HX OF ENGINE SHUT OFF, 1999 ALPINE COACH W/ 39,670 MILES. SINCE PURCHASING IN OCTOBER 1998 HAD ENGINE QUIT NINE TIMES, FOUR OF WHICH HAPPENED WHILE TRAVELING AT HIGHWAY SPEEDS. HAD MANY REPAIRS DONE ON THE COACH ITSELF THROUGH WRV (MANUFACTURER), PLUS THE PROBLEMS WITH CUMMINS ENGINE SHUTTING OFF. PAPERWORK SHOWS MANY REPAIRS F…
Read full complaint
HX OF ENGINE SHUT OFF, 1999 ALPINE COACH W/ 39,670 MILES. SINCE PURCHASING IN OCTOBER 1998 HAD ENGINE QUIT NINE TIMES, FOUR OF WHICH HAPPENED WHILE TRAVELING AT HIGHWAY SPEEDS. HAD MANY REPAIRS DONE ON THE COACH ITSELF THROUGH WRV (MANUFACTURER), PLUS THE PROBLEMS WITH CUMMINS ENGINE SHUTTING OFF. PAPERWORK SHOWS MANY REPAIRS FOR THIS PROBLEM, BUT IT STILL HAPPENS. NOW THE COACH IS SETTING, UNABLE TO START AND RUN, DUE TO FUEL PUMP FAILURE. CUMMINS MOTORS DENIES THIS IS A WARRANTY PROBLEM, WILL PAY FOR 1/2 OF COST OF REBUILT FUEL PUMP. THROUGH RESEARCH I HAVE DISCOVERED THE ISC-330E-RV MOTOR DID HAVE A SAFETY CAMPAIGN FOR DEFECTIVE FUEL CAPS. I HAVE NEVER BEEN CONTACTED ABOUT THIS SAFETY ISSUE, NOR WERE CAPS REPLACED. THERE IS REAL DANGER TO MYSELF, MY WIFE, AND MY TWO CHILDREN HAVING A 30,000 POUND VEHICLE JUST SHUTTING OFF TRAVELING DOWN THE ROAD. I HAVE NO FAITH THAT A REBUILT FUEL PUMP WILL ADDRESS THE SITUATION OF ENGINE STALLING. IT IS A MOST DANGEROUS VEHICLE TO OPERATE AS IT IS.*AK
CERTAIN MOTOR HOMES, TRUCK CAMPERS, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: WESTERN RV WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR WESTERN RV AT 1-866-567-4133.
ON CERTAIN MOTOR HOMES (36', 38' AND 40") BUILT WITH BOSCH TWO-PISTON PIN-SLIDE BRAKE ASSEMBLIES, THE BRAKE CALIPERS CAN HANG-UP ON ANY OR ALL WHEELS.
Consequence & remedy
Consequence: DAMAGE TO THE BRAKE COMPONENTS CAN OCCUR RESULTING IN THE POTENTIAL LOSS OF BRAKING CAPABILITY.
Remedy: DEALERS WILL REPLACE THE ZOPS DISC BRAKE CLIPERS. THE RECALL BEGAN ON NOVEMBER 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WESTERN RV AT 1-509-457-4133.
VEHICLE DESCRIPTION: SHUTTLE BUSES, RECREATIONAL VEHICLES, UTILITY VANS, AND HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR WABCO PHASE 1, D-VERSION ANTILOCK BRAKE SYSTEM (ABS), FAIL TO COMPLY TO THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." AN INTERNAL DIAGNOSTIC SYSTEM IN THE ABS MAY NOT DETECT AN EXTREME WHEEL SPEED SENSOR AIR GAP. SUCH A CONDITION COULD POSSIBLY OCCUR DURING (1) ORIGINAL ASSEMBLY OR (2) SUBSEQUENT WHEEL END SERVICE.
Consequence & remedy
Consequence: THIS COULD DISABLE THE ANTI-LOCK FUNCTION ON THE AFFECTED WHEEL WITHOUT PROVIDING THE REQUIRED OPERATOR WARNING THAT THE ABS FUNCTION REQUIRES SERVICING.
Remedy: MERITOR IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY SCHEDULING FOR THIS CAMPAIGN. THE ABS ECU WILL BE REMOVED AND REPLACED OR THE ECU WILL BE REPROGRAMMED ON THE AFFECTED VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MERITOR WABCO AT 1-800-535-5560.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1999 Western Alpine Coach Problems, Complaints & Recalls | Skip That Year
Illustration