NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
223 reports120,000 miles · Jan 16, 2015
Engine
TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE EMITTED AN ABNORMAL NOISE AND STALLED. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRE CEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE EMITTED AN ABNORMAL NOISE AND STALLED. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRE CEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
NHTSA ODI #10673038
129,300 miles · Jan 12, 2015
Engine
THE BEARING FOR THE COUNTER BALANCE SHAFT HAS FAILED ON MY VEHICLE, CAUSING OVER $3,000 IN REPAIRS NEEDED. VOLVO HAS ADMITTED THAT THIS IS A KNOWN ISSUE WITH OLDER 2005 XC90'S WITH THE V8, BUT ARE NOT WILLING TO COVER MY REPAIRS COSTS. I FEEL THERE SHOULD BE A RECALL. IF THIS BEARING FAILS WHILE DRIVING THE ENGINE COULD SEIZE C…
Read full complaint
THE BEARING FOR THE COUNTER BALANCE SHAFT HAS FAILED ON MY VEHICLE, CAUSING OVER $3,000 IN REPAIRS NEEDED. VOLVO HAS ADMITTED THAT THIS IS A KNOWN ISSUE WITH OLDER 2005 XC90'S WITH THE V8, BUT ARE NOT WILLING TO COVER MY REPAIRS COSTS. I FEEL THERE SHOULD BE A RECALL. IF THIS BEARING FAILS WHILE DRIVING THE ENGINE COULD SEIZE CAUSING AN ACCIDENT. *TR
NHTSA ODI #10671814
90,000 miles · Dec 26, 2014
Electrical SystemFuel/propulsion System
2005 XC90 V8 STALLED IN TRAFFIC. WOULD NOT RESTART, BUT STARTER WOULD CRANK. FUEL PUMP CONTROLLER WAS FOUND TO BE INTERNALLY CORRODED AND FILLED WITH DRIED SALT. THIS CONTROLLER IS MOUNTED FORWARD OF THE RIGHT REAR WHEEL WELL. MANY INSTANCES OF THIS CONTROLLER FAILING DUE TO SALT / MOISTURE INGRESS HAVE BEEN REPORTED BY OTHE…
Read full complaint
2005 XC90 V8 STALLED IN TRAFFIC. WOULD NOT RESTART, BUT STARTER WOULD CRANK. FUEL PUMP CONTROLLER WAS FOUND TO BE INTERNALLY CORRODED AND FILLED WITH DRIED SALT. THIS CONTROLLER IS MOUNTED FORWARD OF THE RIGHT REAR WHEEL WELL. MANY INSTANCES OF THIS CONTROLLER FAILING DUE TO SALT / MOISTURE INGRESS HAVE BEEN REPORTED BY OTHER OWNERS. THE CONTROLLER WAS RELOCATED TO THE INSIDE OF THE VEHICLE SOME MODEL YEARS LATER. *TR
NHTSA ODI #10668406
115,000 miles · Nov 22, 2014
Electrical SystemFuel/propulsion System
DRIVING AT APPROXIMATELY 40 MPH, THE CHECK ENGINE AND OIL WARNING LIGHTS APPEARED. THE CAR COMPLETELY DIED WHILE I WAS ON THE ROAD. THE STEERING WHEEL AND BRAKES FROZE UP AND THE SPEED DECREASED TO BARELY NOTHING. I COULD GET THE CAR TO JUST MAKE IT OFF THE ROAD SAFELY BECAUSE I COULD NOT TURN THE WHEEL OR USE THE BRAKES WELL…
Read full complaint
DRIVING AT APPROXIMATELY 40 MPH, THE CHECK ENGINE AND OIL WARNING LIGHTS APPEARED. THE CAR COMPLETELY DIED WHILE I WAS ON THE ROAD. THE STEERING WHEEL AND BRAKES FROZE UP AND THE SPEED DECREASED TO BARELY NOTHING. I COULD GET THE CAR TO JUST MAKE IT OFF THE ROAD SAFELY BECAUSE I COULD NOT TURN THE WHEEL OR USE THE BRAKES WELL. THOUGHT IT WAS MY OIL SO I WAS ABLE TO GET SOMEONE TO ADD OIL TO IT WHILE ON SIDE OF BUSY ROAD. STARTED CAR UP FINE AND DROVE FOR 5 MORE DAYS UNTIL IT HAPPENED AGAIN. GOT IT TOWED TO MECHANIC WHO CHANGED THE FUEL PUMP. OTHER ELECTRICAL PROBLEMS AROUSE WHILE MECHANIC HAD IT SO BROUGHT TO VOLVO WHO SAYS I NEED A NEW CONTROL ELECTRIC MODULE IN MY CAR. *TR
NHTSA ODI #10660192
156,000 miles · Nov 18, 2014
Electrical System
AFTER PARKING AT RESTAURANT, WE WALKED TO OUR PARKED VOLVO AND WHEN I TURNED THE KEY, IT WOULD ONLY GO FROM 0 TO THE 1 POSITION ( I.E.LIGHTS, RADIO WOULD COME ON) BUT IT WOULD NOT TURN ANY FURTHER TO THE START POSITION HAD TO HAVE IT TOWED TO THE DEALER AND WAS TOLD THIS HAS HAPPENED BEFORE TO THIS MODEL AND IT IS AN IGNITION LO…
Read full complaint
AFTER PARKING AT RESTAURANT, WE WALKED TO OUR PARKED VOLVO AND WHEN I TURNED THE KEY, IT WOULD ONLY GO FROM 0 TO THE 1 POSITION ( I.E.LIGHTS, RADIO WOULD COME ON) BUT IT WOULD NOT TURN ANY FURTHER TO THE START POSITION HAD TO HAVE IT TOWED TO THE DEALER AND WAS TOLD THIS HAS HAPPENED BEFORE TO THIS MODEL AND IT IS AN IGNITION LOCK FAILURE. THEY NEED TO ORDER THE PART FROM SWEDEN AND HAVE IT MATCH OUR KEYS. $850 !!. THIS IS A SAFETY ISSUE IN MY MIND HAS WE COULD HAVE BEEN STRANDED ANYWHERE AND IF THIS IS NOT THE FIRST TIME THIS HAS HAPPENED, WHY ARE THEY NOT RECALLING THIS PART? *TR
NHTSA ODI #10658892
85,000 miles · Nov 3, 2014
Engine
I WAS JUST DRIVING ALONG AT 30 MPH OR LESS WHEN I HEARD A PRETTY LOAD NOISE AND THEN FELT A VIBRATION ON THE FLOOR BOARD. I WAS JUST A BLOCK AWAY FROM MY DESTINATION AND WHEN I GOT THERE THE NOISE CONTINUED. I ORIGINALLY THOUGHT THE NOISE WAS COMING FROM UNDER THE CAR BUT AFTER FURTHER INVESTIGATION LATER IN THE DAY AFTER LETT…
Read full complaint
I WAS JUST DRIVING ALONG AT 30 MPH OR LESS WHEN I HEARD A PRETTY LOAD NOISE AND THEN FELT A VIBRATION ON THE FLOOR BOARD. I WAS JUST A BLOCK AWAY FROM MY DESTINATION AND WHEN I GOT THERE THE NOISE CONTINUED. I ORIGINALLY THOUGHT THE NOISE WAS COMING FROM UNDER THE CAR BUT AFTER FURTHER INVESTIGATION LATER IN THE DAY AFTER LETTING THE CAR SIT FOR AWHILE I REALIZED THE NOISE WAS COMING FROM THE ENGINE. I HAD THE CAR ORIGINALLY TOWED TO MY MECHANIC WHO INFORMED ME THAT THE ENGINE WAS BLOWN. I COULD NOT BELIEVE THIS I HAD THE CAR A LITTLE UNDER ONE YEAR AND THE PREVIOUS OWNER ALWAYS HAD THE CAR SERVICED THROUGH A VOLVO DEALERSHIP FROM DAY ONE TO 60,200. I TOOK OVER THE CAR AND AT THE TIME OF THE INCIDENT MY CAR HAD A LITTLE OVER 85,000 MILES. ENGINES ARE NOT SUPPOSE TO FAIL AT UNDER 100,000 MILES. THERE IS SOMETHING SERIOUSLY WRONG WITH THESE ENGINES. THE INTERNET IS FULL OF THESE STORIES JUST LIKE MINE AND VOLVO IS DOING NOTHING ABOUT IT! THEY DO NOT CARE, THEY DO NOT STAND BEHIND THEIR CARS. SOMETHING HAS TO BE DONE ABOUT THIS A LOT OF INNOCENT PEOPLE ARE BEING HURT FINANCIALLY BY VOLVO. A RECALL ON THESE CAR SHOULD BE ISSUED...VOLVO NEEDS TO BE HELD ACCOUNTABLE FOR THIS! VOLVO MADE THE DETERMINATION NOT TO HELP ME...WITHOUT EVEN SEEING THE CAR AND THE SERVICE RECORDS. ACTION NEEDS TO HAPPEN AND THEY NEED TO BE FORCED TO HELP ME AND THE HUNDREDS IF NOT THOUSANDS OF PEOPLE THAT HAVE BEEN AFFECTED BY THIS. *TR
NHTSA ODI #10652117
170,000 miles · Oct 24, 2014
Electrical SystemExterior LightingVehicle Speed Control
WHILE DRIVING VEHICLE AT 55-60 MPH ALL DASHBOARD LIGHTS CAME ON AND CAR LOST POWER. THIS CAUSED A FRIGHTENING AND EXTREMELY DANGEROUS SITUATION. WITHOUT HEADLIGHTS OR TAIL LIGHTS I COULD NOT BE SEEN BY OTHER DRIVERS. I TRIED TO CROSS 2 LANES AND GET ONTO THE SHOULDER WITH NO POWER STEERING OR ENGINE POWER. WHILE I WAS VERY FORTU…
Read full complaint
WHILE DRIVING VEHICLE AT 55-60 MPH ALL DASHBOARD LIGHTS CAME ON AND CAR LOST POWER. THIS CAUSED A FRIGHTENING AND EXTREMELY DANGEROUS SITUATION. WITHOUT HEADLIGHTS OR TAIL LIGHTS I COULD NOT BE SEEN BY OTHER DRIVERS. I TRIED TO CROSS 2 LANES AND GET ONTO THE SHOULDER WITH NO POWER STEERING OR ENGINE POWER. WHILE I WAS VERY FORTUNATE I WAS NOT IN OR DID NOT CAUSE A SERIOUS ACCIDENT I HAD AN EXTREMELY CLOSE CALLS. I CHANGED LANES AND ALMOST COLLIDED WITH ANOTHER VEHICLE TRAVELING AT 55. ONCE IN THE LANE ANOTHER DRIVER WHO WAS UNABLE TO SEE MY VEHICLE (NO LIGHTS) CAME UP BEHIND ME AT A HIGH RATE OF SPEED. ONLY A LAST MINUTE SWERVE AVOIDED A REAR END COLLISION THAT NO DOUBT WOULD HAVE CAUSED A TERRIBLE ACCIDENT WITH VERY SERIOUS IF NOT TRAGIC RESULTS. ADDITIONALLY OTHER DRIVERS HAD TO SWERVE TO AVOID THE VEHICLE-CAUSING A VERY DANGEROUS, CHAOTIC SITUATION. THE LOSS OF POWER AND LOSS OF LIGHTS CAME CLOSE TO CAUSING A MAJOR MULTI-VEHICLE ACCIDENT. MANY ARE AWARE OF THIS PROBLEM. PLEASE DO NOT WAIT UNTIL PEOPLE ARE KILLED TO REOPEN THE INVESTIGATION AND RE-CONSIDER A SAFETY RECALL. *TR
NHTSA ODI #10649780
45 miles · Oct 24, 2014
EnginePower Train
THIS IS A 2005 VOLVO THAT HAS A HISTORY OF TRANSMISSION FAILURE IN ALL CARS OF THIS MODEL AND YEAR. IF ONE GOOGLES THE MODEL AND MAKE OF THIS CAR ONE WILL FIND FORUM AFTER FORUM OF PEOPLE WHO HAVE HAD TO REPLACE THESE FAILED TRANSMISSIONS BEFORE OR SHORTLY AFTER WARRANTY IS UP. THE DEALERS AND SERVICES HAVE LARGELY PUT THIS…
Read full complaint
THIS IS A 2005 VOLVO THAT HAS A HISTORY OF TRANSMISSION FAILURE IN ALL CARS OF THIS MODEL AND YEAR. IF ONE GOOGLES THE MODEL AND MAKE OF THIS CAR ONE WILL FIND FORUM AFTER FORUM OF PEOPLE WHO HAVE HAD TO REPLACE THESE FAILED TRANSMISSIONS BEFORE OR SHORTLY AFTER WARRANTY IS UP. THE DEALERS AND SERVICES HAVE LARGELY PUT THIS ITEM WHICH SHOULD HAVE BEEN A RECALL ISSUE ON TO THE CUSTOMER. MY TRANSMISSION FAILED WHEN TRYING TO ACCELERATE ON TO A FREEWAY. I WAS NEARLY IN A LIKELY FATAL COLLISION DUE TO THE TRANSMISSION FAILING TO GO OUT OF 2ND GEAR. THERE WAS A CLASS ACTION SUIT SURROUNDING THIS ISSUE IN THIS MODEL , BUT FEW VOLVO OWNERS WERE NOTIFIED OF IT. PLEASE HELP US AND DEMAND THAT VOLVO RECALL THESE CARS, REPAY FOR FAILED TRANSMISSIONS AND LOST VALUE OF THE CARS......ONE CANNOT EVEN GIVE THEM AWAY NO AND THESE WERE 45K$ CARS!!!!!!!!!!FURIOUS. *TR
NHTSA ODI #10649735
155,000 miles · Oct 7, 2014
Power Train
TRANSMISSION COMPLETELY FAILED. THIS WAS THE 2ND TRANSMISSION, AS THE FIRST ONE FAILED AT 45000 MILES. I HAD TO REPLACE THE TRANSMISSION AT A COST OF $6000. REBUILDING FAILED TRANS WAS SLIGHTLY CHEAPER BUT NOT WORTH IT. I UNDERSTAND THERE IS A CLASS ACTION LAWSUIT, BUT WAS SETTLED BEFORE MY TRANSMISSION FAILED. *TR
NHTSA ODI #10641999
Mileage unknown · Aug 28, 2014
Engine
I PURCHASE A USED 2005 VOLVO ON APRIL 19, 2013 FROM C& M AUTO SALES CORPORATION. IN DECEMBER OF 2013 I RECEIVED A RECALL NOTICE FROM VOLVO. THEY NOTIFIED ME THAT ALL 2004-2005 VOLVO XC90- WERE RECALLED. I WAS INFORMED TO TAKE IT TO A VOLVO DEALER. I DROVE THE VEHICLE TO WHITE PLAINS, N Y. DEALER THERE I WAS TOLD THEY TOOK…
Read full complaint
I PURCHASE A USED 2005 VOLVO ON APRIL 19, 2013 FROM C& M AUTO SALES CORPORATION. IN DECEMBER OF 2013 I RECEIVED A RECALL NOTICE FROM VOLVO. THEY NOTIFIED ME THAT ALL 2004-2005 VOLVO XC90- WERE RECALLED. I WAS INFORMED TO TAKE IT TO A VOLVO DEALER. I DROVE THE VEHICLE TO WHITE PLAINS, N Y. DEALER THERE I WAS TOLD THEY TOOK CARE OF THE PROBLEM. UPON RETURNING HOME I NOTICED ALL LIGHTS WERE ON THE DASHBOARD & RETURN THE VEHICLE TO THE DEALER. THERE WERE MANY ISSUES CLAIMED BY THE DEALERS AND WAS TOLD TO PICK IT UP WHICH I DID EVER SINCE THEN VEHICLE HAS BEEN PARKED AND NOT DRIVEN. *TR
NHTSA ODI #10629144
Official recalls
6Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 25, 2007
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
Consequence & remedy
Consequence: MISPLACEMENT OF THE JACK'S CRANK HANDLE CAN POSE A SAFETY RISK AS IT CAN RESULT IN A SHORT CIRCUIT OF THE BATTERY WHICH COULD THEN LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Nov 17, 2005
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequence & remedy
Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE10025 · Central Electronic Module Failure
Opened Jul 20, 2010 · Closed Nov 22, 2010
Status: closed (inferred from source dates) · Electrical System
Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.
EA06006 · Volvo XC90 Battery Cable Failures
Opened Mar 21, 2006 · Closed Jun 14, 2007
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Electrical SYSTEM:12V/24V/48V Battery:cables
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Electrical SYSTEM:12V/24V/48V Battery
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05064 · Windshield Wiper Arm Performance
Opened Dec 2, 2005 · Closed May 10, 2006
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.
PE05057 · Volvo XC90 Battery Cable Failures
Opened Nov 2, 2005 · Closed Mar 23, 2006
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:starter Assembly; Electrical System:wiring; Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Additional source detail variants (4)
Electrical SYSTEM:12V/24V/48V Battery:cables
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:starter Assembly
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Illustration