IllustrationTHE CONSUMER STATED THAT YAMAHA ISSUED A SAFETY RECALL FOR THE FRAME. THE DEALER STATED THAT THEY DON'T KNOW WHEN THE PARTS WOULD BE AVAILABLE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
2002 Yamaha Road Star
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Road Star years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
025–50K
150–75K
075–100K
0100–150K
0150K+
36 reports with mileage · 51 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 82 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
87 reportsWITHOUT USE OF THE MOTORCYCLE DUE TO THE LENGTH OF TIME IT WOULD TAKE THE DEALERSHIPS TO GET THE REPAIR KITS TO PERFORM THE TRANSMISSION COMPONET RECALL. *PH *JB
CONSUMER RECEIVED A RECALL NOTICE FOR REPLACEMENT OF THE TRANSMISSION. NO PARTS WERE AVAILABLE.*AK
NHTSA RECALL 03V30900 CONCERNING TRANSMISSION FAILURE. CONSUMER CONTACTED THE DEALERSHIP ON FEBRUARY 11, 2004, AND WAS TOLD BY THE DEALER THAT PARTS WERE NOT AVAILABLE, AND HE HAD NO PROJECTED DATE AS TO WHEN PARTS WOULD BE AVAILABLE. ALSO, DEALER INFORMED THE CONSUMER THAT IF HE DID NOT PURCHASE THE MOTORCYCLE FROM THIS DEAL…
Read full complaint
NHTSA RECALL 03V30900 CONCERNING TRANSMISSION FAILURE. CONSUMER CONTACTED THE DEALERSHIP ON FEBRUARY 11, 2004, AND WAS TOLD BY THE DEALER THAT PARTS WERE NOT AVAILABLE, AND HE HAD NO PROJECTED DATE AS TO WHEN PARTS WOULD BE AVAILABLE. ALSO, DEALER INFORMED THE CONSUMER THAT IF HE DID NOT PURCHASE THE MOTORCYCLE FROM THIS DEALER HE WILL NOT SERVICE HIM ONCE THE PARTS DO COME IN. *AK *JB
I RECEIVED A RECALL LETTER FROM YAMAHA CORPORATION SINCE JANUARY 9,2004 REGARDING TRANSMISSION FAILURES. IT IS MARCH 19TH AND STILL HAVE NOT BEEN ABLE TO TAKE MY MOTORCYCLE INTO A DEALERSHIP AND ALL DEALERSHIPS I HAVE CONTACTED DO NOT KNOW WHEN THEY WILL HAVE THE PARTS TO FIX THE TRANSMISSION. ALSO THE DEALERSHIP THAT I BOUGHT…
Read full complaint
I RECEIVED A RECALL LETTER FROM YAMAHA CORPORATION SINCE JANUARY 9,2004 REGARDING TRANSMISSION FAILURES. IT IS MARCH 19TH AND STILL HAVE NOT BEEN ABLE TO TAKE MY MOTORCYCLE INTO A DEALERSHIP AND ALL DEALERSHIPS I HAVE CONTACTED DO NOT KNOW WHEN THEY WILL HAVE THE PARTS TO FIX THE TRANSMISSION. ALSO THE DEALERSHIP THAT I BOUGHT MY MOTORCYCLE FROM IS GOING TO FIX THEIR MOTORCYCLES BEFORE THEY FIX CUSTOMERS MOTORCYCLES, I HAVE NOT BEEN ABLE TO USE MY MOTORCYCLE FOR WORK AND IS CAUSING SOME HARDSHIP FOR ME AND MY FAMILY, I HOPE THERE IS SOMETHING THAT CAN BE DONE TO HELP EXPEDITE THIS ISSUE. THANK YOU.*AK
CONSUMER RECEIVED NHTSA RECALL 03V309000 CONCERNING TRANSMISSION FAILURE IN JANUARY 2004. CONSUMER WAS TOLD BY THE DEALER THAT PARTS WERE SLOW COMING IN, AND THAT IT COULD BE SEVERAL MONTHS BEFORE MOTORCYCLE COULD BE REPAIRED. *AK
CONSUMER RECEIVED A RECALL NOTICE CONCERNING TRANSMISSION FAILURE. NO PARTS WERE AVAILABLE.*AK
NHTSA RECALL 03V309000 CONCERNING TRANSMISSION FAILURE. CONSUMER CONTACTED THE DEALER, AND WAS TOLD THAT THE PARTS NEEDED TO SERVICE MOTORCYCLE WERE NOT AVAILABLE, AND THAT THERE WAS NO PROJECTED DATE AS TO WHEN THEY WOULD BE AVAILABLE. *AK *JB
CONSUMER RECEIVED NHTSA RECALL 03V309000 CONCERNING TRANSMISSION FAILURE. CONSUMER CONTACTED DEALER, AND WAS TOLD THAT THE PARTS NEEDED TO REPAIR MOTORCYCLE WOULD NOT BE AVAILABLE FOR SEVERAL MONTHS. *AK
CONSUMER RECEIVED RECALL NOTICE FOR TRANSMISSION FAILURE. NO PARTS WERE AVAILABLE. *AK
Official recalls
103V309000 · Power Train:manual Transmission
Aug 26, 2003
IN THE TRANSMISSION ON CERTAIN MOTORCYCLES, THE SECOND/THIRD PINION GEAR MAY BE INCORRECTLY MACHINED WHICH COULD CAUSE ABNORMAL WEAR THAT EVENTUALLY RESULTS IN A BROKEN RETAINER CIRCLIP.
Consequence & remedy
Consequence: IF THE CIRCLIP BREAKS, THE TRANSMISSION COULD LOCK UP, WHICH WOULD ALSO CAUSE THE REAR WHEEL TO LOCK UP. THIS COULD RESULT IN LOSS OF CONTROL AND A CRASH, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.
Remedy: YAMAHA WILL REPLACE THE TRANSMISSION GEARS AND SHAFTS WITH NEW ONES. OWNER NOTIFICATION BEGAN ON SEPTEMBER 9, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT YAMAHA AT 1-800-88-YAMAHA OR VISIT THEIR WEBSITE AT WWW.YAMAHA-MOTOR.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE03038 · Unintended Rear Wheel Lockup
Opened Aug 11, 2003 · Closed Nov 6, 2003
Status: closed (inferred from source dates) · Power Train:manual Transmission
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
Additional source detail variants (2)
Power Train:manual Transmission
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
Power Train:manual Transmission
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