2016 Volvo XC90

Previous issues with brakes, suspension, leaking sunroof, electrical and gauges. Vehicle became disabled due to defect with coolant system, smoke from engine compartment, towed to Monterery Volvo (dealership/service center identified issues with coolant leak present turbo & cooling Plastic pipe. Cruise control-Vacuum Pump: Found vacuum pump leaking oil. Estimated repair $5,414.38

The contact owns a 2016 Volvo XC90. The contact stated that the vehicle had experienced high oil consumption. After adding oil to the engine, the message "Oil Level Low" was display within three weeks. Additionally, while operating the vehicle the message "low engine function" had displayed and the vehicle would not properly accelerate and was jerking. The contact also discovered puddles of water inside the rear trunk of the vehicle with electrical wires and components submerged in the water. The vehicle had experienced various electrical failures with the back-up camera malfunctioning. In addition, there was mold inside the vehicle. The cause of the failure was not yet determined. The manufacturer and local dealer were contacted regarding the failures. The failure mileage was 75,000. The VIN was not included.

for last 2 years, my 2016 xc90 has kept request to add oil every 1 or 2 month. In May, 2023, my car speed suddenly reduced the speed to 25 miles and the turtle sign popped up. It was very dangerous when I drove it on the highway, it was almost get hit by the car after me. After I sent to dealer, I was told that the the cylinder of the engine did not work. The engine light has been on and off many times. I sent my car to the dealer regularly for the maintenance

My 2016 Volvo XC90's engine has suffered from high oil consumption that has required excessive servicing and additions of motor oil. These issues began several years ago when the XC90's low oil warning message appeared. The local Volvo dealership said my XC90 had an oil leak and it would cost over $10,000 to determine the source of the leak. So the Volvo dealership suggested that I regularly put 2 quarts of oil in the engine every couple hundred miles, which I have done. Despite the Volvo dealership's speculative guess, no oil leakage was ever seen and there was never any oil pooling under the vehicle. Then on Sunday, June 25, 2023, out of nowhere a "reduced engine performance" message popped up. The XC90 swerved, almost causing a wreck, while greatly decreasing speed in traffic on the interstate. I was barely able to get to the next exit where the engine died. Our car had to be towed over 30 miles to the nearest Volvo dealership. The engine was leaking oil throughout the engine compartment, including fully coating the spark plugs. Additionally, the motor mount is broken in multiple places causing the engine to shake wildly. Now I am told the engine is destroyed and will cost $20,000-$24,000 to replace. Volvo knows about the defective pistons and piston rings in the 2016 XC90 engines, as illustrated by Technical Journal 31216.6.0, but has never issued a recall. The local Volvo service dept. never checked, much less replaced the defective pistons and piston rings, even though it knew or should have known the defect could require the engine to be replaced. In speaking with Volvo customer service, I was advised that Volvo service technicians are not required to follow the service solutions found in the technical journal. Volvo's failure to recall the defective engines has now exposed my family, including my baby, to unnecessary danger, but also exposed us to grossly excessive costs/expenses due to known defects. A recall should be required for all 2016 XC90 engines.

My XC90 had the oil consumption issue that I started reporting at 50K miles and Volvo finally performed a piston ring replacement at 80K miles under a service action. Fuel injectors were also replaced by the Dealer. On our first long distance trip from Tallahassee to Atlanta, the car lost all power and stopped on I-75, almost killing us. It had to be towed and the dealer says that the engine was flooded by fuel due to fuel pump module failure causing fuel injectors to stay activated and engine needs to be replaced. I believe that the issue was caused by the repair not being done correctly or the time it took Volvo to take responsibility for the oil consumption issue and subsequent repair.

Like you know now most 2016 volvo xc90 are burning oil 2-3 quarts every 1500 miles car is smoking blue smoke most of the xc90 2016 with 2.0 liter engine volvo has like extended warranty up to 100k on some cars but cars where burning oil from 2016 year most cars are over 100k volvo will not help fix issue . No check engine light on cars ! You stay behind the muffler can’t breath how bad it stinks no check engine passing emission like that !!! I don’t have money to pay $11000 to replace pistons rings volvo will not help so guess this car will smoke and can pass emission

Our car has shut down in the middle of traffic due to the oil going from full to empty in a few hundred miles. Oil change was recently done with synthetic oil and only had driven a few hundred miles when it went to empty. I had to buy a quart of oil at the gas station. I need to put an extra quart of oil every few hundred miles due to excessive oil consumption.

The contact owns a 2016 Volvo XC90. The contact stated the vehicle was leaking and consuming engine oil. The contact checked and became aware that there was no oil in the engine. There were no warning lights illuminated. The vehicle was taken to the local dealer who performed an oil consumption test and determined that the piston rings and engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 53,000.