *TR
TL*THE CONTACT OWNS A 2000 AUDI A6. THE INSTRUMENT PANEL FAILED. THE CONTACT PURCHASED THE VEHICLE IN 2007 AND THE LIGHTS ON THE INSTRUMENT PANEL HAVE NEVER COMPLETELY WORKED. WHEN IT IS COLD OUTSIDE, THE LIGHTS ILLUMINATE BRIGHT ENOUGH TO BE VISIBLE. IN WARM TEMPERATURES, THE LIGHTS WERE VERY LOW AND VERY DIM. THE DEALER H…
Read full complaint
TL*THE CONTACT OWNS A 2000 AUDI A6. THE INSTRUMENT PANEL FAILED. THE CONTACT PURCHASED THE VEHICLE IN 2007 AND THE LIGHTS ON THE INSTRUMENT PANEL HAVE NEVER COMPLETELY WORKED. WHEN IT IS COLD OUTSIDE, THE LIGHTS ILLUMINATE BRIGHT ENOUGH TO BE VISIBLE. IN WARM TEMPERATURES, THE LIGHTS WERE VERY LOW AND VERY DIM. THE DEALER HAS NOT BEEN INSPECTED BY THE DEALER. THE CONTACT WAS INFORMED THAT IN ORDER TO HAVE IT REPAIRED, HE WOULD NEED TO REPLACE THE ENTIRE INSTRUMENT PANEL CLUSTER. WHEN THE LIGHTS ARE DIM, HE IS UNABLE TO SEE WHAT GEAR THE VEHICLE IS IN OR DETECT IF THERE WAS A POSSIBLE FAILURE WITH THE ENGINE. THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE WAS 97,000. UPDATED 07/29/08 *BF THE CONSUMER STATED THE SCRREN WAS NOT VISIBLE. UPDATED 07/31/08. *JB
MY INFORMATION LED CLUSTER IN MY DASH FADES OUT WHEN IT GETS WARM. THIS CLUSTER IS RESPONSIBLE FOR DISPLAYING GEAR INFORMATION (P,R,N,D,4,3,2,1) AS WELL OTHER SAFETY AND INFORMATIONAL MESSAGES. IT IS A HAZARD TO DRIVE OR SHIFT INTO GEAR WHEN YOU ARE NOT SURE IF IT IS REVERSE OR DRIVE AS WELL AS ANY SAFETY INFORMATION THE CAR…
Read full complaint
MY INFORMATION LED CLUSTER IN MY DASH FADES OUT WHEN IT GETS WARM. THIS CLUSTER IS RESPONSIBLE FOR DISPLAYING GEAR INFORMATION (P,R,N,D,4,3,2,1) AS WELL OTHER SAFETY AND INFORMATIONAL MESSAGES. IT IS A HAZARD TO DRIVE OR SHIFT INTO GEAR WHEN YOU ARE NOT SURE IF IT IS REVERSE OR DRIVE AS WELL AS ANY SAFETY INFORMATION THE CAR WOULD NEED TO DISPLAY. *TR
2000 AUDI A6 WITH A FUEL LEAK. CONSUMER STATES THAT THE VEHICLE HAS BEEN REPAIRED FOR THE FUEL LEAK AND WOULD LIKE SOME FINANCIAL ASSISTANCE IN PAYING FOR THE REPAIR. CONSUMER STATED HE NEVER RECEIVED A CALL FROM THE DEALER. *KB THE VEHICLE HAD PUDDLES OF FUEL ON TOP OF THE TANK. THE CONSUMER BELIEVED RECALL # 01V157000 WAS RE…
Read full complaint
2000 AUDI A6 WITH A FUEL LEAK. CONSUMER STATES THAT THE VEHICLE HAS BEEN REPAIRED FOR THE FUEL LEAK AND WOULD LIKE SOME FINANCIAL ASSISTANCE IN PAYING FOR THE REPAIR. CONSUMER STATED HE NEVER RECEIVED A CALL FROM THE DEALER. *KB THE VEHICLE HAD PUDDLES OF FUEL ON TOP OF THE TANK. THE CONSUMER BELIEVED RECALL # 01V157000 WAS RELATED TO FUEL TANK PROBLEM HE EXPERIENCED . THE DEALER INFORMED THE CONSUMER THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. THE CONSUMER STATED THE LIGHTS ON THE VEHICLE WOULD DIM. *JB
MODEL YEAR 2000, AUDI A6 QUATTRO WAGON 4 INSTANCES OF SUB-STANDARD EQUIPMENT: 1) ABS WARNING LIGHTS DUE TO DEFECTIVE ABS CONTROLLER A VERY COMMON PROBLEM WHICH THE MANUFACTURER SHOULD BE FORCED TO RECALL. 2) SUB-STANDARD MATERIALS USED IN THE VENT TUBING IN THE ENGINE COMPARTMENT (CHEAP PLASTIC THAT BREAKS CAUSING INCREASED …
Read full complaint
MODEL YEAR 2000, AUDI A6 QUATTRO WAGON 4 INSTANCES OF SUB-STANDARD EQUIPMENT: 1) ABS WARNING LIGHTS DUE TO DEFECTIVE ABS CONTROLLER A VERY COMMON PROBLEM WHICH THE MANUFACTURER SHOULD BE FORCED TO RECALL. 2) SUB-STANDARD MATERIALS USED IN THE VENT TUBING IN THE ENGINE COMPARTMENT (CHEAP PLASTIC THAT BREAKS CAUSING INCREASED EMISSIONS OUTPUT HARMING THE ENVIRONMENT). 3) DASHBOARD WARNING DISPLAY LED FAULTY, A VERY COMMON PROBLEM WHICH THE MANUFACTURER SHOULD BE FORCED TO RECALL. 4)PLASTIC COMPONENTS IN INTERIOR OF THE AUTO BREAK EASILY POOR PLASTIC STRENGTH (IE CUPHOLDER, BUTTONS ETC). *TR
INFORMATION DISPLAY ON INSTRUMENT CLUSTER IS NOT READABLE. MANY LINES ON THE LCD DISPLAY KEEP IT FROM PROVIDING CRITICAL INFORMATION. *TR
TL*THE CONTACT OWNS A 2000 AUDI A6. THE CONSOLE HAS A CENTER DISPLAY THAT SHOWS WARNING LIGHTS FOR GAS, BRAKES, ETC. THE CENTER DISPLAY FAILED GRADUALLY APPROXIMATELY ONE YEAR AGO. THE DISPLAY HAS COMPLETELY FAILED AND WHEN THE VEHICLE IS COLD SOME OF THE LINES IN THE DISPLAY ARE VISIBLE. THE DEALER STATED THAT THE VEHICLE IS NO…
Read full complaint
TL*THE CONTACT OWNS A 2000 AUDI A6. THE CONSOLE HAS A CENTER DISPLAY THAT SHOWS WARNING LIGHTS FOR GAS, BRAKES, ETC. THE CENTER DISPLAY FAILED GRADUALLY APPROXIMATELY ONE YEAR AGO. THE DISPLAY HAS COMPLETELY FAILED AND WHEN THE VEHICLE IS COLD SOME OF THE LINES IN THE DISPLAY ARE VISIBLE. THE DEALER STATED THAT THE VEHICLE IS NO LONGER UNDER WARRANTY AND THEY WILL NOT REPAIR IT. THE CURRENT MILEAGE WAS 76,000 AND THE FAILURE MILEAGE WAS 70,000. THE CONSUMER STATED THE GAS GAUGE IS NOT WORKING AND NOT MOVING WHEN THE VEHICLE IS FILLED UP WITH GAS. UPDATED 11/07/07 *TR
Official recalls
420V056000 · Air Bags:frontal:driver Side:inflator Module
Jan 31, 2020
Volkswagen Group of America, Inc. (VW) is recalling certain 2000-2001 TT Roadster, 2000 TT Coupe, 1999 Audi A8, 1998-2000 Audi A6, and 1999-2000 Audi A4 vehicles equipped with Non-Azide Driver air bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, possibly causing the air bag to deploy improperly in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, the air bag may not properly protect the occupant, increasing the risk of serious injury or death.
Remedy: Dealers will replace the driver frontal air bag inflator with an alternative inflator when the parts become available, free of charge. Owner notifications were mailed September 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69BT.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
01V157000 · Fuel System, Gasoline:storage:tank Assembly
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ06003 · Driver's Side Dash Fire
Opened Feb 27, 2006 · Closed Jul 20, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:interior/under Dash
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
Additional source detail variants (2)
Electrical System
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
Electrical System:wiring:interior/under Dash
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
EA03025 · Drivers Side Dash Fire
Opened Nov 25, 2003 · Closed May 7, 2004
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Additional source detail variants (10)
Electrical System
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:front Underhood
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:front Underhood
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:fuses And Circuit Breakers
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:fuses And Circuit Breakers
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
PE03035 · Drivers Side Dashboard Fire
Opened Jul 25, 2003 · Closed Nov 25, 2003
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Additional source detail variants (4)
Electrical System
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring:fuses And Circuit Breakers
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring:interior/under Dash
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.