IllustrationACCELERATOR STUCK FULL OPEN WHILE IT WAS PUSHED TO THE FLOORBOARD WHEN ACCELERATING ONTO A FREEWAY. HAD TO STAND ON THE BRAKES WITH ONE FOOT AND STOMP REPEATEDLY ON THE ACCELERATOR WITH THE OTHER UNTIL THE ACCELERATOR RELEASED.*AK
2004 Audi A4
Owner reports · Recalls · Investigations
More warning signs than most A4 years
Owner complaints for the 2004 Audi A4 are substantially higher than the model-year median of 76.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all A4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
250–25K
4125–50K
5150–75K
2975–100K
16100–150K
6150K+
168 reports with mileage · 21 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports3 fire reports5 injury reports
Vehicle Speed Control complaints
16 reportsDT*: THE CONTACT STATED WHILE DRIVING 35 MPH UPHILL ON A STREET, UPON MAKING A RIGHT TURN, THE VEHICLE ACCELERATED TO 40 MPH WITHOUT WARNING. THE CONTACT APPLIED BRAKE PRESSURE WHICH STOPPED THE ACCELERATION. THE VEHICLE WAS INSPECTED BY A DEALER WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS ALERTED.
WHILE COMMUTING TO WORK, THE ACCELERATOR PEDAL ON MY 2004 AUDI A4 CABRIOLET STUCK TO THE FLOOR. AT THE TIME, I WAS DRIVING APPROXIMATELY 35-40 MPH. THE PEDAL SUDDENLY MOVED AWAY FROM MY FOOT, STUCK TO THE FLOOR, AND MY CAR STARTED TO RAPIDLY INCREASE IN SPEED. NOT KNOWING EXACTLY WHAT WAS GOING ON, I HIT THE BRAKES, TO NO AVA…
Read full complaint
WHILE COMMUTING TO WORK, THE ACCELERATOR PEDAL ON MY 2004 AUDI A4 CABRIOLET STUCK TO THE FLOOR. AT THE TIME, I WAS DRIVING APPROXIMATELY 35-40 MPH. THE PEDAL SUDDENLY MOVED AWAY FROM MY FOOT, STUCK TO THE FLOOR, AND MY CAR STARTED TO RAPIDLY INCREASE IN SPEED. NOT KNOWING EXACTLY WHAT WAS GOING ON, I HIT THE BRAKES, TO NO AVAIL. THE ENGINE WAS SCREAMING AS THE RPMS RACED INTO THE 7000S. I TRIED TO JIGGLE THE GAS PEDAL FREE WITH MY FOOT, BUT IT WAS STUCK AND WOULD NOT BUDGE. THE BRAKES, WHICH I PRESSED ON AGAIN WITH ALL MY STRENGTH, WOULD NOT OVERPOWER THE ENGINE. I THREW THE MANAUL TRANSMISSION INTO "PARK" BUT THAT DID NOT STOP THE CAR EITHER. I FINALLY TURNED THE IGNITION OFF AND THE CAR CAME TO A GRINDING HALT IN THE MIDDLE OF THE STREET. THE CAR WAS TOWED TO THE CLOSET AUDI DEALERSHIP, HOEHN AUDI. THEY HAD THE CAR FOR TWO WEEKS BUT TOLD ME SINCE THEY WERE NOT ABLE TO RECREATE THE PROBLEM AND DID NOT DETECT ANY MALFUNCTIONS IN THE CAR'S COMPUTER, THERE WAS NOTHING WRONG WITH MY CAR NOR WAS THERE ANYTHING THEY COULD DO FOR ME. IN FACT, THEY TRIED TO TELL ME THAT THE ACCELERATOR MAY HAVE GOTTEN STUCK UNDER THE FLOOR MAT. I TOLD THEM THAT WAS NOT POSSIBLE AND THAT I WAS LOOKING AT THE ACCELERATOR AS I WAS TRYING TO GET IT UNSTUCK AND THERE WAS NO FLOOR MAT IN THE WAY. I ALSO FILED A COMPLAINT WITH AUDI'S CUSTOMER CARE ADVOCATES. MY COMPLAINT WAS DENIED BECAUSE THE DEALERSHIP DID NOT FIND ANYTHING WRONG WITH MY CAR. I THEN TOOK MY CAR TO THE AUDI DEALERSHIP WHERE I LEASED THE VEHICLE, MIRAMAR AUDI, FOR A SECOND OPINION. THEY, TOO, TOLD ME THAT THEY WERE NOT ABLE TO DETECT ANYTHING WRONG WITH MY CAR AND THAT THERE WAS NOTHING MORE THEY COULD DO FOR ME. THEY TOLD ME THAT THEY BELIEVED AUDI CORPORATE WAS INVOLVED BUT WOULD NOT PROVIDE WITH THE NAME OF ANYONE AT AUDI CORPORATE WITH WHOM I COULD DISCUSS THE ISSUE FURTHER. THEY ALSO STATED THAT THEY HAD THREE OTHER AUDIS IN THEIR SERVICE DEPT FOR THE SAME PROBLEM.
2004 AUDI A4 ACCELERATED FULL THROTTLE WITH PEDAL STUCK TO FLOOR ON 5/20/05. CAR WOULD NOT DECELERATE AND BRAKING HELPED AVERT ACCIDENT. VEHICLE WAS TOWED TO DEALER AND TESTING FOUND NOTHING.
WHILE DRIVING ON THE HIGHWAY AT 50 MPH, THE VEHICLE PROCEED TO LAUCH FORWARD AT A HIGH RATE OF SPEED, THE RPM'S WERE IN THE RED, VEHICHLE HAD TO BE PUT IN NEUTRAL AND ENGINE TURNED OFF IMMEDIATELY TO AVOID DAMAGE. VEHICLE WAS RESTARTED, WHEN WE HIT THIRD GEAR, VEHICLE AGAIN LAUCHED FORWARD, PEDAL WAS PRACTICALY GLUED TO THE FLO…
Read full complaint
WHILE DRIVING ON THE HIGHWAY AT 50 MPH, THE VEHICLE PROCEED TO LAUCH FORWARD AT A HIGH RATE OF SPEED, THE RPM'S WERE IN THE RED, VEHICHLE HAD TO BE PUT IN NEUTRAL AND ENGINE TURNED OFF IMMEDIATELY TO AVOID DAMAGE. VEHICLE WAS RESTARTED, WHEN WE HIT THIRD GEAR, VEHICLE AGAIN LAUCHED FORWARD, PEDAL WAS PRACTICALY GLUED TO THE FLOOR, TRYING TO PRY PEDAL UP WITH FOOT WAS NO USE, AGAIN PUT IN NEUTRAL AND PULLED OVER CAR AND TURNED OFF ENGINE. WHEN WE STARTED THE CAR FOR THE THIRD TIME, WE SAT WITH IT IN NEUTRAL AND ENGINE BEGAN TO RAISE. CAR WAS BEING TOWED TO DEALER. WE HAVE NOT HEARD ANY OUTCOME, BUT WE ARE VERY SCARED TO EVER DRIVE THE VEHICLE AGAIN.*AK
VEHICLE LURCHED OR ACCELERATED UPON FINAL PARKING NEAR A STOP WITH FOOT OFF ACCELERATOR PEDAL AND ON BRAKE PEDAL. CAR ACCELERATED FOR MORE THAN HALF A MILE AT 80 MPH. CONSUMER WAS ABLE TO CONTROL VEHICLE AND PUT IT IN NEUTRAL. DEALER INDICATED VEHICLE OPERATED AS DESIGNED BY THE MANUFACTURER, THERE WAS NOTHING WRONG WITH VEH…
Read full complaint
VEHICLE LURCHED OR ACCELERATED UPON FINAL PARKING NEAR A STOP WITH FOOT OFF ACCELERATOR PEDAL AND ON BRAKE PEDAL. CAR ACCELERATED FOR MORE THAN HALF A MILE AT 80 MPH. CONSUMER WAS ABLE TO CONTROL VEHICLE AND PUT IT IN NEUTRAL. DEALER INDICATED VEHICLE OPERATED AS DESIGNED BY THE MANUFACTURER, THERE WAS NOTHING WRONG WITH VEHICLE.*AK
Official recalls
216V382000 · Air Bags:frontal:passenger Side:inflator Module
Jun 1, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2004-2008 Audi A4, and 2005-2011 Audi A6 vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Volkswagen is recalling certain model year 2004-2008 Audi A4, and 2005-2008 Audi A6 vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Volkswagen is recalling model year 2004 Audi A4 vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Audi will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Owner notification letters were mailed April 28, 2017. Owners may contact Audi customer service at 1-800-822-2834.
05V096000 · Exterior Lighting:headlights
Mar 15, 2005
ON CERTAIN PASSENGER VEHICLES, THERE IS A POSSIBILITY OF XENON HEADLAMP COATING DEGRADATION OVER TIME. THE LUMINOUS TRANSMITTANCE OF THE HEADLAMP MAY DECREASE OVER A PERIOD OF TIME.
Consequence & remedy
Consequence: THIS CONDITION COULD AFFECT A DRIVER'S FIELD OF VIEW, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT XENON HEADLAMP REFLECTORS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08027 · Engine Stalling - Fuel Pump Failure
Opened Apr 14, 2008 · Closed Aug 6, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump
IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PE08-027, VOLKSWAGEN AG (VW) STATED THAT IT BELIEVES THAT THE POSSIBLE CAUSAL OR CONTRIBUTORY FACTORS OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES COULD RESULT FROM EXCESSIVE ACCUMULATION OF FOREIGN MATERIALS IN THE FUEL FILTER.IN RARE CASES, THE FUEL FILTER COULD BECOME CLOGGED, WHICH CAN CAUSE INCREASED PRESSURE ON THE PUMP.VW INDICATED THAT ENGINE STALLS RESULTING FROM THIS CONDITION ARE RARE AND WOULD BE PRECEDED BY SYMPTOMS SUCH AS REDUCED ENGINE POWER, NOISE OR HESITATION.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA DETERMINED THAT THE RATE OF ENGINE STALL INCIDENTS RESULTING FROM FUEL PUMP FAILURE IS LOW AT APPROXIMATELY 0.2 PERCENT AFTER THREE YEARS IN SERVICE. ON JANUARY 17, 2006, VW SUBMITTED A DEFECT INFORMATION REPORT TO ODI CONCERNING A SAFETY RECALL TO ADDRESS A DEFECT IN THE FUEL PUMPS OF APPROXIMATELY 74,000 MODEL YEAR (MY) 2003 VOLKSWAGEN PASSAT (47,000), AUDI A4 (20,000) AND AUDI A6 (7,000) VEHICLES BUILT FROM SEPTEMBER 2002 THROUGH MARCH 2003 (NHTSA RECALL NO. 06V-017, VW RECALL NOS. M7 FOR PASSAT AND JL FOR AUDI A4 AND A6).ACCORDING TO VW, A SUB-SUPPLIER EXPERIENCED AN UNKNOWN CHANGE IN THE MATERIAL COMPOSITION OF THE CARBON-BRUSH SET USED IN THE ELECTRIC MOTOR IN THE FUEL PUMP, WHICH COULD LEAD TO INCREASED WEAR OF THE CARBON-BRUSH SETS, WHICH IN TURN CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE.ON JULY 23, 2007, VW EXPANDED THE SCOPE OF THE RECALL TO INCLUDE VEHICLES MANUFACTURED FROM AUGUST 2002 THROUGH APRIL 2003, ADDING ANOTHER 34,358 VEHICLES TO THE ORIGINAL RECALL (24,801 VOLKSWAGEN PASSAT, 7,436 AUDI A4 AND 2,121 AUDI A6 VEHICLES).ODI ASSIGNED RECALL NO. 07V-375 TO THE AMENDED RECALL REPORT. THE MY 2004 AUDI A4 VEHICLES THAT ARE THE SUBJECT OF PE08-027 ARE NOT AFFECTED BY THE SUB-SUPPLIER ISSUE THAT PROMPTED 06V-017 AND 07V-375.PRODUCTION OF THE MY 2004 VEHICLES BEGAN FOUR MONTHS AFTER THE AMENDED PRODUCTION RANGE IDENTIFIED IN 07V-375.THE FUEL PUMP FAILURES IN THE MY 2004 VEHICLES HAVE DIFFERENT CAUSES THAN THE DEFECT IDENTIFIED IN THE PRIOR RECALL POPULATIONS AND HAVE OCCURRED AT MUCH LOWER FREQUENCIES. FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FIND BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PE08-027, VOLKSWAGEN AG (VW) STATED THAT IT BELIEVES THAT THE POSSIBLE CAUSAL OR CONTRIBUTORY FACTORS OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES COULD RESULT FROM EXCESSIVE ACCUMULATION OF FOREIGN MATERIALS IN THE FUEL FILTER.IN RARE CASES, THE FUEL FILTER COULD BECOME CLOGGED, WHICH CAN CAUSE INCREASED PRESSURE ON THE PUMP.VW INDICATED THAT ENGINE STALLS RESULTING FROM THIS CONDITION ARE RARE AND WOULD BE PRECEDED BY SYMPTOMS SUCH AS REDUCED ENGINE POWER, NOISE OR HESITATION.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA DETERMINED THAT THE RATE OF ENGINE STALL INCIDENTS RESULTING FROM FUEL PUMP FAILURE IS LOW AT APPROXIMATELY 0.2 PERCENT AFTER THREE YEARS IN SERVICE. ON JANUARY 17, 2006, VW SUBMITTED A DEFECT INFORMATION REPORT TO ODI CONCERNING A SAFETY RECALL TO ADDRESS A DEFECT IN THE FUEL PUMPS OF APPROXIMATELY 74,000 MODEL YEAR (MY) 2003 VOLKSWAGEN PASSAT (47,000), AUDI A4 (20,000) AND AUDI A6 (7,000) VEHICLES BUILT FROM SEPTEMBER 2002 THROUGH MARCH 2003 (NHTSA RECALL NO. 06V-017, VW RECALL NOS. M7 FOR PASSAT AND JL FOR AUDI A4 AND A6).ACCORDING TO VW, A SUB-SUPPLIER EXPERIENCED AN UNKNOWN CHANGE IN THE MATERIAL COMPOSITION OF THE CARBON-BRUSH SET USED IN THE ELECTRIC MOTOR IN THE FUEL PUMP, WHICH COULD LEAD TO INCREASED WEAR OF THE CARBON-BRUSH SETS, WHICH IN TURN CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE.ON JULY 23, 2007, VW EXPANDED THE SCOPE OF THE RECALL TO INCLUDE VEHICLES MANUFACTURED FROM AUGUST 2002 THROUGH APRIL 2003, ADDING ANOTHER 34,358 VEHICLES TO THE ORIGINAL RECALL (24,801 VOLKSWAGEN PASSAT, 7,436 AUDI A4 AND 2,121 AUDI A6 VEHICLES).ODI ASSIGNED RECALL NO. 07V-375 TO THE AMENDED RECALL REPORT. THE MY 2004 AUDI A4 VEHICLES THAT ARE THE SUBJECT OF PE08-027 ARE NOT AFFECTED BY THE SUB-SUPPLIER ISSUE THAT PROMPTED 06V-017 AND 07V-375.PRODUCTION OF THE MY 2004 VEHICLES BEGAN FOUR MONTHS AFTER THE AMENDED PRODUCTION RANGE IDENTIFIED IN 07V-375.THE FUEL PUMP FAILURES IN THE MY 2004 VEHICLES HAVE DIFFERENT CAUSES THAN THE DEFECT IDENTIFIED IN THE PRIOR RECALL POPULATIONS AND HAVE OCCURRED AT MUCH LOWER FREQUENCIES. FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FIND BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline:delivery
IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PE08-027, VOLKSWAGEN AG (VW) STATED THAT IT BELIEVES THAT THE POSSIBLE CAUSAL OR CONTRIBUTORY FACTORS OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES COULD RESULT FROM EXCESSIVE ACCUMULATION OF FOREIGN MATERIALS IN THE FUEL FILTER.IN RARE CASES, THE FUEL FILTER COULD BECOME CLOGGED, WHICH CAN CAUSE INCREASED PRESSURE ON THE PUMP.VW INDICATED THAT ENGINE STALLS RESULTING FROM THIS CONDITION ARE RARE AND WOULD BE PRECEDED BY SYMPTOMS SUCH AS REDUCED ENGINE POWER, NOISE OR HESITATION.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA DETERMINED THAT THE RATE OF ENGINE STALL INCIDENTS RESULTING FROM FUEL PUMP FAILURE IS LOW AT APPROXIMATELY 0.2 PERCENT AFTER THREE YEARS IN SERVICE. ON JANUARY 17, 2006, VW SUBMITTED A DEFECT INFORMATION REPORT TO ODI CONCERNING A SAFETY RECALL TO ADDRESS A DEFECT IN THE FUEL PUMPS OF APPROXIMATELY 74,000 MODEL YEAR (MY) 2003 VOLKSWAGEN PASSAT (47,000), AUDI A4 (20,000) AND AUDI A6 (7,000) VEHICLES BUILT FROM SEPTEMBER 2002 THROUGH MARCH 2003 (NHTSA RECALL NO. 06V-017, VW RECALL NOS. M7 FOR PASSAT AND JL FOR AUDI A4 AND A6).ACCORDING TO VW, A SUB-SUPPLIER EXPERIENCED AN UNKNOWN CHANGE IN THE MATERIAL COMPOSITION OF THE CARBON-BRUSH SET USED IN THE ELECTRIC MOTOR IN THE FUEL PUMP, WHICH COULD LEAD TO INCREASED WEAR OF THE CARBON-BRUSH SETS, WHICH IN TURN CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE.ON JULY 23, 2007, VW EXPANDED THE SCOPE OF THE RECALL TO INCLUDE VEHICLES MANUFACTURED FROM AUGUST 2002 THROUGH APRIL 2003, ADDING ANOTHER 34,358 VEHICLES TO THE ORIGINAL RECALL (24,801 VOLKSWAGEN PASSAT, 7,436 AUDI A4 AND 2,121 AUDI A6 VEHICLES).ODI ASSIGNED RECALL NO. 07V-375 TO THE AMENDED RECALL REPORT. THE MY 2004 AUDI A4 VEHICLES THAT ARE THE SUBJECT OF PE08-027 ARE NOT AFFECTED BY THE SUB-SUPPLIER ISSUE THAT PROMPTED 06V-017 AND 07V-375.PRODUCTION OF THE MY 2004 VEHICLES BEGAN FOUR MONTHS AFTER THE AMENDED PRODUCTION RANGE IDENTIFIED IN 07V-375.THE FUEL PUMP FAILURES IN THE MY 2004 VEHICLES HAVE DIFFERENT CAUSES THAN THE DEFECT IDENTIFIED IN THE PRIOR RECALL POPULATIONS AND HAVE OCCURRED AT MUCH LOWER FREQUENCIES. FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FIND BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
IN RESPONSE TO ODI'S INFORMATION REQUEST FOR PE08-027, VOLKSWAGEN AG (VW) STATED THAT IT BELIEVES THAT THE POSSIBLE CAUSAL OR CONTRIBUTORY FACTORS OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES COULD RESULT FROM EXCESSIVE ACCUMULATION OF FOREIGN MATERIALS IN THE FUEL FILTER.IN RARE CASES, THE FUEL FILTER COULD BECOME CLOGGED, WHICH CAN CAUSE INCREASED PRESSURE ON THE PUMP.VW INDICATED THAT ENGINE STALLS RESULTING FROM THIS CONDITION ARE RARE AND WOULD BE PRECEDED BY SYMPTOMS SUCH AS REDUCED ENGINE POWER, NOISE OR HESITATION.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA DETERMINED THAT THE RATE OF ENGINE STALL INCIDENTS RESULTING FROM FUEL PUMP FAILURE IS LOW AT APPROXIMATELY 0.2 PERCENT AFTER THREE YEARS IN SERVICE. ON JANUARY 17, 2006, VW SUBMITTED A DEFECT INFORMATION REPORT TO ODI CONCERNING A SAFETY RECALL TO ADDRESS A DEFECT IN THE FUEL PUMPS OF APPROXIMATELY 74,000 MODEL YEAR (MY) 2003 VOLKSWAGEN PASSAT (47,000), AUDI A4 (20,000) AND AUDI A6 (7,000) VEHICLES BUILT FROM SEPTEMBER 2002 THROUGH MARCH 2003 (NHTSA RECALL NO. 06V-017, VW RECALL NOS. M7 FOR PASSAT AND JL FOR AUDI A4 AND A6).ACCORDING TO VW, A SUB-SUPPLIER EXPERIENCED AN UNKNOWN CHANGE IN THE MATERIAL COMPOSITION OF THE CARBON-BRUSH SET USED IN THE ELECTRIC MOTOR IN THE FUEL PUMP, WHICH COULD LEAD TO INCREASED WEAR OF THE CARBON-BRUSH SETS, WHICH IN TURN CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE.ON JULY 23, 2007, VW EXPANDED THE SCOPE OF THE RECALL TO INCLUDE VEHICLES MANUFACTURED FROM AUGUST 2002 THROUGH APRIL 2003, ADDING ANOTHER 34,358 VEHICLES TO THE ORIGINAL RECALL (24,801 VOLKSWAGEN PASSAT, 7,436 AUDI A4 AND 2,121 AUDI A6 VEHICLES).ODI ASSIGNED RECALL NO. 07V-375 TO THE AMENDED RECALL REPORT. THE MY 2004 AUDI A4 VEHICLES THAT ARE THE SUBJECT OF PE08-027 ARE NOT AFFECTED BY THE SUB-SUPPLIER ISSUE THAT PROMPTED 06V-017 AND 07V-375.PRODUCTION OF THE MY 2004 VEHICLES BEGAN FOUR MONTHS AFTER THE AMENDED PRODUCTION RANGE IDENTIFIED IN 07V-375.THE FUEL PUMP FAILURES IN THE MY 2004 VEHICLES HAVE DIFFERENT CAUSES THAN THE DEFECT IDENTIFIED IN THE PRIOR RECALL POPULATIONS AND HAVE OCCURRED AT MUCH LOWER FREQUENCIES. FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FIND BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.