IllustrationMY 1999 AUDI A6 2.8 HAS ABS CONTROL MODULE FAILURE. THIS APPEARS TO BE A COMMON PROBLEM AMONG 1996 TO 2001 AUDI'S AND VW'S LACK OF ANTI-LOCK BRAKING SYSTEM CONTROL MAKES MY VEHICLE UNSAFE. AUDI IS NOT WILLING TO CORRECT THIS PROBLEM. THIS PROBLEM AFFECTS A LARGE NUMBER OF VEHICLES.
1999 Audi A6
Owner reports · Recalls · Investigations
More warning signs than most A6 years
Owner complaints for the 1999 Audi A6 are substantially higher than the model-year median of 35.
About this comparison →How this year compares
Owner complaints by model year
Compare all A6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1325–50K
3350–75K
3775–100K
24100–150K
7150K+
119 reports with mileage · 98 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports23 fire reports14 injury reports
Service Brakes, Hydraulic complaints
31 reportsDRIVING HOME TONIGHT MY CAR ALL OF A SUDDEN STARTED ACCELERATING (I DRIVE AN AUDI A6 1999). USING THE BRAKES I WAS ABLE TO SLOW IT DOWN ENOUGH TO GET OFF THE FREEWAY THOUGH MY BRAKES SEEMED TO BE FIGHTING AGAINST THE CAR. I ROLLED THROUGH TWO STOP SIGNS AS MY CAR WOULD NOT STOP AND LUCKILY AVOIDING THE OTHER CARS WAITING THERE…
Read full complaint
DRIVING HOME TONIGHT MY CAR ALL OF A SUDDEN STARTED ACCELERATING (I DRIVE AN AUDI A6 1999). USING THE BRAKES I WAS ABLE TO SLOW IT DOWN ENOUGH TO GET OFF THE FREEWAY THOUGH MY BRAKES SEEMED TO BE FIGHTING AGAINST THE CAR. I ROLLED THROUGH TWO STOP SIGNS AS MY CAR WOULD NOT STOP AND LUCKILY AVOIDING THE OTHER CARS WAITING THERE I WAS ABLE TO PUT MY CAR IN PARK AND TURN OFF THE ENGINE. I WAITED TEN MINUTES OR SO AND TRIED STARTING MY CAR. THE ENGINE REVVED TO 4 TO 5000 RPMS SO, I QUICKLY SHUT IT OFF AGAIN. I WAITED AGAIN, TRIED IT ONCE MORE AND THE CAR STARTED FINE. I DROVE HOME, CALLED THE DEALERSHIP AND WAS TOLD I COULD BE SEEN ON 02/14/11. FOUR DAYS FROM NOW. THIS IS THE SECOND TIME THIS HAS HAPPENED. *TR
I HAVE A 1999 AUDI A6 QUATTRO -- ABS UNIT LIGHT FLASHES, DIAGNOSED AS A DEFECTIVE CONTROL UNIT. THIS APPEARS TO BE A VERY COMMON PROBLEM WITH AUDI AND VW AND A SERIOUS SAFETY ISSUE. *TR
ALL OF A SUDDEN MY ABS LIGHT CAME ON IN MY 1999 AUDI A6, AND THE BRAKE LIGHT STARTED FLASHING. I HAD A FULL LOSS OF MY ABS BRAKES ON ICY WINTER ROADS. I EVENTUALLY SLID OFF THE ROAD AND HIT A FENCE. THE ABS CONTROL MODULE ON MY CAR HAD FAILED, AND I'VE READ POSTS OF SEVERAL HUNDREDS OTHER HAVING THE SAME PROBLEM. IN MY CAR IT IS…
Read full complaint
ALL OF A SUDDEN MY ABS LIGHT CAME ON IN MY 1999 AUDI A6, AND THE BRAKE LIGHT STARTED FLASHING. I HAD A FULL LOSS OF MY ABS BRAKES ON ICY WINTER ROADS. I EVENTUALLY SLID OFF THE ROAD AND HIT A FENCE. THE ABS CONTROL MODULE ON MY CAR HAD FAILED, AND I'VE READ POSTS OF SEVERAL HUNDREDS OTHER HAVING THE SAME PROBLEM. IN MY CAR IT IS A CONSTANT ERROR, AND NO-ONE BUT AUDI CAN FIX THE PROBLEM. I ALSO CONTACTED AUDI, WHICH CLAIMS THAT THE ABS SYSTEM DISABLING IS NOT A SAFETY CONCERN. WHEN THERE'S A CHANCE THAT YOUR ABS (SOMETHING YOU'VE RELIED ON FOR YEARS) SUDDENLY SHUTS DOWN BECAUSE OF A WAY TOO COMMON ERROR, IT IS A MAJOR SAFETY CONCERN. I WAS LUCKY I ONLY GOT SOME DENTS TO MY CAR, BUT IF AUDI HAD RECALLED THESE I WOULDN'T HAVE HAD TO GET REPAIRS DONE TO MY CAR. UNFORTUNATELY SOMEONE WILL PROBABLY HAVE TO DIE BEFORE THIS SAFETY CONCERN IS TAKEN SERIOUSLY AND AUDI WILL DO A RECALL. *TR
1999 AUDI A6 AVANT WITH SERIOUS SAFETY ISSUES. CONSUMER WOULD LIKE AUDI TO PAY FOR THE LAST 4 REPAIRS THAT NEEDED TO BE DONE. CONSUMER HAS HAD SOME SERIOUS SAFETY ISSUES WITH THIS VEHICLE AND STATES THAT IT IS A LEMON. *KB THERE WAS A RUMBLING NOISE COMING FROM THE ENGINE, THERE WAS AN OIL LEAK COMING FROM THE ENGINE, THE ENGI…
Read full complaint
1999 AUDI A6 AVANT WITH SERIOUS SAFETY ISSUES. CONSUMER WOULD LIKE AUDI TO PAY FOR THE LAST 4 REPAIRS THAT NEEDED TO BE DONE. CONSUMER HAS HAD SOME SERIOUS SAFETY ISSUES WITH THIS VEHICLE AND STATES THAT IT IS A LEMON. *KB THERE WAS A RUMBLING NOISE COMING FROM THE ENGINE, THERE WAS AN OIL LEAK COMING FROM THE ENGINE, THE ENGINE LIGHT ILLUMINATED DUE TO A BAD PIPE, THE FRONT ROTORS AND PADS WERE REPLACED, THE TRANSMISSION WAS LEAKING, THE BACK WHEELS WERE DRAGGING SO THE PADS WOULD NOT RELEASE, THE BRAKE AND ABS LIGHT ILLUMINATED, THE CRUISE CONTROL WAS INOPERATIVE, T HE SUNROOF WAS INOPERATIVE, THE TIE RODS NEEDED TO BE REPLACED, THE TIMING BELT, WATER PUMP, GASKET OIL COOLER AND SERPENTINE BELT WERE ALL REPLACED. *JB
ABS FAILURE. FLASHING LIGHT,ABS(ORANGE) AND BRAKE LIGHT(RED)FOLLOWED BY ABOUT THREE HIGH PITCHED BEEPS. AFTER DOING ALOT OF RESEARCH ONLINE,FOUND OUT IT IS A COMMON PROBLEM WITH THIS TYPE OF BOSCH ABS SYSTEM ,AUDIS, VW'S AND OTHERS FITTED WITH THIS TYPE OF SYSTEM. *TR
TL*THE CONTACT OWNS A 1999 AUDI A6. THE CONTACT STATED THAT THE ABS MODULE HAS BEEN REPLACED NUMEROUS TIMES. THE INSTRUMENT PANEL INDICATES THAT THE ABS IS NOT FUNCTIONING PROPERLY. SHE STATED THAT THE AXLE ON THE DRIVER SIDE WAS REPLACED SIX TIMES IN THREE MONTHS. THE DEALER STATED THAT THE AXLE IS TOO SHORT. THE CONTACT S…
Read full complaint
TL*THE CONTACT OWNS A 1999 AUDI A6. THE CONTACT STATED THAT THE ABS MODULE HAS BEEN REPLACED NUMEROUS TIMES. THE INSTRUMENT PANEL INDICATES THAT THE ABS IS NOT FUNCTIONING PROPERLY. SHE STATED THAT THE AXLE ON THE DRIVER SIDE WAS REPLACED SIX TIMES IN THREE MONTHS. THE DEALER STATED THAT THE AXLE IS TOO SHORT. THE CONTACT STATED THAT THE PARTS HAVE BECOME VERY COSTLY. THE VIN, ENGINE SIZE, NUMBER OF CYLINDERS, AND SPEED WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 58,000.
TL* - THE CONTACT PURCHASED A 1999 AUDI A6. ON MARCH 19, 2007. THE CONTACT EXPLAINED THAT ON MARCH 20, 2007 THE CHECK ENGINE LIGHT TURNED ON FOR THE FIRST TIME ,AND THAT THERE WAS BURNT SMELL COMING FROM THE ENGINE. THE DEALER STATED THAT THERE WAS AIR IN THE GAS LINES. ON MARCH 21, 2007 THE AIR CONDITIONER STOPPED WORKING. …
Read full complaint
TL* - THE CONTACT PURCHASED A 1999 AUDI A6. ON MARCH 19, 2007. THE CONTACT EXPLAINED THAT ON MARCH 20, 2007 THE CHECK ENGINE LIGHT TURNED ON FOR THE FIRST TIME ,AND THAT THERE WAS BURNT SMELL COMING FROM THE ENGINE. THE DEALER STATED THAT THERE WAS AIR IN THE GAS LINES. ON MARCH 21, 2007 THE AIR CONDITIONER STOPPED WORKING. ON MARCH 22, 2007 THE CHECK ENGINE LIGHT TURNED ON A SECOND TIME. THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE CONTACT WAS TOLD THAT THE AIR CONDITIONER NEEDED TO BE REPAIRED, AND THAT THE ENGINE HOSES NEEDED TO BE TUNED. ON MARCH 24, 2007 THE VEHICLE WOULD NOT START. THE DEALERSHIP TRANSPORTED THE VEHICLE BACK TO THE REPAIR SHOP. THE CONTACT WAS TOLD THAT THIS PROBLEM WAS DUE TO A BAD BATTERY, THE HOSES WERE ADJUSTED. THEY WERE ONLY WAITING ON THE PARTS FOR THE AIR CONDITIONER. THE CONTACT HAD INFORMED THEM THAT THERE CONTINUED TO BE A STRONG BURNT SMELL COMING FROM THE ENGINE. ON MARCH 31, 2007 THE CONTACT TOOK THE VEHICLE BACK TO THE DEALERSHIP TO HAVE WORKED ON THE AIR CONDITION UNIT. ON APRIL 1 THE CONTACT HEARD A LOUD FAN NOISE FROM UNDER THE HOOD WHEN SHE STARTED THE VEHICLE. ON APRIL 4, 2007 THE CONTACT CALLED THE DEALER AND WAS TOLD THAT ALL VEHICLES GO THROUGH A 25 POINT INSPECTION BEFORE SALES. ON APRIL 7 THE VEHICLE WAS TAKEN TO A PROFESSIONAL DEALER, WHERE THE CONTACT WAS INFORMED THAT THERE WERE LEAKS ON THE FRONT AND THE BACK OF THE ENGINE. ALL ENGINE CAM SEALS, HOSES, AND ABS MODULE NEED TO BE REPLACED . THE REPAIR COSTS WOULD COME TO OVER $5000.00. THE CONTACT WANTED TO FILE A COMPLAINT AGAINST AMERICAR TRADING COMPANY 501 NORTH THOMPSON, SPRING DALE AR, 72764 (479-927-0333) SINCE THEY DID NOT REPORT THAT THESE PROBLEMS EXISTED ON THE VEHICLE PRIOR TO THE SALE. THE DEALER HAS NOT RETURNED THE CONTACTS CALLS AFTER THIS LAST FAILURE. THE FAILURE MILEAGE WAS 120,049, AND THE CURRENT MILEAGE WAS 121,594. *AK UPDATED 07/17/07. *JB
ABS LIGHT STAYS ON.. TOOK TO DEALER AND THEY SAID FAULTY CONTROL MODULE..$@$1000.00 TO REPAIR... WAS TOLD THAT THIS IS A COMMON PROBLEM WITH 1999 AUDI A6 AVANT...ALSO WAS TOLD THAT THIS PROBLEM ALMOST NEVER HAPPENS ON ANY OTHER AUTOMOBILE...CHECKED ON THE INTERNET AND FOUND MANY AUDI OWNERS HAVE HAD THE SAME PROBLEM..WHY SHOULD…
Read full complaint
ABS LIGHT STAYS ON.. TOOK TO DEALER AND THEY SAID FAULTY CONTROL MODULE..$@$1000.00 TO REPAIR... WAS TOLD THAT THIS IS A COMMON PROBLEM WITH 1999 AUDI A6 AVANT...ALSO WAS TOLD THAT THIS PROBLEM ALMOST NEVER HAPPENS ON ANY OTHER AUTOMOBILE...CHECKED ON THE INTERNET AND FOUND MANY AUDI OWNERS HAVE HAD THE SAME PROBLEM..WHY SHOULD WE PAY FOR AUDI'S FAULTY COMPONENTS? *JB
FAILURE OF CONTROL UNIT FOR ABS BRAKES. *NM
Official recalls
920V056000 · Air Bags:frontal:driver Side:inflator Module
Jan 31, 2020
Volkswagen Group of America, Inc. (VW) is recalling certain 2000-2001 TT Roadster, 2000 TT Coupe, 1999 Audi A8, 1998-2000 Audi A6, and 1999-2000 Audi A4 vehicles equipped with Non-Azide Driver air bag Inflators (NADI) that do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, possibly causing the air bag to deploy improperly in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, the air bag may not properly protect the occupant, increasing the risk of serious injury or death.
Remedy: Dealers will replace the driver frontal air bag inflator with an alternative inflator when the parts become available, free of charge. Owner notifications were mailed September 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69BT.
06V198000 · Electrical System
Jun 5, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
04V495000 · Vehicle Speed Control
Oct 12, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L, V6 5-VALVE ENGINES, AND AUTOMATIC TRANSMISSIONS, WHILE DRIVING DURING EXTREMELY LOW AMBIENT TEMPERATURES THE THROTTLE MAY FREEZE IN AN OPEN POSITION DUE TO ICE ACCUMULATING IN THE THROTTLE BODY.
Consequence & remedy
Consequence: IF THIS OCCURS, THE VEHICLE MAY FAIL TO REDUCE SPEED WHEN THE DRIVER LIFTS HIS/HER FOOT FROM THE GAS PEDAL. THIS LOSS OF VEHICLE CONTROL COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: AUDI WILL INSTALL A REPLACEMENT THROTTLE BODY KIT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 29, 2004. OWNERS MAY CONTACT AUDI AT 1-800-822-2834. OWNERS OF VEHICLES WHICH ARE NOT REGISTERED IN THE COLD-WEATHER STATES OF ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, VERMONT, WASHINGTON, WISCONSIN, AND WYOMING, WILL BE NOTIFIED OF A SERVICE ACTION, UNDER WHICH THEY WILL BE PROVIDED THE FREE REMEDY UPON REQUEST.
04V133000 · Electrical System
Mar 18, 2004
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Consequence & remedy
Consequence: A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
01V157000 · Fuel System, Gasoline:storage:tank Assembly
May 3, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.
Consequence & remedy
Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.
Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.
00V414000 · Steering:linkages:rod:relay:connecting
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence & remedy
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
99V248000 · Steering:linkages:rod:relay:connecting
Sep 13, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TIE RODS OF THE STEERING ASSEMBLY ARE PROTECTED ON EACH SIDE BY A SEAL TO PREVENT MOISTURE AND DUST PARTICLES FROM ENTERING THE SWIVEL BEARING MECHANISM. IT IS POSSIBLE THAT SOME TIE ROD SEALS MAY NOT SEAL PROPERLY.
Consequence & remedy
Consequence: IF MOISTURE AND/OR DUST PARTICLES ENTER THE SWIVEL BEARING MECHANISM, THE SWIVEL BEARING COULD WEAR OVER TIME DIMINISHING THE STEERING CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIE RODS.
99V131001 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
May 21, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A CONTROL VALVE IN THE VACUUM HOSE CONNECTING THE BRAKE BOOSTER TO THE INTAKE MANIFOLD MAY NOT OPEN OR CLOSE FULLY AT TEMPERATURES BELOW -4 F UNDER CERTAIN DRIVING CONDITIONS.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE INSUFFICIENT VACUUM TO BE PROVIDED TO THE BRAKE BOOSTER.
Remedy: DEALERS WILL INSTALL A VACUUM BY-PASS SYSTEM INTO VEHICLES OPERATED IN THESE STATES WHICH IS DESIGNED TO PROVIDE SUFFICIENT VACUUM FOR FULL BRAKE ASSIST UNDER ALL WEATHER CONDITIONS.
99V058000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Mar 22, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH QUATTRO DRIVE SYSTEM WHICH EMPLOYS A FUEL AND FUEL VAPOR LEAK DETECTION SYSTEM. IF THE VEHICLE IS REFUELED SHORTLY AFTER THE ENGINE IS STARTED, AND IS KEPT RUNNING WHILE BEING REFUELED, THE FUEL VAPOR RECOVERY SYSTEM COULD PRODUCE SUFFICIENT BACK PRESSURE TO CAUSE FUEL TO BE EJECTED AFTER A COMPLETE FILL-UP WHEN THE FUEL PUMP NOZZLE IS REMOVED FROM THE FILLER NECK.
Consequence & remedy
Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, FUEL SPRAY COULD RESULT IN FIRE OR POSSIBLE PERSONAL INJURY.
Remedy: VW IS PROVIDING A NEW PAGE FOR THE OWNER'S MANUAL AND ALSO REQUESTING OWNERS TO MAKE AN APPOINTMENT WITH THEIR DEALERS TO HAVE A LABEL CONTAINING IMPORTANT REFUELING INSTRUCTIONS INSTALLED INSIDE OF THE FUEL FILLER DOOR. DEALERS WILL ALSO REMOVE THE TIRE PRESSURE LABEL AND REPLACE IT WITH A NEW LABEL AFFIXED TO THE FENDER WELL AT THE RIGHT REAR DOOR.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8RQ06003 · Driver's Side Dash Fire
Opened Feb 27, 2006 · Closed Jul 20, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:interior/under Dash
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
Additional source detail variants (2)
Electrical System
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
Electrical System:wiring:interior/under Dash
VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.
EA04017 · STUCK-OPEN Throttle
Opened Jun 30, 2004 · Closed Feb 10, 2005
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
VWOA HAS RECALLED APPROXIMATELY 28,300 MY 1998-99 A6 VEHICLES IN COLD WEATHER STATES THAT EXPERIENCED THE HIGHEST RATE OF THROTTLE ICING INCIDENTS IN THE SUBJECT VEHICLES (04V-495).THE FAILURE RATE IN THE A4 AND PASSAT VEHICLES IS MUCH LOWER THAN IN THE RECALLED VEHICLES.ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE A4 AND PASSAT VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE AUDI A4 OR VW PASSAT VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES. FOR FURTHER DETAILS SEE THE ATTACHED CLOSING REPORT.
PE04023 · STUCK-OPEN Throttle
Opened Mar 5, 2004 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
COMPLAINTS RECEIVED BY ODI AND AUDI ALLEGE THAT, IN EXTREME COLD WEATHER, THE THROTTLE MAY UNEXPECTEDLY FAIL TO RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, MAKING IT DIFFICULT TO STOP THE VEHICLE.IN MARCH OF 2004, AUDI PERFORMED A SERIES OF TESTS TO INVESTIGATE THE POSSIBLE CAUSES OF THROTTLE ICING.AUDI CONCLUDED THAT UNDER CERTAIN DRIVING CONDITIONS - ONLY SHORT DISTANCE TRIPS OVER SEVERAL WEEKS WHERE COOLANT TEMPERATURE REMAINS BELOW 70?C (158?F) - WATER MAY ACCUMULATE IN THE MOTOR OIL. WATER THAT HAS ACCUMULATED IN THE MOTOR OIL WILL EVAPORATE AFTER THE ENGINE OIL TEMPERATURE EXCEEDS 70?C (158?F) AND COULD, WITHIN 15 TO 20 MINUTES OF DRIVING AT A CONSTANT SPEED WITH AN OUTSIDE TEMPERATURE BELOW -20?C (-4OF), CAUSE ICE TO FORM IN THE THROTTLE BODY.ACCORDING TO AUDI, THIS CONDITION OCCURS AT RELATIVELY LOW THROTTLE SETTINGS AND RESULTS IN THROTTLE STICKING AT POSITIONS THAT CAN BE CONTROLLED BY BRAKING.DURING TYPICAL VEHICLE USAGE (MIXTURE OF SHORT AND LONG DISTANCE DRIVING) THIS PHENOMENON IS NOT EXPECTED TO OCCUR.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Additional source detail variants (4)
Fuel System, Gasoline
COMPLAINTS RECEIVED BY ODI AND AUDI ALLEGE THAT, IN EXTREME COLD WEATHER, THE THROTTLE MAY UNEXPECTEDLY FAIL TO RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, MAKING IT DIFFICULT TO STOP THE VEHICLE.IN MARCH OF 2004, AUDI PERFORMED A SERIES OF TESTS TO INVESTIGATE THE POSSIBLE CAUSES OF THROTTLE ICING.AUDI CONCLUDED THAT UNDER CERTAIN DRIVING CONDITIONS - ONLY SHORT DISTANCE TRIPS OVER SEVERAL WEEKS WHERE COOLANT TEMPERATURE REMAINS BELOW 70?C (158?F) - WATER MAY ACCUMULATE IN THE MOTOR OIL. WATER THAT HAS ACCUMULATED IN THE MOTOR OIL WILL EVAPORATE AFTER THE ENGINE OIL TEMPERATURE EXCEEDS 70?C (158?F) AND COULD, WITHIN 15 TO 20 MINUTES OF DRIVING AT A CONSTANT SPEED WITH AN OUTSIDE TEMPERATURE BELOW -20?C (-4OF), CAUSE ICE TO FORM IN THE THROTTLE BODY.ACCORDING TO AUDI, THIS CONDITION OCCURS AT RELATIVELY LOW THROTTLE SETTINGS AND RESULTS IN THROTTLE STICKING AT POSITIONS THAT CAN BE CONTROLLED BY BRAKING.DURING TYPICAL VEHICLE USAGE (MIXTURE OF SHORT AND LONG DISTANCE DRIVING) THIS PHENOMENON IS NOT EXPECTED TO OCCUR.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Vehicle Speed Control:cables
COMPLAINTS RECEIVED BY ODI AND AUDI ALLEGE THAT, IN EXTREME COLD WEATHER, THE THROTTLE MAY UNEXPECTEDLY FAIL TO RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, MAKING IT DIFFICULT TO STOP THE VEHICLE.IN MARCH OF 2004, AUDI PERFORMED A SERIES OF TESTS TO INVESTIGATE THE POSSIBLE CAUSES OF THROTTLE ICING.AUDI CONCLUDED THAT UNDER CERTAIN DRIVING CONDITIONS - ONLY SHORT DISTANCE TRIPS OVER SEVERAL WEEKS WHERE COOLANT TEMPERATURE REMAINS BELOW 70?C (158?F) - WATER MAY ACCUMULATE IN THE MOTOR OIL. WATER THAT HAS ACCUMULATED IN THE MOTOR OIL WILL EVAPORATE AFTER THE ENGINE OIL TEMPERATURE EXCEEDS 70?C (158?F) AND COULD, WITHIN 15 TO 20 MINUTES OF DRIVING AT A CONSTANT SPEED WITH AN OUTSIDE TEMPERATURE BELOW -20?C (-4OF), CAUSE ICE TO FORM IN THE THROTTLE BODY.ACCORDING TO AUDI, THIS CONDITION OCCURS AT RELATIVELY LOW THROTTLE SETTINGS AND RESULTS IN THROTTLE STICKING AT POSITIONS THAT CAN BE CONTROLLED BY BRAKING.DURING TYPICAL VEHICLE USAGE (MIXTURE OF SHORT AND LONG DISTANCE DRIVING) THIS PHENOMENON IS NOT EXPECTED TO OCCUR.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Vehicle Speed Control:linkages
COMPLAINTS RECEIVED BY ODI AND AUDI ALLEGE THAT, IN EXTREME COLD WEATHER, THE THROTTLE MAY UNEXPECTEDLY FAIL TO RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, MAKING IT DIFFICULT TO STOP THE VEHICLE.IN MARCH OF 2004, AUDI PERFORMED A SERIES OF TESTS TO INVESTIGATE THE POSSIBLE CAUSES OF THROTTLE ICING.AUDI CONCLUDED THAT UNDER CERTAIN DRIVING CONDITIONS - ONLY SHORT DISTANCE TRIPS OVER SEVERAL WEEKS WHERE COOLANT TEMPERATURE REMAINS BELOW 70?C (158?F) - WATER MAY ACCUMULATE IN THE MOTOR OIL. WATER THAT HAS ACCUMULATED IN THE MOTOR OIL WILL EVAPORATE AFTER THE ENGINE OIL TEMPERATURE EXCEEDS 70?C (158?F) AND COULD, WITHIN 15 TO 20 MINUTES OF DRIVING AT A CONSTANT SPEED WITH AN OUTSIDE TEMPERATURE BELOW -20?C (-4OF), CAUSE ICE TO FORM IN THE THROTTLE BODY.ACCORDING TO AUDI, THIS CONDITION OCCURS AT RELATIVELY LOW THROTTLE SETTINGS AND RESULTS IN THROTTLE STICKING AT POSITIONS THAT CAN BE CONTROLLED BY BRAKING.DURING TYPICAL VEHICLE USAGE (MIXTURE OF SHORT AND LONG DISTANCE DRIVING) THIS PHENOMENON IS NOT EXPECTED TO OCCUR.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Vehicle Speed Control
COMPLAINTS RECEIVED BY ODI AND AUDI ALLEGE THAT, IN EXTREME COLD WEATHER, THE THROTTLE MAY UNEXPECTEDLY FAIL TO RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, MAKING IT DIFFICULT TO STOP THE VEHICLE.IN MARCH OF 2004, AUDI PERFORMED A SERIES OF TESTS TO INVESTIGATE THE POSSIBLE CAUSES OF THROTTLE ICING.AUDI CONCLUDED THAT UNDER CERTAIN DRIVING CONDITIONS - ONLY SHORT DISTANCE TRIPS OVER SEVERAL WEEKS WHERE COOLANT TEMPERATURE REMAINS BELOW 70?C (158?F) - WATER MAY ACCUMULATE IN THE MOTOR OIL. WATER THAT HAS ACCUMULATED IN THE MOTOR OIL WILL EVAPORATE AFTER THE ENGINE OIL TEMPERATURE EXCEEDS 70?C (158?F) AND COULD, WITHIN 15 TO 20 MINUTES OF DRIVING AT A CONSTANT SPEED WITH AN OUTSIDE TEMPERATURE BELOW -20?C (-4OF), CAUSE ICE TO FORM IN THE THROTTLE BODY.ACCORDING TO AUDI, THIS CONDITION OCCURS AT RELATIVELY LOW THROTTLE SETTINGS AND RESULTS IN THROTTLE STICKING AT POSITIONS THAT CAN BE CONTROLLED BY BRAKING.DURING TYPICAL VEHICLE USAGE (MIXTURE OF SHORT AND LONG DISTANCE DRIVING) THIS PHENOMENON IS NOT EXPECTED TO OCCUR.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
EA03025 · Drivers Side Dash Fire
Opened Nov 25, 2003 · Closed May 7, 2004
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Additional source detail variants (10)
Electrical System
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:front Underhood
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:front Underhood
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:fuses And Circuit Breakers
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:fuses And Circuit Breakers
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring:interior/under Dash
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
Electrical System:wiring
THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.
PE03035 · Drivers Side Dashboard Fire
Opened Jul 25, 2003 · Closed Nov 25, 2003
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Additional source detail variants (4)
Electrical System
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring:fuses And Circuit Breakers
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring:interior/under Dash
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
Electrical System:wiring
OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.
PE03019 · Steering Wheel Heater Overheats
Opened May 15, 2003 · Closed Sep 17, 2003
Status: closed (inferred from source dates) · Steering: Steering Wheel/handle Bar
THIS PE WAS OPENED BASED ON FOUR ODI COMPLAINTS THAT THE STEERING WHEEL OVERHEATS. VW HAS SHOWN THAT MOISTURE AND PRESPIRATION PERMEATE THE STEERING WHEEL COVER CAUSING THE HEATING ELEMENT TO CORRODE.THIS CORROSION MAY CAUSE A SMALL, LOCALIZED AREA OF THE STEERING WHEEL TO EXPERIENCE A BRIEF DURATION OF OVERHEATING.THERE ARE NO REPORTS OF THE STEERING WHEEL SUSTAINING COMBUSTION. THE INVESTIGATION HAS FOUND NO OCCURRENCES OF SEVERE BURNING AND NO CONSUMERS REQUIRED MEDICAL ATTENTION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02008 · Brake And Clutch Pedal Bracket
Opened Jan 23, 2002 · Closed Jul 12, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
PE99001 · Fuel Expulsion
Opened Jan 1, 1999 · Closed Mar 24, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
BY LETTER DATED MARCH 22, 1999, VOLKSWAGEN NOTIFIED NHTSA THAT IT WOULD TAKE SAFETY RECALL ACTION TO CORRECT THE SPITBACK PROBLEM ON ALL THE SUBJECT VEHICLES.BASED ON THE MANUFACTURER'S RECALL ACTION (ODI 99V-058), THIS INVESTIGATION IS CLOSED.