Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
480–25K
1325–50K
950–75K
1075–100K
7100–150K
2150K+
89 reports with mileage · 108 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports10 fire reports4 injury reports
What owners actually said
197 reports
Mileage unknown · Feb 22, 2023
EngineUnknown Or Other
Our car has shut down in the middle of traffic due to the oil going from full to empty in a few hundred miles. Oil change was recently done with synthetic oil and only had driven a few hundred miles when it went to empty. I had to buy a quart of oil at the gas station. I need to put an extra quart of oil every few hundred mile…
Read full complaint
Our car has shut down in the middle of traffic due to the oil going from full to empty in a few hundred miles. Oil change was recently done with synthetic oil and only had driven a few hundred miles when it went to empty. I had to buy a quart of oil at the gas station. I need to put an extra quart of oil every few hundred miles due to excessive oil consumption.
NHTSA ODI #11508511
53,000 miles · Jan 26, 2023
Engine
The contact owns a 2016 Volvo XC90. The contact stated the vehicle was leaking and consuming engine oil. The contact checked and became aware that there was no oil in the engine. There were no warning lights illuminated. The vehicle was taken to the local dealer who performed an oil consumption test and determined that the pist…
Read full complaint
The contact owns a 2016 Volvo XC90. The contact stated the vehicle was leaking and consuming engine oil. The contact checked and became aware that there was no oil in the engine. There were no warning lights illuminated. The vehicle was taken to the local dealer who performed an oil consumption test and determined that the piston rings and engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 53,000.
NHTSA ODI #11503813
Mileage unknown · Jan 20, 2023
Engine
engine consuming lots of oil. sometimes it fails to accelerate when I press the accelerator pedal.
NHTSA ODI #11502849
Mileage unknown · Jan 17, 2023
Electrical SystemUnknown Or Other
First, the rear passenger side door latch failed at 57k miles, allegedly due to water intrusion. They replaced with a revised part - p/n 32310869. Now at 63k miles, the driver side rear door latch failed in the same way. This compromises safety because it renders the rear seats completely inaccessible. I could not get my child…
Read full complaint
First, the rear passenger side door latch failed at 57k miles, allegedly due to water intrusion. They replaced with a revised part - p/n 32310869. Now at 63k miles, the driver side rear door latch failed in the same way. This compromises safety because it renders the rear seats completely inaccessible. I could not get my children out of the back seat through traditional means. The problem has been confirmed by a dealership and is well documented online. There was no warning or indication when the part had failed. The passenger door stopped working "regularly" (intermittently would not open) a few days before it failed entirely. The driver rear door gave no advanced notice.
NHTSA ODI #11502287
79,000 miles · Dec 27, 2022
Engine
The contact owns a 2016 Volvo XC90. The contact stated that she became aware the engine oil level was lower than needed. The vehicle was taken to the dealer and the contact was informed that the vehicle was experiencing excessive oil consumption. The vehicle was not repaired. The manufacturer was not contacted or notified of the…
Read full complaint
The contact owns a 2016 Volvo XC90. The contact stated that she became aware the engine oil level was lower than needed. The vehicle was taken to the dealer and the contact was informed that the vehicle was experiencing excessive oil consumption. The vehicle was not repaired. The manufacturer was not contacted or notified of the failure. The approximate failure mileage was 79,000.
NHTSA ODI #11498962
Mileage unknown · Dec 24, 2022
Structure
When temperatures drop below freezing, the rear door latches will not latch closed. Our children have to hang onto the doors to keep them from swinging open on corners while they also try not to fall out of the vehicle. Dealer says this is a common problem on this model, and is known to Volvo. They’ve attempted to regrease, a…
Read full complaint
When temperatures drop below freezing, the rear door latches will not latch closed. Our children have to hang onto the doors to keep them from swinging open on corners while they also try not to fall out of the vehicle. Dealer says this is a common problem on this model, and is known to Volvo. They’ve attempted to regrease, and advised that the technical service bulletin provided by Volvo does not fix the issue (attempting to reseal window above latch to keep from water intrusion/freezing).
NHTSA ODI #11498757
Mileage unknown · Dec 19, 2022
Engine
Engine oil consumption issue. Engine is consuming a quart of oil every 1,500 miles.
NHTSA ODI #11497997
100,000 miles · Dec 16, 2022
Visibility
The contact owns a 2016 Volvo XC90. The contact stated while driving down a hill and depressing the brake pedal, water started leaking through the sunroof. The contact stated he noticed water in the trunk of the vehicle. The contact took the vehicle to the local dealer, where it was diagnosed with needing the seals of the sunroo…
Read full complaint
The contact owns a 2016 Volvo XC90. The contact stated while driving down a hill and depressing the brake pedal, water started leaking through the sunroof. The contact stated he noticed water in the trunk of the vehicle. The contact took the vehicle to the local dealer, where it was diagnosed with needing the seals of the sunroof and the sunroof motor to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 100,000.
NHTSA ODI #11497718
65,000 miles · Nov 23, 2022
Suspension
The contact owns a 2016 Volvo XC90. The contact stated while driving 25 MPH, there was a rattling sound coming from the vehicle. The vehicle was taken to the dealer and the contact was informed that the front air strut needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure…
Read full complaint
The contact owns a 2016 Volvo XC90. The contact stated while driving 25 MPH, there was a rattling sound coming from the vehicle. The vehicle was taken to the dealer and the contact was informed that the front air strut needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure however, no assistance was provided. The failure mileage was 65,000.
NHTSA ODI #11494753
Mileage unknown · Nov 4, 2022
Engine
Engine coolant line leaking from a faulty coolant pipe. Which can potentially cause fire.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Consequence & remedy
Consequence: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.
Remedy: Dealers will inspect and tighten the second-row seat belt buckle anchorage bolts, as necessary, free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10259.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Consequence & remedy
Consequence: The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.
Remedy: Volvo Car will notify owners, and dealers will update the rear seat control display software, free of charge. Owner notification letters were mailed July 14, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10093.
Volvo Cars of N.A., LLC (Volvo Cars) is recalling certain 2016 XC90 vehicles. Exposure to heat and humidity may cause the engine coolant bleeder hose to crack, resulting in a coolant leak.
Consequence & remedy
Consequence: If the coolant leak goes unnoticed, coolant may accumulate in the catalytic converter heat shield insulation and catch fire when the vehicle is stationary, increasing the risk of injury.
Remedy: Volvo Cars will notify owners, and dealers will replace the engine side coolant bleeder hose, free of charge. The recall began June 12, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29936.
Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: If the seat belt buckle separates from the bracket, the front seat passenger may not be adequately restrained in the event of a crash, increasing their risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will inspect the front passenger seat belt buckle stud, replacing the seat belt buckle as needed, free of charge. The recall began January 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89708.
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence & remedy
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Additional source detail variants (2)
Equipment:appliance:air Conditioner
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Air Bags
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.
Consequence: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will inspect the air conditioning drain hose for proper installation, replacing the hose as necessary, free of charge. The recall is expected to begin on November the 14, 2016. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R89707.
Volvo Car USA LLC (Volvo) is recalling certain model year 2016 XC90 vehicles manufactured January 27, 2015, to April 23, 2016. The sunroofs on the affected vehicles have a switch on the overhead console that may not be adequately recessed to prevent the switch from being unintentionally pressed. When pressed, the sunroof may fully close. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 118, "Power-Operated Window, Partition, and Roof Panel Systems."
Consequence & remedy
Consequence: If the switch is unintentionally pressed and the sunroof panel closes, there is an increased risk of occupant injury.
Remedy: Volvo will notify owners, and dealers will perform a software upgrade that disables the auto-close function, free of charge. The recall began June 24, 2016. Owners may contact Volvo customer service at 1-800-458-1552 or by visiting http://Volvo.custhelp.com. Volvo's number for this recall is R89702.
Volvo Cars of N.A., LLC (Volvo) is recalling certain model year 2016 Volvo XC90 vehicles manufactured January 27, 2015, to July 10, 2015. The third row seating side curtain air bags may not fully inflate.
Consequence & remedy
Consequence: Underinflated air bags may not fully protect third row occupants, increasing the risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will modify the D-pillar interior panels to allow full inflation of the third row airbags, free of charge. The recall began on September 21, 2015. Owners may contact Volvo Customer Care at 1-800-458-1552.
Volvo Cars of N.A., LLC (Volvo) is recalling certain model year 2016 Volvo XC90 vehicles manufactured January 27, 2015, to May 19, 2015. The affected vehicles have front seats whose wiring harness for the Side Impact Protection System (SIPS) may have been routed incorrectly.
Consequence & remedy
Consequence: If the wiring harness is routed incorrectly, the wiring may be damaged, disabling the front seat side impact air bag, and increasing the risk of injury to the seat occupant in the event of a crash necessitating deployment of the front seat side impact air bag.
Remedy: Volvo will notify owners, and dealers will inspect the routing of the SIPS wiring, correcting the routing and installing a protective sleeve as necessary, free of charge. The recall began on June 30, 2015. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89571.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2016 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration