IllustrationVOLVO XC90 2005 V8 - COUNTER BALANCE SHAFT FAILURE LEADING TO TOTAL ENGINE FAILURE AND REQUIRING ENGINE REPLACEMENT. *TR
2005 Volvo XC90
Owner reports · Recalls · Investigations
More warning signs than most XC90 years
Owner complaints for the 2005 Volvo XC90 are substantially higher than the model-year median of 34.
About this comparison →How this year compares
Owner complaints by model year
Compare all XC90 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
1325–50K
5350–75K
4375–100K
56100–150K
16150K+
195 reports with mileage · 28 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports3 fire reports1 injury reports
What owners actually said
223 reportsTRANSMISSION FAILURE OF VOLVO XC90 T6. KNOWN PROBLEM THAT THE TRANSMISSION IN THIS CAR IS BAD. LEFT STRANDED IN THE MIDDLE OF AN INTERSECTION AND WAS ALMOST REAR-ENDED! "TRANSMISSION SERVICE URGENT" LIGHT CAME ON AND TOOK TO BE CHECKED OUT. WAS TOLD COULDN'T FIND PROBLEM AND REPLACED FLUID. TO NO AVAIL AND WAS LEFT STRANDED! I H…
Read full complaint
TRANSMISSION FAILURE OF VOLVO XC90 T6. KNOWN PROBLEM THAT THE TRANSMISSION IN THIS CAR IS BAD. LEFT STRANDED IN THE MIDDLE OF AN INTERSECTION AND WAS ALMOST REAR-ENDED! "TRANSMISSION SERVICE URGENT" LIGHT CAME ON AND TOOK TO BE CHECKED OUT. WAS TOLD COULDN'T FIND PROBLEM AND REPLACED FLUID. TO NO AVAIL AND WAS LEFT STRANDED! I HAVE FOUND COUNTLESS COMPLAINTS ONLINE FROM OTHERS WITH THIS SAME ISSUE!! *TR
MY 2005 VOLVO XC90'S TRANSMISSION UNEXPECTEDLY FAILED DURING ACCELERATION WHILE I WAS TURNING LEFT ACROSS TRAFFIC CAUSING A SIGNIFICANT DECREASE IN POWER WHICH IN TURN REQUIRED SEVERAL CARS TO HAVE TO "SLAM" ON THEIR BRAKES TO AVOID HITTING ME. THEIR "SLAMMING" ON THE BRAKES CAUSED THE CARS BEHIND THEM TO HAVE TO BRAKE HARD TO A…
Read full complaint
MY 2005 VOLVO XC90'S TRANSMISSION UNEXPECTEDLY FAILED DURING ACCELERATION WHILE I WAS TURNING LEFT ACROSS TRAFFIC CAUSING A SIGNIFICANT DECREASE IN POWER WHICH IN TURN REQUIRED SEVERAL CARS TO HAVE TO "SLAM" ON THEIR BRAKES TO AVOID HITTING ME. THEIR "SLAMMING" ON THE BRAKES CAUSED THE CARS BEHIND THEM TO HAVE TO BRAKE HARD TO AVOID REAR-ENDING THEM. AFTER TAKING THE SUV TO THE DEALERSHIP FOR DIAGNOSTIC CHECK AND LEARNING THAT OUR TRANSMISSION NEEDED TO BE REPLACED, I DID A SEARCH ON OUR CAR MAKE AND MODEL AND FOUND THAT I WAS NO WHERE NEAR THE FIRST PERSON TO EXPERIENCE A TERRIFYING EVENT LIKE THIS DUE TO VOLVO'S TRANSMISSION FAILURES. I FOUND PAGE AFTER PAGE OF ACCOUNTS WHERE PEOPLES CARS SUDDENLY WOULD NOT ACCELERATE AS USUAL DUE TO TRANSMISSION FAILURE. THIS IS A MAJOR SAFETY ISSUE THAT I THINK THE NTSB NEEDS TO INVESTIGATE DUE TO VOLVO'S REFUSAL TO EITHER ACKNOWLEDGE OR CORRECT THE PROBLEM. PLEASE DON'T WAIT UNTIL AN ENTIRE FAMILY IS HURT OR KILLED BEFORE TAKING ACTION. PLEASE DO NOT REPEAT THE TOYOTA MISTAKES. *TR
I HAVE A 2005 VOLVO XC90 T6. THE TRANSMISSION FAILED ON THE HIGHWAY TODAY,AND I WAS NEARLY REAR ENDED WITH TWO SMALL CHILDREN IN THE TRUCK. THE LIGHT CAME ON NOW THAT SAID TRANSMISSION SERVICE URGENT. I COMPLAINED TO THE VOLVO DEALER 7 MONTHS AGO. THEY DID A SOFTWARE UPGRADE AND SAID ALL WAS FINE.VOLVO IS WELL AWARE OF THIS PROB…
Read full complaint
I HAVE A 2005 VOLVO XC90 T6. THE TRANSMISSION FAILED ON THE HIGHWAY TODAY,AND I WAS NEARLY REAR ENDED WITH TWO SMALL CHILDREN IN THE TRUCK. THE LIGHT CAME ON NOW THAT SAID TRANSMISSION SERVICE URGENT. I COMPLAINED TO THE VOLVO DEALER 7 MONTHS AGO. THEY DID A SOFTWARE UPGRADE AND SAID ALL WAS FINE.VOLVO IS WELL AWARE OF THIS PROBLEM WITH MANY MANY 2005 XC 90 T6 VEHICLES. *TR
MY 2005 VOLVO XC-90 DOES NOT AUTOMATICALLY LOCK ANY OF THE VEHICLE DOORS WHEN THE CAR IS PUT IN DRIVE AND STARTS MOVING. THIS IS A SERIOUS SAFETY DEFECT THAT I COMPLAINED ABOUT TO VOLVO, FORD AND NHTSA IN 2005. FORD MOTOR COMPANY AND VOLVO ADVERTISE THE XC-90 AS THE SAFEST VEHICLE ON THE ROAD. FORD AND VOLVO HAVE OTHER CARS…
Read full complaint
MY 2005 VOLVO XC-90 DOES NOT AUTOMATICALLY LOCK ANY OF THE VEHICLE DOORS WHEN THE CAR IS PUT IN DRIVE AND STARTS MOVING. THIS IS A SERIOUS SAFETY DEFECT THAT I COMPLAINED ABOUT TO VOLVO, FORD AND NHTSA IN 2005. FORD MOTOR COMPANY AND VOLVO ADVERTISE THE XC-90 AS THE SAFEST VEHICLE ON THE ROAD. FORD AND VOLVO HAVE OTHER CARS BEFORE AND AFTER THE XC-90'S INTRODUCTION THAT AUTOMATICALLY LOCKS THE DOORS WHEN THE VEHICLE IS PUT IN DRIVE AND STARTS MOVING. FORD MOTOR COMPANY HAS HAD AUTOMATIC DOOR LOCKS ON MANY OF THEIR OTHER VEHICLES FOR YEARS SO THEY TRAINED US TO EXPECT IT, AND THEN THEY LEAVE THIS FEATURE OFF! I BELIEVE THIS DESIGN FLAW HAS BEEN IN EXISTENCE SINCE THE XC-90 WAS FIRST INTRODUCTION INTO THE UNITED STATES IN 2004. THIS IS UNCONSCIONABLE!!! *TR
MY 2005 VOLVO XC90 WITH ONLY 88000 MILES IS HAVING TRANSMISSION PROBLEMS JUST THIS MORNING A MESSAGE READS URGENT TRANSMISSION PROBLEM AND I RESEARCH AND NOTICE THAT MANY CUSTOMERS HAVE HAD THIS SAME PROBLEM WITH THE SAME VEHICLE MODEL AND YEAR YET VOLVO HAS NOT DONE A RECALL ON IT. *TR
COUNTER BALANCE BEARING FAILED AT 55,504 MILES. NON-GREASED BEARING FAILURE, CAUSED BY RUSTING, DUE TO MOISTURE BUILD UP INSIDE OF ENGINE CHAMBER. VEHICLE HAD ALL REQUIRED SERVICE DONE A VOLVO DEALERSHIPS. ENGINE WAS REPAIRED NOT REPLACED, FOR A COST OF $5000.00. REPAIR WORK WAS DONE AT VOLVO DEALERSHIP. VOLVO MECHANIC DRILL…
Read full complaint
COUNTER BALANCE BEARING FAILED AT 55,504 MILES. NON-GREASED BEARING FAILURE, CAUSED BY RUSTING, DUE TO MOISTURE BUILD UP INSIDE OF ENGINE CHAMBER. VEHICLE HAD ALL REQUIRED SERVICE DONE A VOLVO DEALERSHIPS. ENGINE WAS REPAIRED NOT REPLACED, FOR A COST OF $5000.00. REPAIR WORK WAS DONE AT VOLVO DEALERSHIP. VOLVO MECHANIC DRILLED WEEPING HOLE IN CHAMBER WHERE COUNTER BALANCE SHAFT SITS TO ALLOW WATER CAUSED BY MOISTURE BUILD UP TO ESCAPE. DRILLING WEEPING HOLE WAS PART OF A TECH BULLETIN ISSUED BY VOLVO. V8 ENGINES FOR THE XC90 PRODUCED IN 2005 DID NOT INITIALLY HAVE THIS WEEPING HOLE IN THEM. THIS DESIGN CHANGE WAS IMPLEMENTED PART WAY THROUGH THE PRODUCTION YEAR (I BELIEVE POST ENGINE #6833). LETTER WAS WRITTEN TO THE CEO OF VOLVO CARS OF N.A. LLC AND REPRESENTATIVE FROM HIS OFFICE REFUSED TO PROVIDE ANY SUPPORT, STATING THAT THE VEHICLE IN QUESTION WAS OUT OF WARRANTY AND THAT THERE WERE NO RECALLS WITH REGARDS TO THIS ISSUE. INFO PROVIDED TO VOLVO FROM SWEDESPEED.COM (SEE ODI ID #10313311), HOWEVER, THIS WAS REJECTED BY VOLVO AS A NON-VALID SOURCE OF INFORMATION (THEIR OWN CUSTOMERS!). THE REPAIR JOB TO REPLACE THE CB SHAFT AND BEARING WAS OVER 30 HOURS, NOT TO MENTION THE PARTS COST. WHAT WILL IT TAKE VOLVO TO ADMIT THERE IS A PROBLEM HERE AND ISSUE A RECALL TO REPLACE BEARINGS AND DRILL WEEPING HOLES IN THEIR 2005 XC90'S WITH V8 ENGINES? CONSIDERING THE COST THEY WILL INCUR, I'D SUGGEST THEY WILL NEED TO BE PUSHED. THE COST OF ENGINE REPAIR IS ($5,000) AND ENGINE REPLACEMENT ($15,000+). ALL BEARING FAILURES OUTSIDE OF WARRANTY ARE FALLING ON THE SHOULDERS OF THE CONSUMER. RECALLS ARE ABOUT SAFETY NOT COST TO THE MANUFACTURE. JUST BECAUSE THIS PROBLEM MAY ONLY BE LINKED TO THE 2005 V8 ENGINES DOESN'T MEAN IT IS NOT IMPORTANT ENOUGH TO BE ADDRESSED FOR NOT ONLY CONSUMER FINANCIAL PROTECTION BUT ALSO FOR SAFETY REASONS. THANKFULLY MY ENGINE DIDN'T FAIL WHILE MY FAMILY WAS DRIVING ON A BUSY INTERSTATE! *TR
I OWN A VOLVO 2005 XC90 AND ONLY 58,000 MILES NEED TO REPLACE THE TRANSMISSION. I SEARCH IN THE INTERNET FOR VOLVO XC90 TRANSMISSION AND IT SEEMS ALOT OF PEOPLE HAVING THE SAME PROBLEM WITH THIS MODEL.
MY 2005 VOLVO XC90 T6 TRANSMISSION HAS FAILED FOR A SECOND TIME AT 95,000 MILES. THIS IS THE SECOND DEFECTIVE TRANSMISSION FOR THE VEHICLE, WHICH WAS ORIGINALLY REPLACED AT 35,000 MILES. WHILE DRIVING ON THE INTERSTATE AND ATTEMPTING TO ACCELERATE INTO TRAFFIC, THE VEHICLE SUDDENLY WENT INTO HIGH RPMS AS IF IN "NEUTRAL", FAILE…
Read full complaint
MY 2005 VOLVO XC90 T6 TRANSMISSION HAS FAILED FOR A SECOND TIME AT 95,000 MILES. THIS IS THE SECOND DEFECTIVE TRANSMISSION FOR THE VEHICLE, WHICH WAS ORIGINALLY REPLACED AT 35,000 MILES. WHILE DRIVING ON THE INTERSTATE AND ATTEMPTING TO ACCELERATE INTO TRAFFIC, THE VEHICLE SUDDENLY WENT INTO HIGH RPMS AS IF IN "NEUTRAL", FAILED TO PROPERLY ACCELERATE, AND THE "SERVICE TRANSMISSION WARNING" LIGHT CAME ON. THIS DEALER SAYS THE TRANSMISSION MUST BE REPLACED A SECOND TIME. VOLVO IS AWARE OF THE CHRONIC PROBLEM WITH THE 2003-2005 T6 VERSION OF THE XC90 BUT THUS FAR HAS NOT ISSUED A RECALL. IT IS NOT UNHEARD OF FOR THE VEHICLES TO REQUIRE 2 OR THREE TRANSMISSIONS BY 100,000 MILES. THERE ARE HUNDREDS IF NOT THOUSANDS OF SIMILAR REPORTS AVAILABLE ON INTERNET WEBSITES. THIS IS A DANGEROUS SITUATION BECAUSE THE VEHICLE SUDDENLY STALLS WITHOUT WARNING WHILE THE DRIVER IS ATTEMPTING TO ACCELERATE, SUCH AS WHEN MERGING INTO INTERSTATE TRAFFIC.
MY CAR STALLS WHILE DRIVING. WHEN CHECKED OUT BY DEALERSHIP THEY IDENTIFIED PROBLEMS WITH THE FUEL PUMP. ON YOUR WEB SITE THERE IS A RECALL FOR 2005 VOLVO XC90, WHICH MY CAR. HOWEVER, VOLVO IS DECLINING MY REQUEST TO FIX THE FUEL PUMP. *TR
Official recalls
610V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
09V483000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
07V221000 · Electrical SYSTEM:12V/24V/48V Battery:cables
May 25, 2007
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
Consequence & remedy
Consequence: MISPLACEMENT OF THE JACK'S CRANK HANDLE CAN POSE A SAFETY RISK AS IT CAN RESULT IN A SHORT CIRCUIT OF THE BATTERY WHICH COULD THEN LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V155000 · Steering:linkages:tie Rod Assembly
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V144000 · Visibility:windshield Wiper/washer
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
05V529000 · Electrical System:starter Assembly:solenoid
Nov 17, 2005
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequence & remedy
Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE10025 · Central Electronic Module Failure
Opened Jul 20, 2010 · Closed Nov 22, 2010
Status: closed (inferred from source dates) · Electrical System
Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.
EA06006 · Volvo XC90 Battery Cable Failures
Opened Mar 21, 2006 · Closed Jun 14, 2007
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Electrical SYSTEM:12V/24V/48V Battery:cables
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Electrical SYSTEM:12V/24V/48V Battery
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05064 · Windshield Wiper Arm Performance
Opened Dec 2, 2005 · Closed May 10, 2006
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.
PE05057 · Volvo XC90 Battery Cable Failures
Opened Nov 2, 2005 · Closed Mar 23, 2006
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:starter Assembly; Electrical System:wiring; Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Additional source detail variants (4)
Electrical SYSTEM:12V/24V/48V Battery:cables
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:starter Assembly
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.