SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2000 Audi A6

Owner reports · Recalls · Investigations

More warning signs than most A6 years

Owner complaints for the 2000 Audi A6 are substantially higher than the model-year median of 35.

About this comparison →
148Owner complaints

Model-year median: 35

4Recall campaigns

View recall details →

4Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
20
1997130
1998217
1999148
2000113
200188
200266
2003
Compare all A6 years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Electrical System
36Service Brakes, Hydraulic
25Engine And Engine Cooling
21Fuel System, Gasoline
14Tires
14
All reported categories
Suspension
12Steering
11Air Bags
8Power Train
8Fuel/propulsion System
6Unknown Or Other
6Vehicle Speed Control
5Service Brakes, Electric
4Structure
4Visibility
4Equipment
3Exterior Lighting
3Fuel System, Other
3Latches/locks/linkages
2Interior Lighting
1Seat Belts
1Wheels
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

87 reports with mileage · 61 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports8 fire reports5 injury reports

Air Bags complaints

8 reports
Clear category filter
80,000 miles · Nov 14, 2010
Air BagsService Brakes, HydraulicCrashInjury

THE ABS LIGHT COMES ON STEADY, THE HAND BRAKE LIGHT FLASHED CONSTANTLY, AND THREE WARNING BEEPS ARE HEARD. A COMPUTER READING SAYS THERE IS NO CONNECTION WITH THE ABS UNIT. THE ABS DOESN'T WORK AT ALL. IT SOMETIMES OCCURS WHEN I FIRST START THE CAR, AND SOMETIMES AFTER DRIVING FOR A WHILE. THE CONSUMER STATED SOMEONE ELSE WAS D…

Read full complaint

THE ABS LIGHT COMES ON STEADY, THE HAND BRAKE LIGHT FLASHED CONSTANTLY, AND THREE WARNING BEEPS ARE HEARD. A COMPUTER READING SAYS THERE IS NO CONNECTION WITH THE ABS UNIT. THE ABS DOESN'T WORK AT ALL. IT SOMETIMES OCCURS WHEN I FIRST START THE CAR, AND SOMETIMES AFTER DRIVING FOR A WHILE. THE CONSUMER STATED SOMEONE ELSE WAS DRIVING HER VEHICLE AND HE/SHE REAR ENDED ANOTHER PERSON. THE CONSUMER STATED THE ABS DID NOT FUNCTION AS DESIGNED. UPDATED 12/16/10 *TR

NHTSA ODI #10365630

Mileage unknown · Sep 14, 2008
Air BagsElectrical System

DASH DOES NOT SHOW IMPORTANT INFO TO MAINTAIN THE CAR PROPERLY. THE DIGITAL LETTERS HAVE DISAPPEARED. I HAVE NO IDEA WHAT'S GOING ON WITH MY A-6.. THE DEALERSHIP TOLD ME THAT ALL AUDI WITH THAT SAME FEATURE HAS THAT SAME PROBLEM. ALSO THERE IS A OIL LEAK THAT IS COMMON IN THE SAME MODELS AS MINE. *TR

NHTSA ODI #10242168

90,000 miles · Jul 28, 2008
Air Bags

THE "AIRBAG MODULES", MANUFACTURED BY BOSCH, IN MANY MODELS OF AUDI AUTOMOBILES APPEAR TO BE FAILING, INEXPLICABLY. THESE MODULES ACT AS THE CENTRAL "BRAIN" FOR A CAR'S AIRBAG SYSTEM AND IF THEY FAIL THE CAR'S AIRBAG SYSTEM IS RENDERED USELESS. IN MY CASE, MY MODULE FAILED INEXPLICABLY AND MUST BE REPLACED ($1000), HAVING NEVER …

Read full complaint

THE "AIRBAG MODULES", MANUFACTURED BY BOSCH, IN MANY MODELS OF AUDI AUTOMOBILES APPEAR TO BE FAILING, INEXPLICABLY. THESE MODULES ACT AS THE CENTRAL "BRAIN" FOR A CAR'S AIRBAG SYSTEM AND IF THEY FAIL THE CAR'S AIRBAG SYSTEM IS RENDERED USELESS. IN MY CASE, MY MODULE FAILED INEXPLICABLY AND MUST BE REPLACED ($1000), HAVING NEVER BEEN IN A COLLISION OR HAD AN AIRBAG DEPLOYMENT. AUDI AND BOSCH HAVE BEEN UNHELPFUL, GIVEN THAT MY CAR IS OUT OF WARRANTY. HOWEVER, IT SEEMS TO ME THAT GIVEN THE CRITICAL NATURE OF A CAR'S SAFETY SYSTEM, AND THE IMPOSSIBILITY OF TAMPERING WITH A COMPUTER MODULE HIDDEN DEEP IN THE RECESSES OF THE CAR, THE MANUFACTURERS SHOULD BE MORE PROACTIVE IN ADDRESSING THE ISSUE. A SIMPLE INTERNET SEARCH INDICATES THIS MAY BE A PERVASIVE PROBLEM, AND IT IS SCARY TO THINK OF HOW MANY CARS ARE OPERATING WITH "FAILED" SAFETY SYSTEMS! *TR

NHTSA ODI #10236138

58,099 miles · Mar 2, 2007
Air Bags

MY 2000 AUDI A6 2.7T, WITH 58099 MILES, WAS PARKED IN COVERED BUT AMBIENT TEMPERATURE PARKING LOT FOR THREE DAYS AT APPROXIMATELY OF. WHEN I RETURNED FROM TRAVEL AND STARTED THE CAR, THE AIRBAG WARNING LIGHT REMAINED ON. THE REPAIR FACILITY DISCOVERED THAT A SENSOR HAD SHORTED AND DESTROYED THE AIRBAG CONTROL UNIT. WHILE THE …

Read full complaint

MY 2000 AUDI A6 2.7T, WITH 58099 MILES, WAS PARKED IN COVERED BUT AMBIENT TEMPERATURE PARKING LOT FOR THREE DAYS AT APPROXIMATELY OF. WHEN I RETURNED FROM TRAVEL AND STARTED THE CAR, THE AIRBAG WARNING LIGHT REMAINED ON. THE REPAIR FACILITY DISCOVERED THAT A SENSOR HAD SHORTED AND DESTROYED THE AIRBAG CONTROL UNIT. WHILE THE WARNING LIGHT NOTIFIED ME OF THE FAILURE, IT DOES NOT SEEM REASONABLE THAT THE AIRBAG CONTROL SHOULD FAIL UNDER THESE CIRCUMSTANCES. *JB

NHTSA ODI #10184069

105,000 miles · Feb 22, 2007
Air Bags

DURING A COLD SNAP, THE AIR BAG WARNING LIGHT CAME ON WHEN THE CAR WAS STARTED IN THE MORNING. THE AIR BAG CONTROLLER WAS QUERIED FOR A FAULT CODE, AND THE CODE 65535, INTERNAL CONTROL MODULE MEMORY ERROR, WAS RETURNED. THE FACTORY MANUAL WAS CONSULTED AND THE REMEDY OFFERED WAS THE REPLACEMENT OF THE CONTROLLER, WITH THE INST…

Read full complaint

DURING A COLD SNAP, THE AIR BAG WARNING LIGHT CAME ON WHEN THE CAR WAS STARTED IN THE MORNING. THE AIR BAG CONTROLLER WAS QUERIED FOR A FAULT CODE, AND THE CODE 65535, INTERNAL CONTROL MODULE MEMORY ERROR, WAS RETURNED. THE FACTORY MANUAL WAS CONSULTED AND THE REMEDY OFFERED WAS THE REPLACEMENT OF THE CONTROLLER, WITH THE INSTRUCTION THAT THE CONTROLLER COULD NOT BE RESET USING THE SCAN TOOL. THE DEALER WAS CONTACTED FOR THE PART, APPROXIMATELY $900, AND IT WOULD HAVE TO BE ORDERED. TOTAL COST (FROM A POSTING ON AUDI WORLD WEB SITE) FOR REPAIR APPROXIMATELY $1500. OF CONCERN IS THE FACT THAT ON THE AUDI WORLD WEB SITE, VERY HEAVILY TILTED TOWARD DIY OWNERS, I SEARCHED FOR THE 65535 FAULT CODE AND IT RETURNED 229 CASES WHERE THEY SPECIFICALLY MENTIONED THE CODE, I DO NOT KNOW HOW MANY MORE MENTIONED THE PROBLEM WITHOUT MENTIONING THE CODE. I DID NOT LOOK AT ALL OF THEM, BUT, MANY DESCRIBED THE SAME COLD WEATHER COINCIDENCE WITH THE PROBLEM. IF THE PROBLEM IS A FAULTY CONTROLLER WHERE COLD INDUCES THE FAULT, EVERY VW PRODUCT, THAT SPENDS ANY TIME IN THE COLD, WITH THAT CONTROL, OR A VARIANT WITH THE SAME FLAW, R IS AT RISK. SEE MY EMAIL FOR THE REST OF THIS. YOUR SYSTEM WOULD NOT LET ME SEND IT AND WHEN I CALLED THEY COULD ONLY OFFER THAT I SEND AN EMAIL. *NM

NHTSA ODI #10183255

45,000 miles · Jan 26, 2005
Air BagsStructure

WHILE DRIVING AT HIGHWAY SPEEDS THERE WAS A BURNING SMELL COMING FROM THE VEHICLE. THE AIRBAG LIGHT BEGAN TO FLICKER ON AND OFF, AND THEN THE DRIVERS SIDE AIRBAG UNEXPECTEDLY DEPLOYED. THE VEHICLE WAS TOWED TO THE DEALER. *MR THE CONSUMER WAS TOLD THAT THE PROBLEM WAS A RESULT OF AN ELECTRICAL SHORT. THE SHORT WAS CAUSED BY…

Read full complaint

WHILE DRIVING AT HIGHWAY SPEEDS THERE WAS A BURNING SMELL COMING FROM THE VEHICLE. THE AIRBAG LIGHT BEGAN TO FLICKER ON AND OFF, AND THEN THE DRIVERS SIDE AIRBAG UNEXPECTEDLY DEPLOYED. THE VEHICLE WAS TOWED TO THE DEALER. *MR THE CONSUMER WAS TOLD THAT THE PROBLEM WAS A RESULT OF AN ELECTRICAL SHORT. THE SHORT WAS CAUSED BY AN IMPACT UNDER THE VEHICLE. THE CONSUMER HAS NO MEMORY OF ANY IMPACT UNDER THE VEHICLE. *TC

NHTSA ODI #10066663

Mileage unknown · Jan 17, 2005
Air Bags

VEHICLE IS OUT OF WARRANTY. VEHICLE HAS NEVER BEEN IN A ACIDENT. AIR BAG LIGHT IN INSTRUMENT PANEL CAME ON. TESTS BY AUDI DEALERSHIP AND INDEPENDENT REPAIR SHOP SHOW AIR BAG CONTROL MODULE NEEDED TO BE REPLACED. INDEPENTED REPAIR SHOP REPLACED AIR BAG CONTROL MODULE AT COST OF $879.50 PLUS 6% TAX. *JB

NHTSA ODI #10106464

Mileage unknown · Aug 7, 2001
Air BagsCrashInjury

WHILE STOPPED AT A RED LIGHT, CONSUMER WAS STRUCK HEAD ON BY A TRUCK, AIR BAGS FAILED TO DEPLOY, CONSUMER SUFFERED NECK INJURIES AND VEHICLE WAS DEEMED A TOTAL LOSS.*JB (ATTORNEY FOR CLIENT).

NHTSA ODI #562447

Official recalls

4

20V056000 · Air Bags:frontal:driver Side:inflator Module

Jan 31, 2020

Volkswagen Group of America, Inc. (VW) is recalling certain 2000-2001 TT Roadster, 2000 TT Coupe, 1999 Audi A8, 1998-2000 Audi A6, and 1999-2000 Audi A4 vehicles equipped with Non-Azide Driver air bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, possibly causing the air bag to deploy improperly in the event of a crash.

Consequence & remedy

Consequence: In the event of a crash necessitating air bag deployment, the air bag may not properly protect the occupant, increasing the risk of serious injury or death.

Remedy: Dealers will replace the driver frontal air bag inflator with an alternative inflator when the parts become available, free of charge. Owner notifications were mailed September 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69BT.

06V198000 · Electrical System

Jun 5, 2006

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.

Consequence & remedy

Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.

Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

04V133000 · Electrical System

Mar 18, 2004

ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.

Consequence & remedy

Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.

Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.

01V157000 · Fuel System, Gasoline:storage:tank Assembly

May 3, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.

Consequence & remedy

Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.

Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

RQ06003 · Driver's Side Dash Fire

Opened Feb 27, 2006 · Closed Jul 20, 2006

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:interior/under Dash

VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.

Additional source detail variants (2)

Electrical System

VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.

Electrical System:wiring:interior/under Dash

VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.

EA03025 · Drivers Side Dash Fire

Opened Nov 25, 2003 · Closed May 7, 2004

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Additional source detail variants (10)

Electrical System

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System:wiring:front Underhood

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System:wiring:front Underhood

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System:wiring:fuses And Circuit Breakers

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System:wiring:fuses And Circuit Breakers

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System:wiring:interior/under Dash

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System:wiring:interior/under Dash

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System:wiring

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

Electrical System:wiring

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

PE03035 · Drivers Side Dashboard Fire

Opened Jul 25, 2003 · Closed Nov 25, 2003

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash

OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.

Additional source detail variants (4)

Electrical System

OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.

Electrical System:wiring:fuses And Circuit Breakers

OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.

Electrical System:wiring:interior/under Dash

OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.

Electrical System:wiring

OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.

PE02008 · Brake And Clutch Pedal Bracket

Opened Jan 23, 2002 · Closed Jul 12, 2002

Status: closed (inferred from source dates) · Service Brakes, Hydraulic

No summary supplied.