Car randomly goes into neutral and stays in neutral not allowing gear change
2015 Acura Tlx
Owner reports · Recalls · Investigations
More warning signs than most Tlx years
Owner complaints for the 2015 Acura Tlx are substantially higher than the model-year median of 65.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tlx years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
231 reports with mileage · 110 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 82 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
160 reportsThe contact owns a 2015 Acura TLX. The contact stated that while driving at undisclosed speeds, the vehicle hesitated while accelerating. The message to stop driving and have the vehicle serviced immediately was displayed. The vehicle was towed to the dealer, who diagnosed that the Automatic Transmission Fluid (ATF) warmer had f…
Read full complaint
The contact owns a 2015 Acura TLX. The contact stated that while driving at undisclosed speeds, the vehicle hesitated while accelerating. The message to stop driving and have the vehicle serviced immediately was displayed. The vehicle was towed to the dealer, who diagnosed that the Automatic Transmission Fluid (ATF) warmer had failed. The dealer diagnosed the vehicle with other undisclosed failures due to the ATF warmer failure. The vehicle was not repaired. The manufacturer was informed of the failures and opened a case. The failure mileage was approximately 77,000.
The fuel delivery system, specifically the fuel pump, has malfunctioned. This vehicle is subject to a fuel pump safety recall, which was reportedly repaired in 2022; however, the vehicle continues to experience the same failure symptoms and is available for inspection upon request. The vehicle has stalled multiple times at highw…
Read full complaint
The fuel delivery system, specifically the fuel pump, has malfunctioned. This vehicle is subject to a fuel pump safety recall, which was reportedly repaired in 2022; however, the vehicle continues to experience the same failure symptoms and is available for inspection upon request. The vehicle has stalled multiple times at highway speeds, resulting in sudden loss of power while driving and creating an immediate risk of collision with surrounding traffic. My family was in the vehicle during these incidents, significantly increasing the risk of serious injury or death. The problem has been reproduced multiple times, including after the vehicle was taken to an authorized Acura dealership. During the most recent visit, diagnostic trouble codes were cleared, but the recalled fuel pump was not repaired or replaced. After being released by the dealership, the vehicle stalled again under similar driving conditions. The vehicle was inspected by the dealership, but no corrective repair was performed beyond clearing codes. The manufacturer has not yet properly remedied the recurring safety defect. Prior to stalling, the vehicle exhibited intermittent hesitation, loss of power, and engine shutdown. Warning indicators and fault codes were present at times and were cleared by the dealership without resolving the underlying issue. These symptoms have continued intermittently since the recall repair. This appears to be a failure to properly diagnose and correct a known safety defect, resulting in repeated dangerous highway stalls and placing occupants at serious risk.
Subject: Complaint - Safety Recall Failure (#23V75100) - Engine Failure Summary: This is a complaint regarding a failure of the safety recall repair performed under Recall #23V75100, which addressed a rod bearing issue that can cause engine failure. Details: 1. On or about April 4, 2024, Southern Acura of Newport News, VA repl…
Read full complaint
Subject: Complaint - Safety Recall Failure (#23V75100) - Engine Failure Summary: This is a complaint regarding a failure of the safety recall repair performed under Recall #23V75100, which addressed a rod bearing issue that can cause engine failure. Details: 1. On or about April 4, 2024, Southern Acura of Newport News, VA replaced the long block under Recall #23V75100 after the original engine failed at approximately 130,810 miles. 2. On or about September 5, 2024, at approximately 173,722 miles, the replacement engine failed again. 3.The vehicle is currently located at Hall Acura of Virginia Beach, VA. , where the dealership has verified that the engine is seized and available for inspection. 4. The failure occurred while driving at approximately 70 mph in a construction zone, where there was no immediate shoulder or safe area to pull off. The sudden loss of power nearly caused a rear- end collision. 5.An independent service center, American Pride - Fort Eustis in Newport News, VA., also verified the problem and found metal shavings and bearing metal coming from the oil pan. 6. There were no warning lamps or alerts prior to the engine failure; all warning lights illuminated only after the loss of power
The contact's client owns a 2015 Acura TLX. The contact stated while the client was driving 65 MPH, the vehicle shut down in the middle of traffic. There were no warning lights illuminated. The contact stated that the transmission failed to shift into drive or reverse. Additionally, there was an unknown failure with the brakes a…
Read full complaint
The contact's client owns a 2015 Acura TLX. The contact stated while the client was driving 65 MPH, the vehicle shut down in the middle of traffic. There were no warning lights illuminated. The contact stated that the transmission failed to shift into drive or reverse. Additionally, there was an unknown failure with the brakes and transmission. The contact stated that the failure was related to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling). The vehicle was towed to the local dealer, where it was diagnosed and determined that the instrument cluster had failed and needed to be replaced. Additionally, the catalytic converter needed to be replaced. The contact stated that the driver suffered a stroke after the failure, and medical attention was provided. The manufacturer was contacted and opened a case. The failure mileage was approximately 67,000.
Hi, I have had a couple instances where the engine revved up between gears. Both times, I remember it happening rather soon after starting off from a stop sign. I didn't pay it much mind, but noted it. Just today, I asked my wife ([XXX]) whether she had noticed anything with the car. I purposely didn't ask any leading quest…
Read full complaint
Hi, I have had a couple instances where the engine revved up between gears. Both times, I remember it happening rather soon after starting off from a stop sign. I didn't pay it much mind, but noted it. Just today, I asked my wife ([XXX]) whether she had noticed anything with the car. I purposely didn't ask any leading questions. She said a few times it would jump instead of smoothly going to the next gear. In Seaside, OR, I started to pull out onto [XXX], planning to take a right and head south bound. There was a Southbound car approaching from the North, but I had plenty of time to pull out and get up to speed. Immediately after starting out, the car popped into neutral and the RPMs raced. I already had some momentum and was on the highway, so I couldn't brake, and because it went into neutral, I hadn't finalized my turn so I was still pointing SE. As the car quickly approached, all I could do was use what little momentum I had and continue into the Northbound lane so the oncoming car could pass. Because of the slight slope to the Northbound shoulder, I was able to slowly come to a stop. I put the car in Park, turned it off, then back on, and everything came back to normal. I cannot begin to express how scared I was. I have lost brakes before in a car, but I know to use the emergency brake. I was completely dumbfounded as to how to react. Had there been oncoming traffic, it would have been an awful accident. Why is there no recall on this? I researched on Google and found a recall on 2015 Acura TLX 6-cylinder transmission due to a bad wiring harness on their 9-Speed transmission. I know mine is an 8-speed, but would it not use the same wiring harness with slight modifications? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2015 Acura TLX. The contact stated while driving approximately 45 MPH, the vehicle failed to maintain the speed while the accelerator pedal was depressed. The contact stated that the vehicle lost automotive power. Several unknown warning lights were illuminated. The contact sustained injuries upon pre-existing…
Read full complaint
The contact owns a 2015 Acura TLX. The contact stated while driving approximately 45 MPH, the vehicle failed to maintain the speed while the accelerator pedal was depressed. The contact stated that the vehicle lost automotive power. Several unknown warning lights were illuminated. The contact sustained injuries upon pre-existing injuries from the failure and sought medical attention. The contact was able to pull onto the shoulder of the roadway. The vehicle was towed to a local dealer where it was diagnosed that the cluster had caused the catalytic converter to fail. The vehicle was repaired at the owner's expense. The contact stated that the vehicle failed to respond as needed while the accelerator pedal was depressed. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); however, there was an abnormal sound coming from the transmission. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.
I was driving on the freeway for about 5 minutes and literally out of no where my car began to make a strange noise and then my engine light came on. Following that my car shut off and I immediately lost power I pulled over as best I can and turn my hazard on eventually the car died because I couldn’t get a tow out fast enough a…
Read full complaint
I was driving on the freeway for about 5 minutes and literally out of no where my car began to make a strange noise and then my engine light came on. Following that my car shut off and I immediately lost power I pulled over as best I can and turn my hazard on eventually the car died because I couldn’t get a tow out fast enough and I’ve had it sitting at a shop ever since this incident.. tell
While driving on the freeway/highway my vehicle went into limp mode and shifted into neutral. My vehicle would not allow me to shift gears and the car would not let me accelerate anymore. I had to think quickly and move out from upcoming traffic. With little speed I had on my vehicle I could only shut down the car and wait for a…
Read full complaint
While driving on the freeway/highway my vehicle went into limp mode and shifted into neutral. My vehicle would not allow me to shift gears and the car would not let me accelerate anymore. I had to think quickly and move out from upcoming traffic. With little speed I had on my vehicle I could only shut down the car and wait for a tow truck. This happened to me twice in 2020 and the mechanics could not find any issue or replicate what had happened. They said this was a software issue. I was still scared to drive my car thinking this would happen again. Then 2 years after ( 2024) again this happened and it was when I was on the freeway. Luckily I was on the left side and was able to stop on the shoulder but stressing out and still traumatized from what occurred 2 years ago. I took it to the dealer and same thing they could not replicate the issue and did re programmed the software. I believe this car is not safe to drive at all knowing this can happen again and again at random times. The attached document is what the dealer gave me stating this remedy was done to the vehicle. This need to be investigated.
Transmission is failing after taking it in for service after noticing a chirp from 2-3 and 3-4 gear.these symptoms are described with service bulletin 17-027 .dealership claimed transmission warmer was good but replaced the seals. In Acuras own document they said the warranty would be extended to ten years.
Official recalls
623V858000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
23V751000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
19V060000 · Fuel System, Other:delivery:fuel Pump
Jan 29, 2019
Honda (American Honda Motor Co.) is recalling certain 2016-2018 Acura MDX, 2015-2019 Acura TLX and 2015-2017 Honda Accord vehicles, equipped with a 3.5L V6 engine. Particulates in fuel may adhere to the internal components of the fuel pump, reducing its performance.
Consequence & remedy
Consequence: Reduced fuel pump performance can result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will update the fuel injection engine control unit (FI-ECU) software and, if necessary, replace the fuel pump, free of charge. The recall began March 25, 2019. Owners may contact customer service at 1-888-234-2138. Acura's recall number for this recall is P3W. Honda's recall number for this recall is N3X.
16V640000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Sep 6, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura TLX 2WD and 4WD vehicles. In the affected vehicles, the transmission wire harness connections may have insufficient crimps, and, as a result, the transmission may unexpectedly shift to neutral.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Acura has notified owners, and dealers will, based on the automatic transmission serial number, update the transmission software to prevent the transmission from shifting into neutral due to a faulty crimp, free of charge. The recall began January 13, 2017. Owners may contact Acura Client Relations at 1-888-234-2138. Honda's number for this recall is KC2.
14V779000 · Power Train:automatic Transmission
Dec 8, 2014
American Honda Motor Co. (Honda) is recalling certain model year 2015 Acura TLX V6 2WD vehicles manufactured July 14, 2014, to November 12, 2014, and certain 2015 TLX V6 SH-AWD vehicles manufactured August 26, 2014, to November 10, 2014. The automatic transmission parking pawl may become contaminated or the park rod may become dislodged or broken. This may prevent the transmission from shifting into the Park position.
Consequence & remedy
Consequence: If the shift indicator displays "Park" but the park lock does not engage, the vehicle may roll away increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will inspect and replace the transmission if necessary, free of charge. The recall began January 30, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JM8.
14V613000 · Equipment:other:labels
Oct 1, 2014
American Honda Motor Co. (Honda) is recalling certain model year 2015 Acura TLX AWD vehicles manufactured August 26, 2014, to September 20, 2014. The affected vehicles may have incorrect values for the Gross Vehicle Weight Rating (GVWR) and Gross Axle Weight Rating (GAWR) front and rear printed on the safety certification label. As such, the vehicles do not conform to Part 567, "Certification."
Consequence & remedy
Consequence: If the vehicle is loaded to the specifications listed on the label, tire failure may result, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will install a corrected certification label, free of charge. The recall is expected to begin on October 21, 2014. Owners may contact Honda customer service at 1-800-382-2238. Honda's number for this recall is JK6.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
Illustration