NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
341 reportsMileage unknown · Aug 22, 2026
Unknown Or Other
As I’m driving my car will shift in neutral which I know this isn’t normal on highway, bridges even low grounds. Don’t see a recall on my car, but after researching I seen In September 2019 tlx was having some of the same problems different year. And this situation happen 3x so far til I afraid to drive it. Just driving smoothly…
Read full complaint
As I’m driving my car will shift in neutral which I know this isn’t normal on highway, bridges even low grounds. Don’t see a recall on my car, but after researching I seen In September 2019 tlx was having some of the same problems different year. And this situation happen 3x so far til I afraid to drive it. Just driving smoothly then goes into different gear which can put me, my kids and anyone else in danger.
NHTSA ODI #11758677
Mileage unknown · Jul 10, 2026
StructureUnknown Or Other
The vehicle is experiencing extensive factory paint failure and clear-coat delamination on the roof, around the rear windshield, C-pillars, and upper door frames. The condition began approximately 12 months ago around the rear windshield and has progressively spread to multiple upper body panels despite normal ownership and main…
Read full complaint
The vehicle is experiencing extensive factory paint failure and clear-coat delamination on the roof, around the rear windshield, C-pillars, and upper door frames. The condition began approximately 12 months ago around the rear windshield and has progressively spread to multiple upper body panels despite normal ownership and maintenance. The paint is peeling in large sections, exposing the underlying paint layers. Research indicates Acura previously acknowledged a similar paint adhesion defect affecting certain 2015 Acura TLX vehicles around the rear windshield and issued a warranty extension for some vehicles. Although my vehicle may not have been included in that program, the failure pattern appears substantially similar. The vehicle has not been involved in any collision affecting these areas, and the paint appears to be the original factory finish. The condition continues to worsen over time. The vehicle is available for inspection upon request. Acura Client Relations has been contacted, and a case has been opened requesting inspection and review.
NHTSA ODI #11749669
Mileage unknown · Jun 15, 2026
Power Train
Car randomly goes into neutral and stays in neutral not allowing gear change
NHTSA ODI #11744119
89,000 miles · May 14, 2026
Fuel System, Gasoline
The contact owns a 2015 Acura TLX. The contact stated that while driving at various speeds the vehicle had suddenly began to shake and rattle and eventually stalled. The contact able to restart the vehicle and continued to drive. Over time the failure continued to occur more frequently. The vehicle was taken to the local dealer …
Read full complaint
The contact owns a 2015 Acura TLX. The contact stated that while driving at various speeds the vehicle had suddenly began to shake and rattle and eventually stalled. The contact able to restart the vehicle and continued to drive. Over time the failure continued to occur more frequently. The vehicle was taken to the local dealer who diagnosed the fuel pump needed to be replaced. The vehicle was later repair by a local mechanic. The manufacturer was contact regarding the failure and informed that the VIN was not included in the NHTSA Campaign Number: 23V858000(FUEL SYSTEM, GASOLINE). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 89,000.
NHTSA ODI #11737765
Mileage unknown · Apr 23, 2026
Electrical SystemEngineLane Departure
The emergency brake system continues to come on and read all the type of stuff on the screen, as well as the LKAS keeps coming on the screen showing problems and when it does, the transmission or engines stalls a little and slows up and speed down on its on
NHTSA ODI #11733172
50,000 miles · Apr 1, 2026
Back Over PreventionVisibility
The contact owns a 2015 Acura TLX. The contact stated that the rear-view camera displayed a distorted image while the vehicle was in reverse(R). The failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The contact stated that the image was being blocked. Additionally, the rear…
Read full complaint
The contact owns a 2015 Acura TLX. The contact stated that the rear-view camera displayed a distorted image while the vehicle was in reverse(R). The failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The contact stated that the image was being blocked. Additionally, the rear-view mirror had dark sunspots that obstructed the driver's visibility. Most recently, the contact became aware that the driver’s seat was fractured where the seat adjust buttons were located. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 50,000.
NHTSA ODI #11728647
Mileage unknown · Mar 17, 2026
EngineFuel/propulsion SystemUnknown Or Other
Vehicle displays two warnings under normal usage. First warning is Emissions system issue and second is Brake System Failure. The Vehicle runs completely normal and operational, however these two warnings flash on the vehicle. The parking brake indicator also flashes. Vehicle has been to dealership/shop for multiple repairs; aro…
Read full complaint
Vehicle displays two warnings under normal usage. First warning is Emissions system issue and second is Brake System Failure. The Vehicle runs completely normal and operational, however these two warnings flash on the vehicle. The parking brake indicator also flashes. Vehicle has been to dealership/shop for multiple repairs; around 3-4 repairs within two months with no resolve for the same warning/issue.
NHTSA ODI #11724835
Mileage unknown · Mar 2, 2026
Forward Collision AvoidanceLane DepartureSteering
The vehicle is throwing a steering code of LSAK. The steering is being compromised as the vehicle cannot determine if it is being steered correctly or not. After researching this code, I have seen hundreds of other people so far complaining about the same code for this year, make and model. One person had stated that his stee…
Read full complaint
The vehicle is throwing a steering code of LSAK. The steering is being compromised as the vehicle cannot determine if it is being steered correctly or not. After researching this code, I have seen hundreds of other people so far complaining about the same code for this year, make and model. One person had stated that his steering stopped mid way on his drive. I looked up the prices of correcting this issue and it ranges anywhere form 1800.00 to 2000 .00. My vehicle only has 65,000 miles on it and this is a potentially very dangerous situation. With the hundreds of customers that I have seen so far that are complaining of the same issue, I do not feel that this should be the customers responsibility to fix but rather a recall or at the very least a class action lawsuit if the dealer will not correct this potentially very dangerous issue.
NHTSA ODI #11721414
99,000 miles · Jan 6, 2026
Engine And Engine Cooling
The contact owns a 2015 Acura TLX. The contact received notification of NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling). The dealer was contacted several times for the recall repair; however, the dealer informed the contact that the part to do the recall repair was not yet available. The contact stated while driving…
Read full complaint
The contact owns a 2015 Acura TLX. The contact received notification of NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling). The dealer was contacted several times for the recall repair; however, the dealer informed the contact that the part to do the recall repair was not yet available. The contact stated while driving 45-50 MPH, the vehicle lost motive power. The contact was able to veer to the shoulder of the road. The vehicle failed to restart and was towed to Firestone, where it was diagnosed and determined that the engine had seized. The vehicle was not repaired and was towed to the residence. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 99,000.
NHTSA ODI #11709143
77,000 miles · Jan 5, 2026
Power Train
The contact owns a 2015 Acura TLX. The contact stated that while driving at undisclosed speeds, the vehicle hesitated while accelerating. The message to stop driving and have the vehicle serviced immediately was displayed. The vehicle was towed to the dealer, who diagnosed that the Automatic Transmission Fluid (ATF) warmer had f…
Read full complaint
The contact owns a 2015 Acura TLX. The contact stated that while driving at undisclosed speeds, the vehicle hesitated while accelerating. The message to stop driving and have the vehicle serviced immediately was displayed. The vehicle was towed to the dealer, who diagnosed that the Automatic Transmission Fluid (ATF) warmer had failed. The dealer diagnosed the vehicle with other undisclosed failures due to the ATF warmer failure. The vehicle was not repaired. The manufacturer was informed of the failures and opened a case. The failure mileage was approximately 77,000.
NHTSA ODI #11708770
Official recalls
6Dec 18, 2023
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Nov 13, 2023
Honda (American Honda Motor Co.) is recalling certain 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2016 and 2018-2019 Pilot, 2017 and 2019 Ridgeline, and 2018-2019 Odyssey vehicles. Due to a manufacturing error, the connecting rod bearing in the engine may wear and seize, damaging the engine.
Consequence & remedy
Consequence: A damaged engine may run improperly or stall while driving, increasing the risk of a fire, crash, or injury.
Remedy: Dealers will inspect and repair, or replace the engine as necessary, free of charge. Owner letters were mailed March 28, 2024. 2016-2017 Acura MDX owner letters were mailed November 1, 2024. 2016-2020 Acura MDX owner letters are expected to be mailed in mid-December 2024. Honda began mailing owner notification letters as of March 18, 2024. 2015-2016 Acura owner letters are expected to be mailed mid-December 2024, 2018 Acura TLX owner letters are expected to be mailed the end of March/early April 2024, 2019 Acura TLX owner letters are expected to be mailed mid-May 2024, 2020 Acura TLX owner letters are expected to be mailed mid-June 2024, and 2016-2020 Acura MDX owner letters are expected to be mailed January 27, 2025. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XG1 and GG0.
Jan 29, 2019
Honda (American Honda Motor Co.) is recalling certain 2016-2018 Acura MDX, 2015-2019 Acura TLX and 2015-2017 Honda Accord vehicles, equipped with a 3.5L V6 engine. Particulates in fuel may adhere to the internal components of the fuel pump, reducing its performance.
Consequence & remedy
Consequence: Reduced fuel pump performance can result in an engine stall, increasing the risk of crash.
Remedy: Honda will notify owners, and dealers will update the fuel injection engine control unit (FI-ECU) software and, if necessary, replace the fuel pump, free of charge. The recall began March 25, 2019. Owners may contact customer service at 1-888-234-2138. Acura's recall number for this recall is P3W. Honda's recall number for this recall is N3X.
Sep 6, 2016
Honda (American Honda Motor Co.) is recalling certain model year 2015 Acura TLX 2WD and 4WD vehicles. In the affected vehicles, the transmission wire harness connections may have insufficient crimps, and, as a result, the transmission may unexpectedly shift to neutral.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Acura has notified owners, and dealers will, based on the automatic transmission serial number, update the transmission software to prevent the transmission from shifting into neutral due to a faulty crimp, free of charge. The recall began January 13, 2017. Owners may contact Acura Client Relations at 1-888-234-2138. Honda's number for this recall is KC2.
Dec 8, 2014
American Honda Motor Co. (Honda) is recalling certain model year 2015 Acura TLX V6 2WD vehicles manufactured July 14, 2014, to November 12, 2014, and certain 2015 TLX V6 SH-AWD vehicles manufactured August 26, 2014, to November 10, 2014. The automatic transmission parking pawl may become contaminated or the park rod may become dislodged or broken. This may prevent the transmission from shifting into the Park position.
Consequence & remedy
Consequence: If the shift indicator displays "Park" but the park lock does not engage, the vehicle may roll away increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will inspect and replace the transmission if necessary, free of charge. The recall began January 30, 2015. Owners may contact Honda customer service at 1-310-783-2000. Honda's number for this recall is JM8.
Oct 1, 2014
American Honda Motor Co. (Honda) is recalling certain model year 2015 Acura TLX AWD vehicles manufactured August 26, 2014, to September 20, 2014. The affected vehicles may have incorrect values for the Gross Vehicle Weight Rating (GVWR) and Gross Axle Weight Rating (GAWR) front and rear printed on the safety certification label. As such, the vehicles do not conform to Part 567, "Certification."
Consequence & remedy
Consequence: If the vehicle is loaded to the specifications listed on the label, tire failure may result, increasing the risk of a crash.
Remedy: Honda will notify owners, and dealers will install a corrected certification label, free of charge. The recall is expected to begin on October 21, 2014. Owners may contact Honda customer service at 1-800-382-2238. Honda's number for this recall is JK6.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA25004 · No Restart After Auto Start/stop Engages
Opened Mar 26, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:crank/camshaft Position Sensor; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine
On June 3, 2022, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE22005 after the agency received VOQs and several field reports concerning the Auto Idle Stop (AIS) feature on 2016-2019MY Honda Pilot vehicles. The complaints allege that the engine fails to restart on its own from a complete stop at a traffic light or road intersection with the AIS function engaged. The subject vehicles are equipped with a 3.5L engine with a 9-speed automatic transmission. On January 6, 2023, Honda released service bulletins 23-008 and 23-009. These service bulletins address the failure to restart issue in the 2016-2019MY Honda Pilot vehicles, as well as the 2015-2020 Acura TLX, 2016-2020 Acura MDX, 2019-2022 Honda Passport, and 2020-2023 Honda Ridgeline vehicles. The repair outlined in the service bulletins is a two-stage countermeasure to remedy the issue. The first stage is a Programmed Fuel Injection (“PGM-FI”) software update. The second stage is only deployed if the software update fails to remedy the issue. The second stage, depending on the model and model year, consists of replacement of the starter assembly, starter relays, and a valve adjustment. Additionally, Honda extended the warranty coverage to 10 years with unlimited mileage for vehicles requiring the second stage component replacement. ODI continues to receive complaints of the AIS failure to restart, with many complainants alleging the campaign countermeasures had been completed.NHTSA has reviewed Honda's Information Request Letter responses involving warranty claims, lawsuits, and consumer complaints in addition to ODI's own data. This Engineering Analysis is being opened to further consider the potential safety defect, including gathering additional data regarding Honda’s service campaign efficacy. ODI is additionally expanding the scope to encompass all vehicles addressed in Honda’s service bulletins 23-008 and 23-009 as well as newer model year vehicles, which are substantially similar to the vehicles covered by the service campaign. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA19001 · Electrical Overstress
Opened Apr 19, 2019 · Closed Sep 19, 2024
Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module
The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.
Illustration