Engine. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports0 fire reports2 injury reports

Structure complaints

4 reports

Clear category filter

Mileage unknown · Jan 10, 2025

Structure

Read full complaint

I was driving along the express way when I heard a loud explosion, I look up to see my sunroof exploded and there was glass all over the kids and I. The explosion was so loud I lost control of the car and almost veered off the road. It was terrifying. It happened last year in the winter then happened this year as well. The temperature outside was about 30degrees, and I was driving about 70mph. There were no other cars in front of me at the time. My daughter and I had scratches from the glass on our back

NHTSA ODI #11635186

Mileage unknown · Apr 17, 2023

Structure

Sunroof exploded while driving down the highway. There was no impact from foreign objects and glass breakage shows upward breaks. No injury sustained due to shade being closed.

NHTSA ODI #11517462

30,000 miles · Sep 28, 2020

StructureUnknown Or OtherInjury

THE ELECTRONIC TRUNK OF MY AUDI A5 FAILED TO STOP CLOSING ONCE IT HIT ME ON THE HEAD. THE HATCH KEPT CLOSING IN UNTIL I WAS ABLE TO MOVE MY BODY OUT OF THE WAY HOWEVER AT THIS POINT THE HATCH ALREADY CAUSED A LACERATION TO MY SKULL WHICH RESULTED IN A VISIT TO THE EMERGENCY ROOM. VEHICLE WAS PARKED AND THE ENGINE WAS ON.

NHTSA ODI #11361546

65,809 miles · Mar 31, 2020

StructureUnknown Or OtherVisibility/wiper

Read full complaint

WHILE DRIVING ON A STRAIGHT, FLAT SECTION OF I-95 IN FLORIDA AT 70MPH, MY 2 YEAR OLD 2018 AUDI A5 CABRIO'S DRIVER'S SIDE SUN VISOR SUDDENLY BROKE OFF AT ITS BASE AND LANDED WITH FORCE ON MY STEERING WHEEL. I'D MOVED THE VISOR INTO THE UP POSITION, FLUSH WITH THE FRAME, AND IN DOING SO, THE VISOR BROKE OFF AT THE BASE. I HAD NOT, NOR HAD I EVER, MOVED THE VISOR WITH A LOT OF FORCE. EVEN WHEN THE CAR WAS NEW, THE VISOR HAD ALWAYS BEEN TOO TIGHT, TOO SHORT, AND DIFFICULT TO MOVE. THE RESULTANT DISTRACTION OF A HEAVY VISOR DROPPING ONTO MY STEERING WHEEL CAUSED ME TO SWERVE AT 70MPH. FORTUNATELY TRAFFIC WAS LIGHT THAT DAY AND NO ACCIDENT OCCURRED. DUE TO A DESIGN FLAW, THE VISOR CAN'T SWING ON ITS SUPPORT BAR AS IT SHOULD. AFTER IT BROKE OFF, I HAD TO USE VISE GRIPS TO MAKE IT SWING AT ALL. I THEN TRIED LUBRICATING THE SUPPORT BAR INSIDE THE VISOR WITH WD-40, WHICH DID NOT HELP. HAD I TRIED TO REATTACH THE VISOR WITH GLUE, THE TORQUE ON THE SUPPORT BAR CAUSED BY THE VISOR'S INABILITY TO SWING FREELY ON ITS AXIS SUGGESTS THAT IT WOULD INSTANTLY BREAK OFF AT THE BASE AGAIN. THE PASSENGER SIDE VISOR HAS NOT FALLEN OFF YET, BUT THE SAME DESIGN WILL CAUSE THAT TO HAPPEN EVENTUALLY. THIS VEHICLE HAD A 4 YEAR/50K MILE WARRANTY, BUT I HAD JUST EXCEEDED THE MILEAGE LIMIT SO IT WAS NO LONGER WARRANTED. I NOTIFIED BOTH MY AUDI DEALER AND AUDI USA ABOUT THIS SAFETY ISSUE. AUDI USA SAYS THAT THEY WILL NOT ISSUE A SERVICE ADVISORY OR RECALL, AND WILL NOT COVER THE PRESENT AND FUTURE DAMAGE TO BOTH VISORS. DESPITE THE SUN VISORS BEING NECESSARY SAFETY EQUIPMENT - ESPECIALLY IN FLORIDA - AUDI DENIES ANY CULPABILITY FOR THIS PROBLEM. THERE ARE MANY ANECDOTES ONLINE OF THIS SAME PROBLEM FROM OTHER DRIVERS OF THIS SAME YEAR/MAKE/MODEL/INTERIOR COLOR, AND IT IS NOT UNIQUE TO MY VEHICLE. MORE SPECIFICALLY ALL THE OTHER INCIDENTS ARE HAPPENING TO AUDIS WITH DARK GRAY VISORS LIKE MINE.

NHTSA ODI #11319824

Official recalls

21V874000 · Air Bags:sensor:occupant Classification:front Passenger; Seats

Nov 10, 2021

Volkswagen Group of America, Inc. (Audi) is recalling certain 2017-2020 A4 Allroad, A4 Sedan, 2018-2019 RS5 Coupe, 2019 RS5 Sportback, 2018-2020 A5 Cabriolet, A5 Coupe, A5 Sportback, S4 Sedan, S5 Cabriolet, S5 Coupe, and Audi S5 Sportback vehicles. The cable connecting the seat heater to the Passenger Occupant Detection System (PODS) may have a contact fault, causing the software to misdiagnose a malfunction and disable the passenger air bag.

Consequence & remedy

Consequence: A disabled passenger air bag increases the risk of injury in the event of a crash.

Remedy: Dealers will replace the connecting cable and either the heating mat or entire seat cover, free of charge. Owner notification letters were mailed January 7, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 74E3. This recall is an expansion of Recall 19V-547 (74D9). Vehicles previously repaired under 19V-547 will need to return for the new remedy.

Additional source detail variants (2)

Air Bags:sensor:occupant Classification:front Passenger

Consequence: A disabled passenger air bag increases the risk of injury in the event of a crash.

Remedy: Dealers will replace the connecting cable and either the heating mat or entire seat cover, free of charge. Owner notification letters were mailed January 7, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 74E3. This recall is an expansion of Recall 19V-547 (74D9). Vehicles previously repaired under 19V-547 will need to return for the new remedy.

Seats

Consequence: A disabled passenger air bag increases the risk of injury in the event of a crash.

19V547000 · Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification

Jul 24, 2019

Volkswagen Group of America, Inc. (Audi) is recalling certain 2018-2019 Audi RS5 Sportback, 2018 S5 Cabriolet, S5 Sportback, S5 Coupe, S4 Sedan, A5 Cabriolet, A5 Sportback, A5 Coupe, and 2017-2018 A4 Sedan and A4 Allroad vehicles. Oxidation on the Passenger Occupant Detection System (PODS) connecting cable may cause the software to misdiagnose a malfunction and disable the passenger air bag.

Consequence & remedy

Consequence: A disabled passenger air bag increases the risk of injury in the event of a crash.

Remedy: Audi will notify owners, and dealers will install cable ties to the harness, free of charge. The recall began September 9, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Audi's number for this recall is 74D9.

Additional source detail variants (2)

Air Bags:frontal:passenger Side:inflator Module

Consequence: A disabled passenger air bag increases the risk of injury in the event of a crash.

Remedy: Audi will notify owners, and dealers will install cable ties to the harness, free of charge. The recall began September 9, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Audi's number for this recall is 74D9.

Air Bags:sensor:occupant Classification

Consequence: A disabled passenger air bag increases the risk of injury in the event of a crash.

18V893000 · Suspension:front

Dec 17, 2018

Volkswagen Group of North America (Volkswagen) is recalling certain 2018 Audi A5 Sportback vehicles. The front suspension fasteners may not have been sufficiently tightened during vehicle production, possibly resulting in a front wheel becoming loose.

Consequence & remedy

Consequence: A loose front wheel may increasing the risk of a crash.

Remedy: Volkswagen has notified owners, and dealers will inspect the front suspension fasteners, and replace them as necessary, free of charge. The recall began January 23, 2019. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 40O2.

18V836000 · Air Bags:frontal:passenger Side:inflator Module

Nov 27, 2018

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Audi A5 Sportback and 2017-2018 Audi A4 Allroad vehicles. A passenger air bag module mounting screw may not have been sufficiently tightened, possibly affecting the deployment of the air bag in the event of a crash.

Consequence & remedy

Consequence: If the air bag does not deploy correctly in the event of a crash, it can increase the risk of an injury.

Remedy: Volkswagen will notify owners, and dealers will inspect the air bag mounting screw, tightening or replacing it as necessary, free of charge. The recall began December 19, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69Y4.

17V822000 · Air Bags:side/window

Dec 20, 2017

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Audi A5 Coupe vehicles. The affected vehicles were built with head curtain air bag assemblies that may not unfold properly. As such, these vehicle fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."

Consequence & remedy

Consequence: In the event of a crash necessitating deployment of the head curtain air bag, if the air bag does not deploy properly, the vehicle occupants have an increased risk of injury.

Remedy: Audi will notify owners, and dealers will modify the head curtain air bags so that they deploy properly, free of charge. The recall began on January 18, 2018. Owners may contact Audi customer service at 11-800-253-2834. Volkswagen's number for this recall is 69T7.

17V675000 · Structure:body:door:hinge And Attachments

Oct 25, 2017

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2018 Audi A4 Sedan and A4 allroad, and 2018 A5 Sportback vehicles. The aluminum trim on the front and rear doors can come loose from around the door speakers, leaving sharp edges exposed.

Consequence & remedy

Consequence: The sharp edges of the speaker trim increase the risk of injury to vehicle occupants.

Remedy: Audi will notify owners, and dealers will replace the speaker cover aluminum trim, free of charge. The recall began March 13, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 70G6.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.