Engine And Engine CoolingEquipment Adaptive/mobility
I OWN A 2004 WINNEBAGO ADVENTURER WPG38R. I INCURRED WHAT AMOUNTED TO A PREMATURE FAILURE OF THE EXHAUST SYSTEM ON MY ON A GENERATOR, DIRECTLY CAUSED BY WINNEBAGO IGNORING ONAN'S "RECOMMENDED" INSTALLATION INSTRUCTIONS. THOSE INSTRUCTIONS SPECIFICALLY STATE A SUPPORT BRACKET BE INSTALLED IF THE TAILPIPE ASSEMBLY IS MORE THAN …
Read full complaint
I OWN A 2004 WINNEBAGO ADVENTURER WPG38R. I INCURRED WHAT AMOUNTED TO A PREMATURE FAILURE OF THE EXHAUST SYSTEM ON MY ON A GENERATOR, DIRECTLY CAUSED BY WINNEBAGO IGNORING ONAN'S "RECOMMENDED" INSTALLATION INSTRUCTIONS. THOSE INSTRUCTIONS SPECIFICALLY STATE A SUPPORT BRACKET BE INSTALLED IF THE TAILPIPE ASSEMBLY IS MORE THAN 18" LONG. THE TAILPIPE ASSEMBLY ON THIS UNIT IS 25" LONG. THE FIX, IF CAUGHT EARLY ON COST ME $725.00. MY REAL CONCERN INVOLVES SAFETY. ONAN WARNS IN THEIR INSTALLATION INSTRUCTIONS " A HOT EXHAUST PIPE CAN CAUSE ---- SEVERE PERSONAL INJURY OR DEATH. I ALSO ASSUME IT CAUSE CARBON MOXIDE POISONING OR HEAT/ FIRE DAMAGE TO THE MOTOR HOME. WINNEBAGO PUT IN WRITING TO ME THEY HAD ALL THEIR MODEL YEARS INSTALLATIONS APPROVED AND INSPECTED BY ONAN.. ONAN PUT IN WRITING TO ME THEY DIDN'T APPROVE OR INSPECT ANY INSTALLATIONS FOR ANY CUSTOMER. WHEN CONFRONTED WITH THIS INFORMATION, A WINNEBAGO CUSTOMER SERVICE REP ( BRIAN) TOLD ME THEN THE LACK OF THE SUPPORT INSTALLATION MUST HAVE BEEN APPROVED BY WINNEBAGO'S ENGINEERS. THEY ( WINNEBAGO) CONTINUED TO DENY ANY RESPONSIBILITY AS MY MOTOR HOME WAS OUT OF WARRANTY. ACCORDING TO ONAN'S WARRANTY THEY EXCLUDE ANY EXCEPTIONS TO THEIR INSTALLATION INSTRUCTIONS. MY WARRANTY THEREFORE WAS VOIDED THE DAY WINNEAGO INSTALLED THE GENERATOR ON MY UNIT AND OTHERS OF SIMILAR LENGTH. A WINNEBAGO TECHNICAL SUPPORT MAN TOLD ME VERBALLY OVER THE PHONE THAT UNIT CERTAINLY SHOULD HAVE A SUPPOPRT BRACKET INSTALLED. HE THEN WENT ON WINNEBAGO'S MANUFACTURING INSTRUCTIONS FOR MY MODEL AND STATED HE WAS SURPRISED IT WASN'T INCLUDED IN THEIR INSTALLATION INSTRUCTIONS. ONE OF THEIR INITIAL STATEMENTS TO ME OVER THE PHONE WAS "IF YOU THINK YOU'RE GETTING ANYTHING OUT OF WINNEBAGO, THINK AGAIN". THEY MAINTAINED THAT STANCE EVEN WHEN I SUBMITTED TO THEM THE SUPPORT INFORMATION I HAD COLLECTED THAT STATED THEY WERE AT FAULT. IT TOOK A LETTER FROM MY ATTORNEY AND A LOCAL TV STATION TO CHANGE THEIR MINDS AND REIMBURSE ME THE $725. *TR
WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence & remedy
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.
Consequence & remedy
Consequence: WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.
CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Winnebago Adventurer Problems, Complaints & Recalls | Skip That Year
Illustration