NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
39 reportsClear category filter16,300 miles · Sep 5, 2008
Electrical System
I WENT TO START MY MOTORCYCLE IN THE GARAGE AND IT HAD NO POWER. I AM AN ASE CERTIFIED MASTER TECHNICIAN. I TRACED THE PROBLEM TO A FAILURE OF THE IGNITION SWITCH. I DISASSEMBLED THE SWITCH AND FOUND THAT THE SOLDER JOINT ON ONE OF THE POWER WIRES HAD MELTED, AND THERE WAS HEAT DAMAGE TO THE CONTACTS INSIDE THE SWITCH. I RE-SOLD…
Read full complaint
I WENT TO START MY MOTORCYCLE IN THE GARAGE AND IT HAD NO POWER. I AM AN ASE CERTIFIED MASTER TECHNICIAN. I TRACED THE PROBLEM TO A FAILURE OF THE IGNITION SWITCH. I DISASSEMBLED THE SWITCH AND FOUND THAT THE SOLDER JOINT ON ONE OF THE POWER WIRES HAD MELTED, AND THERE WAS HEAT DAMAGE TO THE CONTACTS INSIDE THE SWITCH. I RE-SOLDERED THE WIRES, CLEANED THE CONTACTS, AND REASSEMBLED THE SWITCH. I AM STILL USING THIS SWITCH, BUT I SUSPECT IT MAY FAIL AGAIN DUE TO THE NUMBER OF OTHER FAILURES THAT HAVE BEEN OCCURRING LATELY, AS LISTED ON FJRFORUM.COM. *TR
NHTSA ODI #10241126
11,801 miles · Aug 31, 2008
Electrical System
2006 YAMAHA FJR1300 MOTORCYCLE. 11300 MILES ON IT. TRAVELING ON ROAD AT 50 MPH. ABRUPTLY THERE WAS A TOTAL SHUT DOWN OF MOTOR AND ELECTRICS. THIS IS A WELL KNOWN AND DOCUMENTED FAILURE PUBLISHED ON THE FJR FORUM. THE SOLDER JOINT HOLDING THE BROWN IGNITION WIRE TO THE BOARD IN THE SWITCH COMES FREE AND IT IS SAME AS TURNING T…
Read full complaint
2006 YAMAHA FJR1300 MOTORCYCLE. 11300 MILES ON IT. TRAVELING ON ROAD AT 50 MPH. ABRUPTLY THERE WAS A TOTAL SHUT DOWN OF MOTOR AND ELECTRICS. THIS IS A WELL KNOWN AND DOCUMENTED FAILURE PUBLISHED ON THE FJR FORUM. THE SOLDER JOINT HOLDING THE BROWN IGNITION WIRE TO THE BOARD IN THE SWITCH COMES FREE AND IT IS SAME AS TURNING THE SWITCH OFF. THIS WOULD BE AND MAYBE HAS BEEN A DEADLY SITUATION IF IT WERE TO HAPPEN IN TRAFFIC. WITH THE SURPRISE WHEN IT HAPPENS AND THE DEAD MOTOR CAUSING THE BIKE TO SLOW VERY QUICKLY COULD CAUSE A REAR END COLLISION. ON A MOTORCYCLE THAT ANT GOOD. A FACTORY RECALL IS URGENTLY NEEDED TO REPLACE THESE SWITCHES WITH A UPDATED ONE. A NEW SWITCH WILL BE ORDERED BY DEALER BUT WILL IT DO THE SAME THING? WILL I BE THIS LUCKY AGAIN? *TR
NHTSA ODI #10240500
16,757 miles · Aug 15, 2008
Electrical System
06 YAMAHA FJR 1300 IGNITION FAILURE, WHILE PARKED,NO ACCIDENT . THEN BIKE STARTED. HAS REPEATED FAILURE SEVERAL TIMES OVER LAST FEW DAYS.. BIKE IN YAMAHA SHOP NOW BEING CHECKED. BIKE HAS APPOX.16,800 MILES ON IT. *TR
NHTSA ODI #10238431
43,000 miles · Aug 14, 2008
Electrical System
2006 YAMAHA FJRA. TURNED KEY ON, NOTHING. AFTER READING THE COMMENTS ON IGNITION FAILURE, CALLED AAA TO HAVE MY '06FJRA TOWED TO THE YAMAHA DEALER. THE YAMAHA DEALERS SERVICE MANAGER CHECKED ON IGNITION AND WAS TOLD "THERE'S NONE IN THE COUNTRY". HE HAD NO IDEA HOW LONG IT WOULD TAKE TO GET THE PART. INDICATED THAT THIS IS A WI…
Read full complaint
2006 YAMAHA FJRA. TURNED KEY ON, NOTHING. AFTER READING THE COMMENTS ON IGNITION FAILURE, CALLED AAA TO HAVE MY '06FJRA TOWED TO THE YAMAHA DEALER. THE YAMAHA DEALERS SERVICE MANAGER CHECKED ON IGNITION AND WAS TOLD "THERE'S NONE IN THE COUNTRY". HE HAD NO IDEA HOW LONG IT WOULD TAKE TO GET THE PART. INDICATED THAT THIS IS A WIDESPREAD PROBLEM WITH ALL YEARS OF THE FJR. *TR
NHTSA ODI #10238136
13,500 miles · Aug 14, 2008
Electrical System
LOST ALL ELECTRICAL POWER TO THE MOTORCYCLE AS I WAS ACCELERATING UP A HILL WITH A CAR DIRECTLY BEHIND ME CAUSING AN EXTREMELY UNSAFE SITUATION. PROBLEM WAS DIAGNOSED AS AN IGNITION SWITCH FAILURE BY NORTH COUNTRY POWERSPORTS IN RANGELY MAINE. *TR
NHTSA ODI #10238117
15,891 miles · Aug 10, 2008
Electrical System
1.DURING A CROSS COUNTRY ROAD TRIP, IGNITION SWITCH FAILED AFTER REFUELING MOTORCYCLE. 2.FIRST TIME, STRANDED 1200 MILES FROM HOME. 3.BIKE TOWED BY TOWING SERVICE TO DEALER 50 MILES AWAY. BY PASSED SWITCH, INSTALLED TOGGLE SWITCHES, TOGGLE SWITCH FAILED ON LAST DAY OF TRIP WHILE TRAVELING DOWN INTERSTATE HIGHWAY. REMOVE SWITCH…
Read full complaint
1.DURING A CROSS COUNTRY ROAD TRIP, IGNITION SWITCH FAILED AFTER REFUELING MOTORCYCLE. 2.FIRST TIME, STRANDED 1200 MILES FROM HOME. 3.BIKE TOWED BY TOWING SERVICE TO DEALER 50 MILES AWAY. BY PASSED SWITCH, INSTALLED TOGGLE SWITCHES, TOGGLE SWITCH FAILED ON LAST DAY OF TRIP WHILE TRAVELING DOWN INTERSTATE HIGHWAY. REMOVE SWITCH, TWISTED WIRES TOGETHER AND CAME ON HOME. *TR
NHTSA ODI #10237578
19,500 miles · Aug 7, 2008
Electrical System
IGNITION SWITCH FAILURE ON 2006 YAMAHA FJR1300 MOTORCYCLE. MINE FAILED WHILE PARKED, BUT OTHERS ON THE FJR FORUM FAILED WHILE RIDING CAUSING IMMEDIATE ENGINE CUT OFF. DEALER REPLACE THE IGNITION SWITCH AT MY COST. SEE HTTP://WWW.FJRFORUM.COM/FORUM//INDEX.PHP?SHOWTOPIC=26098. *TR
NHTSA ODI #10237408
12,500 miles · Aug 3, 2008
Electrical System
WHILE ON CROSS COUNTRY MOTORCYCLE TRIP, THE IGNITION SWITCH FAILED CAUSING THE VEHICLE TO LOSE ALL POWER. HAD THIS OCCURRED IN TRAFFIC (WHICH IT HAS ON OTHER'S BIKES) IT COULD HAVE BEEN CATASTROPHIC. IT ONLY FAILED ONCE, AND REMAINED BROKEN. ROADSIDE REPAIR REQUIRED HOT WIRING THE BIKE AND BYPASSING THE FAILED IGNITION SWITCH. …
Read full complaint
WHILE ON CROSS COUNTRY MOTORCYCLE TRIP, THE IGNITION SWITCH FAILED CAUSING THE VEHICLE TO LOSE ALL POWER. HAD THIS OCCURRED IN TRAFFIC (WHICH IT HAS ON OTHER'S BIKES) IT COULD HAVE BEEN CATASTROPHIC. IT ONLY FAILED ONCE, AND REMAINED BROKEN. ROADSIDE REPAIR REQUIRED HOT WIRING THE BIKE AND BYPASSING THE FAILED IGNITION SWITCH. *TR
NHTSA ODI #10236765
19,500 miles · Aug 1, 2008
Electrical System
TOTAL FAILURE OF THE IGNITION SWITCH WHILE IN TRAFFIC. HAD JUST TURNED LEFT ONTO A HIGHWAY AND THE BIKE JUST SHUT DOWN. I WAS LUCKY THAT I COULD GET TO THE SIDE OF THE ROAD RIGHT AWAY. THIS COULD HAVE BEEN BAD WITH A DIFFERENT MIX OF TRAFFIC. I HAD NO WARNING AT ALL THAT ANYTHING WAS WRONG. *TR
NHTSA ODI #10236674
34,450 miles · Jul 31, 2008
Electrical System
TL*THE CONTACT OWNS A 2006 YAMAHA FJR 1300. HE STATED THAT THERE WAS AN ELECTRICAL FAILURE WITH THE MOTORCYCLE. THE IGNITION SWITCH (MAIN SWITCH) BROWN WIRE WAS IMPROPERLY MANUFACTURED. THE CONTACT IS A FORMER BIKE MECHANIC AND REPLACED THE IGNITION SWITCH. THE FAILURE MILEAGE WAS 34,450 AND CURRENT MILEAGE IS 39,020. UPDATED 0…
Read full complaint
TL*THE CONTACT OWNS A 2006 YAMAHA FJR 1300. HE STATED THAT THERE WAS AN ELECTRICAL FAILURE WITH THE MOTORCYCLE. THE IGNITION SWITCH (MAIN SWITCH) BROWN WIRE WAS IMPROPERLY MANUFACTURED. THE CONTACT IS A FORMER BIKE MECHANIC AND REPLACED THE IGNITION SWITCH. THE FAILURE MILEAGE WAS 34,450 AND CURRENT MILEAGE IS 39,020. UPDATED 09/10/08 *BF UPDATED 09/15/09*JB
NHTSA ODI #10236544
NHTSA investigations
2EA08025 · Motorcycle Stalling - Electrical
Opened Nov 21, 2008 · Closed Jan 9, 2009
Status: closed (inferred from source dates) · Electrical System:ignition:switch
ODI IS AWARE OF AT LEAST 45 ALLEGATIONS OF FJR1300 ENGINE STALLING WHILE UNDERWAY DUE TO AN IGNITION SWITCH FAILURE.IN SOME INSTANCES, CYCLING THE SWITCH WILL ALLOW RE-START.FJRFORUM.COM HAS NUMEROUS THREADS ALLEGING THE SAME ISSUE.SHORTLY AFTER OPENING THIS EA, AND BEFORE RECEIVING A RELATED INFORMATION REQUEST FROM US, YAMAHA DECIDED TO CONDUCT A SAFETY RECALL (09V-002) TO INSTALL NEW IGNITION SWITCHES IN ALL MY 2006-8 AND EARLY MY 2009 FJR1300 MOTORCYCLES.WITH THAT DECISION, THIS INVESTIGATION IS CLOSED.
PE08048 · Motorcycle Stalling - Electrical
Opened Aug 8, 2008 · Closed Nov 21, 2008
Status: closed (inferred from source dates) · Electrical System:ignition:switch
ODI IS AWARE OF AT LEAST 45 ALLEGATIONS OF FJR1300 ENGINE STALLING WHILE UNDERWAY DUE TO AN IGNITION SWITCH FAILURE.IN SOME INSTANCES, CYCLING THE SWITCH WILL ALLOW RE-START.FJRFORUM.COM HAS NUMEROUS THREADS ALLEGING THE SAME ISSUE.TO GATHER MORE FOCUSED INFORMATION ABOUT THIS SUBJECT, WE ARE UPGRADING THIS PE TO AN EA (EA08-025).
Illustration