Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports1 injury reports
What owners actually said
18 reports
15,000 miles · Jul 8, 2003
Power Train
YAMAHA ROADSTAR MOTORCYCLE 2000, BUILT BEFORE MARCH OF 2000. SPRING INSIDE TRANSMISSION BROKE, CAUSING LOSS OF SHIFT CAPABILITY. BREAK OCCURRED WHILE STOPPED AT A LIGHT, SO SPRING PARTS DID NOT INTERFERE WITH FORWARD MOVEMENT THAT MIGHT HAVE BEEN CAUSED IF PIECE OF SPRING HAD LODGED BETWEEN GEAR TEETH. SPRING REPLACED UNDER WA…
Read full complaint
YAMAHA ROADSTAR MOTORCYCLE 2000, BUILT BEFORE MARCH OF 2000. SPRING INSIDE TRANSMISSION BROKE, CAUSING LOSS OF SHIFT CAPABILITY. BREAK OCCURRED WHILE STOPPED AT A LIGHT, SO SPRING PARTS DID NOT INTERFERE WITH FORWARD MOVEMENT THAT MIGHT HAVE BEEN CAUSED IF PIECE OF SPRING HAD LODGED BETWEEN GEAR TEETH. SPRING REPLACED UNDER WARRANTY, HOWEVER OCCASIONAL HARD SHIFTS OCCUR.*AK
NHTSA ODI #10025663
Mileage unknown · Jul 8, 2003
Power Train
I AM CONCERNED FOR MY OWN AND MY FAMILY MEMBERS SAFETY DUE TO REPORTED TRANSMISSION FAILURES ON YAMAHA ROAD STAR MOTORCYCLES. THESE FAILURES HAVE TAKEN PLACE AT HIGHWAY SPEEDS WITH NO ADVANCE WARNINGS. THE TRANSMISSION "LOCKS UP" THEREBY LOCKING THE REAR WHEEL.*AK
NHTSA ODI #10025655
Mileage unknown · Jun 24, 2003
Engine And Engine Cooling
MY MOTORCYCLE, 2000 YAMAHA ROADSTAR, VIN. NO. [XXX], HAS NOT BEEN OPERATED IN MORE THAN A YEAR. I BROUGHT IT IN FOR ALL SERVICE TO PUT IT BACK ON ROAD, INCLUDING SERVICE UNDER RECALL 01V094000. DEALER INFORMED ME THAT MUFFLER BRACKET ONLY NEEDS TO BE INSPECTED. RECALL NOTICE STATES THAT REPLACEMENT IS REQUIRED. MANUFACTURER…
Read full complaint
MY MOTORCYCLE, 2000 YAMAHA ROADSTAR, VIN. NO. [XXX], HAS NOT BEEN OPERATED IN MORE THAN A YEAR. I BROUGHT IT IN FOR ALL SERVICE TO PUT IT BACK ON ROAD, INCLUDING SERVICE UNDER RECALL 01V094000. DEALER INFORMED ME THAT MUFFLER BRACKET ONLY NEEDS TO BE INSPECTED. RECALL NOTICE STATES THAT REPLACEMENT IS REQUIRED. MANUFACTURER'S CUSTOMER SERVICE LINE CONTINUALLY RINGS BUSY 800.962.7962. CAN SOMEONE PLEASE GIVE ME AN ANSWER AS TO WHAT, IF ANYTHING, NEEDS TO BE DONE? *JB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10023693
20,260 miles · May 1, 2003
Engine And Engine Cooling
OIL PUMP DRIVE GEAR FAILURE LED TO 3 COLLAPSED LIFTERS AND SUBSIQUENT ENGINE FAILURE.
NHTSA ODI #10016853
Mileage unknown · Aug 5, 2002
Engine And Engine Cooling
I HAVE HEARD OF 9 OTHER OIL PUMP FAILURES ON THE ROAD STAR. *AK
NHTSA ODI #765199
Mileage unknown · Apr 15, 2002
Structure
REAR FENDER CRACKS ON THIS MODEL BEHIND THE FENDER SUPPORT. IF THIS CONDITION GOES UNNOTICED BY THE DRIVER THE FENDER MAY BUCKLE AND FALL TO CONTACT THE REAR TIRE CAUSING A LOSS OF CONTROL OF THE MOTORCYCLE. CONTACT HAS BEEN MADE WITH THE MANUFACTURER AND THEY DENY THAT THIS IS A COMMON PROBLEM IN SPITE OF AN ESTIMATED 30% OF …
Read full complaint
REAR FENDER CRACKS ON THIS MODEL BEHIND THE FENDER SUPPORT. IF THIS CONDITION GOES UNNOTICED BY THE DRIVER THE FENDER MAY BUCKLE AND FALL TO CONTACT THE REAR TIRE CAUSING A LOSS OF CONTROL OF THE MOTORCYCLE. CONTACT HAS BEEN MADE WITH THE MANUFACTURER AND THEY DENY THAT THIS IS A COMMON PROBLEM IN SPITE OF AN ESTIMATED 30% OF ALL OWNERS COMPLAINING OF EXPERIENCING THIS PROBLEM.*AK
NHTSA ODI #760736
Mileage unknown · Mar 26, 2001
Tires
FRONT TIRE WAS PLACED ON MOTOR CYCLE BACKWARDS. ARROW INDICATED DIRECTION TIRE SHOULD BE. TIRE HAD A KNOT IN IT. STEERING WOULD SHAKE. TOOK TO DEALERSHIP, AND WAS INFORMED BY MECHANIC IT WAS A MANUFACTURER'S DEFECT.*AK
NHTSA ODI #884212
Mileage unknown · Feb 26, 2001
Structure
CONSUMER NOTICED A CRACK IN THE REAR FENDER, THE DEALER ORDERED A NEW FENDER WHICH WAS SUPPOSED TO ARRIVE IN ONE WEEK BUT IT HAS BEEN 5 WEEKS AND THE FENDER HAS NOT ARRIVED YET. NLM
ON CERTAIN MOTORCYCLES, CERTAIN TRANSMISSION COMPONENTS MAY NOT MEET YAMAHA QUALITY-CONTROL STANDARDS, WHICH COULD ALLOW ABNORMAL WEAR THAT EVENTUALLY RESULTS IN A BROKEN RETAINING CIRCLIP.
Consequence & remedy
Consequence: IF THE CIRCLIP BREAKS, THE TRANSMISSION COULD LOCK UP, WHICH WOULD ALSO CAUSE THE REAR WHEEL TO LOCK UP. THIS COULD RESULT IN LOSS OF CONTROL AND A CRASH WITH INJURY OR DEATH.
Remedy: DEALERS WILL REPLACE CERTAIN TRANSMISSION COMPONENTS WITH NEW ONES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT YAMAHA AT 1-800-88-YAMAHA OR VISIT THEIR WEBSITE AT WWW.YAMAHA-MOTOR.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE03038 · Unintended Rear Wheel Lockup
Opened Aug 11, 2003 · Closed Nov 6, 2003
Status: closed (inferred from source dates) · Power Train:manual Transmission
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
Additional source detail variants (2)
Power Train:manual Transmission
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
Power Train:manual Transmission
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
2000 Yamaha Road Star Problems, Complaints & Recalls | Skip That Year
Illustration