Fuel/propulsion SystemPower TrainVehicle Speed Control
2017 Volvo XC90 T8 plug-in hybrid, approximately 81,000 miles, experienced intermittent hesitation/loss of propulsion when accelerating. When acceleration is requested, the vehicle can hesitate before power is delivered, creating a serious safety concern when entering, merging into, or crossing traffic because expected accelerat…
Read full complaint
2017 Volvo XC90 T8 plug-in hybrid, approximately 81,000 miles, experienced intermittent hesitation/loss of propulsion when accelerating. When acceleration is requested, the vehicle can hesitate before power is delivered, creating a serious safety concern when entering, merging into, or crossing traffic because expected acceleration is not immediately available. Diagnostic testing identified faults in the IEM/ERAD system, including P286D00, Clutch A Engagement Time Performance/Too Slow, and P0A1B62, Drive Motor A Control Module, Algorithm Based Failure. The vehicle is currently being evaluated by an authorized Volvo dealer. I was advised that the high-voltage battery cells appear to be functioning properly and that the dealer is consulting Volvo technical support regarding the loss-of-acceleration condition. Volvo has issued Technical Journal guidance addressing ERAD clutch DTCs, including P286D00, on this generation of XC90. I am concerned that delayed or failed engagement of the ERAD clutch can cause an unexpected delay or loss of propulsion during acceleration. I am also aware of another NHTSA complaint involving a 2017 Volvo XC90 ERAD clutch failure, NHTSA Complaint No. 11673211, describing a delay in propulsion followed by sudden power delivery. I am requesting that NHTSA review this condition as a potential safety defect involving ERAD clutch engagement and intermittent loss or delay of propulsion in Volvo XC90 T8 vehicles.
NHTSA ODI #11761290
Mileage unknown · Sep 25, 2024
Electrical SystemPower Train
The Park Neutral Position (PNP) switch malfunctions. Yes Not a huge safety issue if you are parked in your driveway and cannot start the car. But if you are driving and the if you have the engine auto start/stop engaged the car will unexpectedly not restart and you have to play with the gear shifter to get it started to move out…
Read full complaint
The Park Neutral Position (PNP) switch malfunctions. Yes Not a huge safety issue if you are parked in your driveway and cannot start the car. But if you are driving and the if you have the engine auto start/stop engaged the car will unexpectedly not restart and you have to play with the gear shifter to get it started to move out of an intersection or out of the way of traffic! This has happened several times with my wife and myself. I have not had it confirmed by a dealer or service center No No
NHTSA ODI #11616395
Mileage unknown · Apr 12, 2022
Electrical SystemEnginePower Train
While driving in hybrid mode while both the gasoline and electric motor are running or shifting back and forth, occasionally the electric motor will come on with a sharp, sometimes loud, metallic “bang”. The sound and feel appears to be coming from the rear. The last two times it happened, the car lunged forward on its own witho…
Read full complaint
While driving in hybrid mode while both the gasoline and electric motor are running or shifting back and forth, occasionally the electric motor will come on with a sharp, sometimes loud, metallic “bang”. The sound and feel appears to be coming from the rear. The last two times it happened, the car lunged forward on its own without additional pressure on the accelerator, and once over the past week it lunged forward near an intersection when lifting off the accelerator pedal and engaging the brake. The lunge almost caused me to rear end the car in front of me which I was not very close to. This occurs about once every 50 miles travelled or once per day and at various speeds. To date it has not generated a CEL or any other type of warning.
NHTSA ODI #11460563
7,766 miles · Oct 15, 2018
EnginePower TrainVehicle Speed Control
ON 2018-09-17, THE VEHICLE, A 2017 VOLVO XC90 T8 HYBRID, REPORTED AN ERROR STATING "REDUCED PERFORMANCE" WITHIN THE INSTRUMENT GAUGE. THE VEHICLE CONTINUED TO DRIVE, WITHOUT THE HYBRID SYSTEM, ONLY WORKING ON THE GAS ENGINE. THE VEHICLE WAS DRIVEN APPROXIMATELY 3 MILES AFTER THE ERROR MESSAGE APPEARED. THE NEXT DAY, 2018-09-18, …
Read full complaint
ON 2018-09-17, THE VEHICLE, A 2017 VOLVO XC90 T8 HYBRID, REPORTED AN ERROR STATING "REDUCED PERFORMANCE" WITHIN THE INSTRUMENT GAUGE. THE VEHICLE CONTINUED TO DRIVE, WITHOUT THE HYBRID SYSTEM, ONLY WORKING ON THE GAS ENGINE. THE VEHICLE WAS DRIVEN APPROXIMATELY 3 MILES AFTER THE ERROR MESSAGE APPEARED. THE NEXT DAY, 2018-09-18, THE VEHICLE WAS STARTED, WITH THE SAME ERROR. AFTER DRIVING LESS THAN A QUARTER OF A MILE, THE VEHICLE ABRUPTLY HALTED IN THE MIDDLE OF AN INTERSECTION, AND THEN LIMITED THE VEHICLE SPEED TO 17 MILES PER HOUR. THE VEHICLE WAS RETURNED TO IT'S ORIGIN, UNABLE TO EXCEED THE 17 MPH RESTRICTION, AND A TOW TRUCK WAS CALLED IN. THE VEHICLE WAS AT THE NEAREST VOLVO DEALER FOR REPAIRS FOR 20 DAYS UNDERGOING REPAIRS. AS OF 2018-10-15, THE VEHICLE HAS BEGIN TO EXHIBIT A SIMILAR PROBLEM AS WAS ORIGINALLY REPORTED WITH 2 MONTHS OF VEHICLE PURCHASE IN SEPTEMBER, 2017, AND WHAT LED TO A MULTI-DAY REPAIR IN EARLY SEPTEMBER, 2018, PRIOR TO THIS INCIDENT OCCURRING IN MID SEPTEMBER, 2018.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Consequence & remedy
Consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Consequence & remedy
Consequence: The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.
Remedy: Volvo Car will notify owners, and dealers will update the rear seat control display software, free of charge. Owner notification letters were mailed July 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10093.
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Consequence & remedy
Consequence: If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
Remedy: Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R39917.
Volvo Car USA LLC (Volvo) is recalling certain 2017 XC90 vehicles. The Micro Gas Generator (MGG), a subcomponent part used within the right hand side seat belt retractor for the third row seats, may detach after the seatbelt retractor pretensioner is deployed.
Consequence & remedy
Consequence: Although, the seat belt will operate as intended in the event of a crash, if the MGG detaches, it may be a projectile within the vehicle cabin, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will replace the third row passenger's side seatbelt retractor, free of charge. The recall began August 4, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89716.
Volvo Car USA LLC (Volvo) is recalling certain 2017 XC90, S90, and V90 Cross Country vehicles. The bolts that secure the Inflatable Curtain (IC) air bags in place may break, possibly resulting in the IC air bag deploying improperly in the event of a crash. As, such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: If the IC air bags do not deploy properly in the event of a crash, the vehicle occupants have an increased risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect and replace the bolts, as necessary, free of charge. The recall is expected to begin April 1, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89714.
Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: If the seat belt buckle separates from the bracket, the front seat passenger may not be adequately restrained in the event of a crash, increasing their risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will inspect the front passenger seat belt buckle stud, replacing the seat belt buckle as needed, free of charge. The recall began January 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89708.
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence & remedy
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Additional source detail variants (2)
Equipment:appliance:air Conditioner
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Air Bags
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2017 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration