IllustrationINSTRUMENT CLUSTER DISPLAY GOES BLACK (NO DISPLAY) AT TIMES WHILE DRIVING.
2004 Workhorse Chassis
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Chassis years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
725–50K
150–75K
075–100K
0100–150K
0150K+
28 reports with mileage · 6 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports2 fire reports0 injury reports
Electrical System complaints
5 reportsTL* THE CONTACT OWNS A 2004 WORKHORSE CHASSIS W22. WHILE DRIVING 65 MPH UPHILL, THE VEHICLE SEIZED AND BRAKE FLUID WAS LEAKING. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
DRIVING DOWN 295@ 70 MPH , ENGINE DIED, LOST POWER STEERING, BRAKES, ALL ELECTRICAL. DEAD IN THE WATER, NEEDED TO TOW. I UNDERSTAND THAT THIS IS A PROBLEM WITH THIS CHASSIS. APPARENTLY THE IGNITION SWITCH MOUNTED ON THE STEERING COLUMN BURNS OUT BECAUSE IT IS OVERLOADED. WORKHORSE OFFERS A FIX USING RELAY COSTS OVER $300.00, SO …
Read full complaint
DRIVING DOWN 295@ 70 MPH , ENGINE DIED, LOST POWER STEERING, BRAKES, ALL ELECTRICAL. DEAD IN THE WATER, NEEDED TO TOW. I UNDERSTAND THAT THIS IS A PROBLEM WITH THIS CHASSIS. APPARENTLY THE IGNITION SWITCH MOUNTED ON THE STEERING COLUMN BURNS OUT BECAUSE IT IS OVERLOADED. WORKHORSE OFFERS A FIX USING RELAY COSTS OVER $300.00, SO THEY MUST REALIZE IT IS A PROBLEM.
CONSUMER WAS NOT INFORMED OF RECALL ON WORKHORSE CUSTOM CHASSIS. *TS THE CONSUMER REQUEST A COPY OF THE ORIGINAL RECALL WHICH WAS SENT ON DECEMBER 2004. THE RECALL WAS TO REPROGRAM THE ELECTRONIC INSTRUMENT PANEL (I/P) CLUSTER SOFTWARE (RECALL NUMBER 50402-C). *NM
RECALL CAMPAIGN 04V195000 CONCERNING WORKHORSE FMVSS 101 AND 105 INSTRUMENT CLUSTER. THE CONSUMER WAS UNABLE TO GET THE DEALER TO HONOR THIS RECALL SINCE MID FEBRUARY 2005. *AK THE CONSUMER WAS INFORMED THAT THE DEALER DID NOT HAVE THE TOOL TO INSERT THE CORRECT DATA INTO THE IP CLUSTER. THE CONSUMER FOUND A DEALER WHO WA…
Read full complaint
RECALL CAMPAIGN 04V195000 CONCERNING WORKHORSE FMVSS 101 AND 105 INSTRUMENT CLUSTER. THE CONSUMER WAS UNABLE TO GET THE DEALER TO HONOR THIS RECALL SINCE MID FEBRUARY 2005. *AK THE CONSUMER WAS INFORMED THAT THE DEALER DID NOT HAVE THE TOOL TO INSERT THE CORRECT DATA INTO THE IP CLUSTER. THE CONSUMER FOUND A DEALER WHO WAS ABLE TO PERFORM THE RECALL REPAIRS. *SC *JB
Official recalls
104V195000 · Electrical System
Apr 22, 2004
CERTAIN CHASSIS EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 101 "CONTROLS AND DISPLAYS" AND 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELL TALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: WORKHORSE WILL NOTIFY ITS CUSTOMERS AND REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN JANUARY 2005. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-246-7731.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.