2004 Workhorse Chassis

TL*THE CONTACT OWNS 2005 WINNEBAGO ADVENTURER WITH A 2004 WORKHORSE CHASSIS. THE CONTACT HAD THE CALIPERS REPLACED ON THE WORKHORSE CHASSIS UNDER A RECALL, BUT THE DEALER WOULD NOT REPAIR ANY OTHER PARTS THAT WERE DAMAGED. THE FAILURE CAUSED THE ROTORS TO CRACK AND BREAK. THE MANUFACTURER STATED THAT THEY DO NOT FIX ANYTHING THAT WAS NOT LISTED IN THE RECALL AND THAT ANY DAMAGE CAUSED FROM THE FAILURE IN THE CALIPERS, WOULD BE THE OWNERS RESPONSIBILITY. THE FAILURE AND CURRENT MILEAGES WERE 17000. UPDATED 02/01/11*LJ UPDATED 04/14/11

2004 SIGHTSEER, -MODEL# WFD30B. I'M HAVING PROBLEMS WITH THE MR JUST SLOWING DOWN AS IF THE BRAKES ARE BEING APPLYED. I HAD THE ENGINE SCOPED AND ALL WAS WELL. I HAVE BEEN TOLD IT COULD HAVE BEEN THE BRAKES, BUT WORKHORSE SAID MY MODEL WAS NOT ON THE RECALL LIST. HAVE BEEN TOLD 1. WRONG CATALYTIC CONVERTER 2. FUEL FILTER 3. BRAKES GETTING HOT AND GRABBING. 4. PARKING BRAKE NOT RELEASING. I HAD TO STOP FOR 30-40 MINUTES, THEN COULD DRIVE FOR 2-3 HOURS, THEN THE LOAE OF POWER OCCURED AGAIN ? HELP! *TR

TL*THE CONTACT OWNS A 2004 WORKHORSE TRAILER MODEL W22. WHILE ATTEMPTING TO APPLY THE BRAKES THE CONTACT NOTICED THAT THE BRAKE PEDAL HAD SUDDENLY FELL TO THE FLOOR. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE REAR CALIPERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 46000. UPDATED 11/03/10. *LJ THE CONSUMER STATED THE REAR CALIPERS FAILED AND THE ABS LIGHT ILLUMINATED. UPDATED 11/04/10*JB

TL*THE CONTACT OWNS A 2004 HOLIDAY RAMBLER RV EQUIPPED WITH A 2004 WORKHORSE CHASSIS W22. WHILE THE CONTACT WAS DRIVING IN RAINY WEATHER CONDITIONS APPROXIMATELY 30 MPH, THE BRAKES WERE ENGAGED AND THE ANTI-LOCK BRAKE SYSTEM WARNING LIGHT ILLUMINATED. THE BRAKES BECAME SPONGY AND TRAVELED TO THE FLOOR WITHOUT RESISTANCE. THERE WAS A BURNING BRAKE ODOR OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE FAILURE WAS CONTRIBUTED TO THE ABS SENSOR. THE WORKHORSE MANUFACTURER WAS NOTIFIED AND THEY REFUSED TO REPAIR THE RELATED DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 09V110000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER STATED THAT THE FAILURE WAS DUE TO NORMAL WEAR AND TEAR. THE CONTACT STATED THAT ON JUNE 11, 2007 THE VEHICLE THE CALIPERS, FRONT AND REAR BRAKE PADS, AND BRAKE LINE HOSES WERE REPLACED. THE FOUR ROTORS WERE ALSO TURNED. THE TOTAL REPAIR COST WAS $3,005.23. IN ADDITION, THE ABS SENSOR WAS PREVIOUSLY REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 20,238.

TL*THE CONTACT OWNS A 2004 DAMON INTRUDER RV EQUIPPED WITH A 2004 WORKHORSE CHASSIS W22. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THE BRAKES WERE ENGAGED; THE FRONT BRAKES BEGAN TO VIBRATE AND THE REAR BRAKES WERE DRAGGING EMITTING A STRONG BURNING ODOR. SUDDENLY, THE VEHICLE WAS DRIVEN ONTO THE EMERGENCY LANE AND THE ENGINE WAS TURNED OFF. THE CONTACT RESTARTED THE VEHICLE AFTER TWO HOURS SO THAT THE BRAKES COULD COOL DOWN. THE FAILURE OCCURRED APPROXIMATELY 10 TIMES AND CONTINUED TO OCCUR. THERE WAS A RECALL ASSOCIATED TO THE NHTSA CAMPAIGN ID NUMBER 09V225000 (SERVICE BRAKES, HYDRAULIC). THE AUTHORIZED DEALER WAS NOTIFIED AND THE PART WAS UNAVAILABLE. THE MANUFACTURER HAD NOT INFORMED THE DEALER REGARDING THE RECALL PART AVAILABILITY. THE CONTACT HAD CONCERN OF THE UNCERTAINTY OF WHEN THE PART WOULD BE AVAILABLE AND THE SAFETY ISSUE ADDRESSED IN THE RECALL. THE FAILURE MILEAGE WAS 14,000. UPDATED EVOQ 07/30/10*JB

TL*THE CONTACT OWNS A 2004 FLEETWOOD BOUNDER RV EQUIPPED WITH A 2004 WORKHORSE CHASSIS W22. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH WHEN THE BRAKES WERE ENGAGED AND THEY LOCKED IMMEDIATELY WITHOUT WARNING. THE FAILURE OCCURRED REPEATEDLY AND PROGRESSED TO WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN STATED THAT THE FAILURE WAS RELATED TO THE BRAKE CALIPERS AND BRAKE PADS. THE CONTACT REPAIRED THE VEHICLE AND THE FAILURE CONTINUED TO OCCUR. THE CONTACT RECEIVED A RECALL NOTICE UNDER NHTSA CAMPAIGN ID NUMBER 09V110000 (SERVICE BRAKES, HYDRAULIC); HOWEVER, THE PART WAS UNAVAILABLE WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE APPROXIMATELY 8,000.

TL*THE CONTACT OWNS A 2004 WORKHORSE W22. THE CONTACT RECEIVED A RECALL NOTICE FROM THE MANUFACTURER MAY 2009 AND A SECOND NOTICE DECEMBER 2009 FOR RECALL 09V110000 (SERVICE BRAKES, HYDRAULIC). HE CALLED THE MANUFACTURER THREE TIMES TO FIND OUT WHEN THE PARTS WOULD BE AVAILABLE. THE VEHICLE HAD THE VEHICEL REPAIRED SEVERAL TIMES IN REFERENCE TO THE FAILURE BUT THE MANUFACTURER OFFERED NO REIMBURSEMENT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 22,000. UPDATED 7/20/10 *CN UPDATED 07/23/10*JB

TL*THE CONTACT OWNS A 2004 WORKHORSE W22. THE CONTACT STATED THAT THE BRAKES FAILED IN 2006 AND WERE REPAIRED AT HIS EXPENSE. HOWEVER, THEY FAILED AGAIN. THE CONTACT RECEIVED A RECALL NOTICE FOR RECALL 09V110000 (SERVICE BRAKES, HYDRAULIC) AND HAD BEEN IN CONSTANT CONTACT WITH THE MANUFACTURER ATTEMPTING TO HAVE THE VEHICLE REPAIRED. HOWEVER, THE PARTS WERE UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000. UPDATED 07/19/10. *LJ UPDATED 09/21/10

TL*THE CONTACT OWNS A 2004 ALLEGRO OPEN ROAD RV WITH WORKHORSE CHASSIS. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE LEFT FRONT BRAKE WHEEL LOCKED UP. THE CONTACT TURN THE VEHICLE OFF FOR A WHILE AND WAS ABLE TO RESTART IT. THE VEHICLE WAS TAKEN TO A DEALERSHIP WHERE THE BRAKES WERE REPAIRED WITH USED PARTS AT THE CONTACT'S EXPENSE. ON THE DAY THAT HE PICKED UP THE VEHICLE FROM THE DEALERSHIP, THE FRONT BRAKES LOCKED UP AGAIN. HE TOOK THE VEHICLE BACK TO THE DEALERSHIP AND THE REPAIRS WERE DONE AGAIN FREE OF CHARGE. THE CONTACT REFERENCED RECALL 50901-C REGARDING THE BRAKE DEFECT, FOR WHICH HE HAD RECEIVED TWO RECALL NOTICES.THE FAILURE MILEAGE WAS APPROXIMATELY 32,800. THE CURRENT MILEAGE WAS APPROXIMATELY 34,000.

TL*THE CONTACT OWNS A 2004 WORKHORSE CHASSIS. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED ACCORDING TO RECALL 04V195000 (ELECTRICAL SYSTEM) AND RECEIVED A RECALL NOTICE FOR A BRAKE SYSTEM DEFECT (NOT IN NHTSA DATABASE): BOSCH CAMPAIGN ID:50901-C. THE CONTACT WAS DRIVING AT APPROXIMATELY 45 MPH WHEN THE BRAKE PEDAL STUCK SUDDENLY. THE CONTACT ALSO NOTICED A LOT OF HEAT BEING EMITTED FROM THE BRAKES AND SMOKE FROM THE WHEELS SO HE REMOVED THE PADS FROM THE ROTORS AND DROVE HOME. THE BRAKES DID NOT RETRACT SO THE ROTORS OVERHEATED INTERMITTENTLY. THE VEHICLE WAS NOT INSPECTED AT THE TIME OF THE COMPLAINT. THE CONTACT CALLED THE MANUFACTURER WHO INFORMED HIM THAT THE PARTS FOR REPAIR WERE UNAVAILABLE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000. THE CURRENT MILEAGE WAS APPROXIMATELY 34,000.