Illustration2003 AIRSTREAM 22' TRAVEL TRAILER HAD LEAKING, FLOOR DETERIORATING, AND TOOK TO A REPAIR SHOP. UPON CHECKING, ALL OUTRIGGERS HAVE FAILED AND CRACKED, FRAME IS TWISTING AT REAR DUE TO OUTRIGGER FAILURE. DID NOT REALIZED THIS UNTIL FLOOR WAS REMOVED FOR REPAIR. *TR
2003 Airstream International Ccd
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all International Ccd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
6 reportsMY '03 22' AIRSTREAM TRAILER HAS MAJOR CRACKS IN THE MAIN FRAME MAKING IT UNTOWABLE. THE AS FACTORY HAS SENT A "PATCH KIT" WHICH WILL HAS NOT WORKED. I AM ONLY ONE OF HUNDREDS WITH THE SAME OR POTENTIAL PROBLEM. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
AIRSTREAM RV TRAILER FRAME FAILURE. *TR
TL*THE CONTACT OWNS A 2003 AIRSTREAM INTERNATIONAL CCD. HE REALIZED THAT THE TABLE INSIDE OF THE VEHICLE WAS TILTED. HE DECIDED TO EXAMINE THE UNDERCARRIAGE OF THE VEHICLE AND NOTICED THAT THE SUB FRAME WAS CRACKED IN TWO PLACES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAG…
Read full complaint
TL*THE CONTACT OWNS A 2003 AIRSTREAM INTERNATIONAL CCD. HE REALIZED THAT THE TABLE INSIDE OF THE VEHICLE WAS TILTED. HE DECIDED TO EXAMINE THE UNDERCARRIAGE OF THE VEHICLE AND NOTICED THAT THE SUB FRAME WAS CRACKED IN TWO PLACES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.
'03 AIRSTREAM 22FT. INT. CCD FRAME FAILURE. MY RECENTLY PURCHASED AS TRAILER HAS MAJOR DEFECTS IN THE FRAME DESIGN. THE OUTRIGGERS HAVE SAGGED AND CRACKED THE FRAME. THE FRAME IS BUCKLED BEHIND THE REAR AXEL AND DROPPED THE ENTIRE REAREND. THE OUTRIGGERS BEHIND THE REAR AXEL HAVE CRACKED AT THE WELD. THERE ARE 83+ COMPLAINTS ON …
Read full complaint
'03 AIRSTREAM 22FT. INT. CCD FRAME FAILURE. MY RECENTLY PURCHASED AS TRAILER HAS MAJOR DEFECTS IN THE FRAME DESIGN. THE OUTRIGGERS HAVE SAGGED AND CRACKED THE FRAME. THE FRAME IS BUCKLED BEHIND THE REAR AXEL AND DROPPED THE ENTIRE REAREND. THE OUTRIGGERS BEHIND THE REAR AXEL HAVE CRACKED AT THE WELD. THERE ARE 83+ COMPLAINTS ON THE AIRSTREAM OWNERS COMMUNITY FORUM. AS HAS ADMITTED THERE IS A PROBLEM AND SENT, REPAIR KITS TO NUMEROUS OWNERS, INCLUDING ME. I KNOW OF AT LEAST ONE OWNER THAT HAD HIS FRAME REPLACED BY AS AND NOW IT'S DOING THE SAME THING. HE HAS PARKED IT AND USES IT AS AN ADDITIONAL BEDROOM. THIS PROBLEM NEEDS LOOKING INTO. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
SIDE WALL TIRE BLOW OUT ON A GOODYEAR TRAILER TIRE ST 225/75/15 MARATHON. PROPER INFLATION AND NOT OVER LOADED TIRE HAD MAYBE 6000 MILES ON IT AND WAS ONE YEAR OLD. *JB
Official recalls
103V464000 · Equipment:recreational Vehicle/trailer
Nov 12, 2003
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR AIRSTREAM AT 937-596-6111.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04051 · Wheel Separations
Opened Jul 22, 2004 · Closed Nov 23, 2004
Status: closed (inferred from source dates) · Wheels; Wheels:lugs/nuts/bolts/studs
WHEEL SEPARATIONS AT THOR INDUSRIES HAVE PREDOMINANTLY OCCURRED IN VEHICLES MANUFACTURED BY KEYSTONE RV.KEYSTONE RV HAS REPORTED 110 SEPARATIONS OF STEEL WHEELS OF 64,727(0.17%) AND 15 SEPARATIONS OF ALUMINUM WHEELS OF 6,984 PRODUCED (0.21%) IN RECREATIONAL VEHICLESMANUFACTURED SINCE MARCH 2003.OTHER DIVISIONS OF THOR INDUSTRIES, DUTCHMAN (4), THOR CALIFORNIA (0), THOR AMERICA (2), KOMFORT CORP (2), AND AIRSTREAM (14) HAVE REPORTED FEWER WHEEL SEPARATIONS OVER A BROADER TIME PERIOD (SINCE 2000) THAN KEYSTONE RV. SINCE A SIGNIFICANT MAJORITY (92%) OF THE WHEEL SEPARATIONS THAT HAVE OCCURRED IN THOR INDUSTRIES VEHICLES HAVE OCCURRED IN KEYSTONE RV VEHICLES, ODI WILL FOCUS INVESTIGATION ACTIVITY ON THESE PRODUCTS AND OPEN AN ENGINEERING ANALYSIS (EA) AT KEYSTONE RV TO INVESTIGATE THE CAUSE(S) FOR WHEEL SEPARATIONS.
Additional source detail variants (2)
Wheels
WHEEL SEPARATIONS AT THOR INDUSRIES HAVE PREDOMINANTLY OCCURRED IN VEHICLES MANUFACTURED BY KEYSTONE RV.KEYSTONE RV HAS REPORTED 110 SEPARATIONS OF STEEL WHEELS OF 64,727(0.17%) AND 15 SEPARATIONS OF ALUMINUM WHEELS OF 6,984 PRODUCED (0.21%) IN RECREATIONAL VEHICLESMANUFACTURED SINCE MARCH 2003.OTHER DIVISIONS OF THOR INDUSTRIES, DUTCHMAN (4), THOR CALIFORNIA (0), THOR AMERICA (2), KOMFORT CORP (2), AND AIRSTREAM (14) HAVE REPORTED FEWER WHEEL SEPARATIONS OVER A BROADER TIME PERIOD (SINCE 2000) THAN KEYSTONE RV. SINCE A SIGNIFICANT MAJORITY (92%) OF THE WHEEL SEPARATIONS THAT HAVE OCCURRED IN THOR INDUSTRIES VEHICLES HAVE OCCURRED IN KEYSTONE RV VEHICLES, ODI WILL FOCUS INVESTIGATION ACTIVITY ON THESE PRODUCTS AND OPEN AN ENGINEERING ANALYSIS (EA) AT KEYSTONE RV TO INVESTIGATE THE CAUSE(S) FOR WHEEL SEPARATIONS.
Wheels:lugs/nuts/bolts/studs
WHEEL SEPARATIONS AT THOR INDUSRIES HAVE PREDOMINANTLY OCCURRED IN VEHICLES MANUFACTURED BY KEYSTONE RV.KEYSTONE RV HAS REPORTED 110 SEPARATIONS OF STEEL WHEELS OF 64,727(0.17%) AND 15 SEPARATIONS OF ALUMINUM WHEELS OF 6,984 PRODUCED (0.21%) IN RECREATIONAL VEHICLESMANUFACTURED SINCE MARCH 2003.OTHER DIVISIONS OF THOR INDUSTRIES, DUTCHMAN (4), THOR CALIFORNIA (0), THOR AMERICA (2), KOMFORT CORP (2), AND AIRSTREAM (14) HAVE REPORTED FEWER WHEEL SEPARATIONS OVER A BROADER TIME PERIOD (SINCE 2000) THAN KEYSTONE RV. SINCE A SIGNIFICANT MAJORITY (92%) OF THE WHEEL SEPARATIONS THAT HAVE OCCURRED IN THOR INDUSTRIES VEHICLES HAVE OCCURRED IN KEYSTONE RV VEHICLES, ODI WILL FOCUS INVESTIGATION ACTIVITY ON THESE PRODUCTS AND OPEN AN ENGINEERING ANALYSIS (EA) AT KEYSTONE RV TO INVESTIGATE THE CAUSE(S) FOR WHEEL SEPARATIONS.