2006 Yamaha FJR1300A

MY MOTORCYCLE IS A 2006 YAMAHA FJR1300A WITH 19924 MILES AT THE TIME THE IGNITION SWITCH FAILED IN ENTERPRISE NEVADA. I TRIED TO START THE BIKE AND NO POWER. FUSES ALL GOOD. NO PRIOR INDICATION OF FAILURE. BY PUTTING THE KEY BETWEEN 'OFF' AND 'ON' I SOMETIMES GOT POWER AND THE BIKE WOULD START. I HAD NO CELL SERVICE. NEAREST NEXT STORE/HELP WAS 92 MILES. NO TOW SERVICE AVAILABLE. FEARFUL THE BIKE WOULD HAVE SUDDENLY QUIT IF THE KEY WAS JIGGLED BY A ROAD BUMP PRIOR TO OR AFTER MY TEMPORARY REPAIR. I DUCT TAPED THE KEY IN POSITION TO MINIMIZE THE CHANCE OF CRASH OR INJURY. *TR

THE IGNITION ON MY 2006 YAMAHA FJR1300 KEEPS FAILING WHEN I TRY TO START IT. I HAVE TAKEN IT TO A DEALERSHIP WHO STATED THAT THE BATTERY POSTS WERE LOOSE. AFTER GETTING IT BACK THE SAME PROBLEM KEEPS OCCURRING. WHEN I TURN THE KEY THE GAUGES SWEEP AND THERE IS A BRIEF MOMENT WHERE THE GAUGES LIGHT UP THEN IT ALL GOES DEAD. I CAN MOVE THE WIRES AND WIGGLE THE KEY TO GET IT STARTED BUT IF I MOVE EITHER OF THOSE AFTER I START THE BIKE IT DIES. THIS IS AN ONGOING PROBLEM. *TR

2006 YAMAHA FJR1300 MOTORCYCLE. SUDDEN COMPLETE SHUT DOWN OF ELECTRICAL SYSTEM. PROBLEM CAUSED BY WIRES DETACHING FROM IGNITION SWITCH. WIRES TOO TIGHT FROM FACTORY AND WERE COLD SOLDERED WITH VERY WEAK CONNECTION. CAN YOU IMAGINE POWERING UP TO OVERTAKE A VEHICLE AND YOU HAVE A SUDDEN WITHOUT WARNING COMPLETE LOSS OF POWER,A VERY DANGEROUS SENARIO

IGNITION SWITCH FAILURE ON 2006 YAMAHA MOTORCYCLE MODEL NUMBER FJR 1300A RESULTED IN SUDDEN LOSS OF POWER IN A CORNER AND STRANDED IN DEATH VALLEY, NEVADA. FOUR WIRES ENTER THE SWITCH HOUSING. ONE OF THE TWO LARGE WIRES PULLED COMPLETELY OUT OF THE SWITCH, WITH THE BRASS SWITCH CONTACT STILL SOLDERED/CRIMPED ON THE END. THIS FAILURE *APPEARS* TO BE THE RESULT OF THE WIRING HARNESS BEING STRETCHED TOO TIGHT DURING THE ASSEMBLY PROCESS. THE WIRES GOING INTO THE SWITCH HAVE NO SLACK, THEY ARE 'BANJO STRING TIGHT'.

TURNING THE IGNITION KEY FAILED TO TURN ON THE POWER. UNABLE TO START MOTORCYCLE. DUE TO LOCATION AT TIME OF FAILURE (NO CELL OR PUBLIC PHONE READILY AVAILABLE) ALMOST HAD TO LEAVE MOTORCYCLE IN THIS REMOTE LOCATION. WAS ABLE TO 'JIGGLE' THE KEY AND FINALLY GET POWER TO START. CONTINUED TO HOTEL WHERE UPON MORNING, NO AMOUNT OF 'JIGGLING' WOULD TURN ON POWER TO START. WAS SUGGESTED TO 'TRY' BRAKE CLEANER IN THE IGNITION SWITCH TO CLEAN THE CONTACTS, BUT SWITCH WOULD STILL NOT FUNCTION, AND TO RENT U- HAUL TRUCK TO RETURN MOTORCYCLE TO HOME LOCATION. 22 HOURS LATER UPON RETURNING HOME, IGNITION SWITCH INTERMITTENTLY WOULD TURN THE POWER ON. DUE THE INTERMITTENT NATURE DEALER REPLACED THE SWITCH. STILL AWAITING PARTS AND DETERMINATION OF WHO WAS PAYING THE BILL. *AK