NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
223 reports113,000 miles · Feb 3, 2011
Engine And Engine Cooling
COUNTERBALANCE SHAFT BEARING FAILURE AT 113,000 MILES LUCKILY FAILURE HAPPENED ON THE WAY TO THE REPAIR SHOP. IF THIS WOULD HAVE TAKEN PLACE ON THE HIGHWAY MY WIFE AND KIDS COULD HAVE BEEN SERIOUSLY INJURED. VOLVO KNOWS THIS IS AN ISSUE OR WOULD NOT HAVE RELEASED A TECHNICAL SERVICE BULLETIN ON WAYS TO REMEDY THE PROBLEM BY DR…
Read full complaint
COUNTERBALANCE SHAFT BEARING FAILURE AT 113,000 MILES LUCKILY FAILURE HAPPENED ON THE WAY TO THE REPAIR SHOP. IF THIS WOULD HAVE TAKEN PLACE ON THE HIGHWAY MY WIFE AND KIDS COULD HAVE BEEN SERIOUSLY INJURED. VOLVO KNOWS THIS IS AN ISSUE OR WOULD NOT HAVE RELEASED A TECHNICAL SERVICE BULLETIN ON WAYS TO REMEDY THE PROBLEM BY DRILLING WEEP HOLES IN THE BLOCK TO SHED MOISTURE. THE TRAPPED MOISTURE CAUSES THE BEARING TO RUST AND FINALLY FAIL CAUSING CATASTROPHIC ENGINE FAILURE. VOLVO HAS OFFERED A MERE $3,000.00 TO CORRECT A $15,000.00 PROBLEM. I HAVE READ NUMEROUS TESTIMONIES FROM OTHER 2005 XC-90 OWNERS WITH ENGINE FAILURE ALWAYS FROM THE FAILED COUNTERBALANCE SHAFT BEARING. HOW DO WE FORCE VOLVO TO ISSUE A RECALL BEFORE SOMEONE GETS SERIOUSLY INJURED.
NHTSA ODI #10380677
131,000 miles · Jan 31, 2011
Electrical SystemEngine And Engine CoolingFuel System, Other
2005 XC90 V8-MANY PROBLEMS WITH CHECK ENGINE LIGHT COMING ON AND CAR LOSING POWER. LOST POWER ON INTERSTATE-CAR WOULD LOSE POWER AND SPEED-NEEDED TOW-HAPPENED TWICE. CURRENT ISSUE CHECK ENGINE LIGHT CAME ON FOLLOWED BY ALL LIGHTS COMING ON STATING BRAKE FAILURE, POWER OVERLOAD, LIMP MODE AND BRAKE FAILURE. DEALER REPLACED ALTERN…
Read full complaint
2005 XC90 V8-MANY PROBLEMS WITH CHECK ENGINE LIGHT COMING ON AND CAR LOSING POWER. LOST POWER ON INTERSTATE-CAR WOULD LOSE POWER AND SPEED-NEEDED TOW-HAPPENED TWICE. CURRENT ISSUE CHECK ENGINE LIGHT CAME ON FOLLOWED BY ALL LIGHTS COMING ON STATING BRAKE FAILURE, POWER OVERLOAD, LIMP MODE AND BRAKE FAILURE. DEALER REPLACED ALTERNATOR AT COST OF $1006. 10 DAYS LATER CHECK ENGINE LIGHT AND ANTI SKID LIGHT CAME ON FOLLOWED BY BRAKE FAILURE LIGHT. CAR LOST HEADLIGHTS AND WINDSHIELD WIPERS-9 PM AND SLEETING. DEALER NOW SAYS NEED TO REPLACE CEM AND BATTERY AT A COST OF $3,000 DUE TO WATER IN CEM. IT WAS RAINING OR SLEETING BOTH TIMES THE CHECK ENGINE LIGHT CAME ON. VOLVO REDESIGNED THE COVER TO PREVENT WATER INTRUSION BUT NEEDS TO ISSUE RECALL. VERY DANGEROUS- TICKING TIME BOMB. SOMEONE WILL HAVE AN ACCIDENT ON RAINY NIGHT ON INTERSTATE. PLEASE CONSIDER REQUIRING RECALL-OWNERS OF THIS VEHICLE ARE SPENDING THOUSANDS OF DOLLARS DUE TO VOLVO XC90 V8 DESIGN FLAWS. HOW CAN VOLVO BE ALLOWED TO SELL VEHICLES THAT SHOULD NOT BE DRIVEN OUTSIDE/OR IN THE RAIN. *TR
NHTSA ODI #10379781
64,000 miles · Jan 27, 2011
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE FUEL TANK WHEN HE WAS DRIVING 25 MPH. THE CONTACT REFERENCED RECALL 09V483000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP) BUT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 64,000.
NHTSA ODI #10379327
115,000 miles · Jan 6, 2011
Engine And Engine Cooling
BALANCE SHAFT FAILURE ON 2005 VOLVO XC90 V8 WITH 115K MILES. UNBELIEVABLE THAT VOLVO WILL NOT ISSUE A RECALL FOR THIS. BALANCE SHAFT FAILED TODAY AT JUST UNDER 115K MILES... UNBELIEVABLE... AND I THOUGHT IT WAS JUST AN INTERNET RUMOR. IF YOU HAVE A 2005 XC90, SELL IT NOW! SERIOUSLY, THIS IS UNACCEPTABLE FOR A $50,000 VEHICLE, …
Read full complaint
BALANCE SHAFT FAILURE ON 2005 VOLVO XC90 V8 WITH 115K MILES. UNBELIEVABLE THAT VOLVO WILL NOT ISSUE A RECALL FOR THIS. BALANCE SHAFT FAILED TODAY AT JUST UNDER 115K MILES... UNBELIEVABLE... AND I THOUGHT IT WAS JUST AN INTERNET RUMOR. IF YOU HAVE A 2005 XC90, SELL IT NOW! SERIOUSLY, THIS IS UNACCEPTABLE FOR A $50,000 VEHICLE, AND EVEN MORE UNACCEPTABLE FOR VOLVO NOT TO ISSUE A RECALL. NEEDLESS TO SAY, I SERIOUSLY DOUBT WE WILL EVER BUY ANOTHER VOLVO AGAIN SIMPLY BECAUSE THEY SHOULD HAVE ISSUED A RECALL FOR THIS PROBLEM. SHOULD HAVE STUCK WITH THE GERMANS (AUDI OR BMW), OR DARE I SAY IT THE JAPANESE, OR EVEN THE AMERICANS! I CAN REPLACE A LOT OF WHEEL BEARINGS ON A YUKON FOR WHAT THIS BALANCE SHAFT IS GOING TO COST ME. VOLVO NEEDS TO MAKE IT RIGHT WITH EVERY OWNER OF A 2005 XC90. VOLVO KNOWS OF THIS PROBLEM AND THAT IS WHY THEY ISSUED A TSB TO DRILL A DRAIN HOLE IN THE BLOCK, BUT THEY NEED TO STEP UP AND ISSUE A RECALL OR, AT THE VERY LEAST IF AN OWNER COMES INTO THE DEALERSHIP WITH THIS PROBLEM, THEY NEED TO FIX IT AT NO CHARGE. IT WAS THEIR MISTAKE, OWN UP TO IT AND FIX IT! *TR
NHTSA ODI #10375029
100,093 miles · Dec 19, 2010
Electrical System
I WAS DRIVING WITH MY DAUGHTER ON A VERY LONG BRIDGE AT NIGHT IN MY 2005 VOLVO XC90. THE CHECK ENGINE LIGHT CAME ON AND WHILE THE CAR STAYED ON, IT APPEARED TO HAVE LOST POWER. I HAVE HAD OTHER ELECTRICAL PROBLEMS WITH THE CAR AND HAVE HAD IT TO THE DEALER 3 TIMES BUT THEY SAY THEY CAN'T FIND ANYTHING WRONG WITH IT. THIS WAS …
Read full complaint
I WAS DRIVING WITH MY DAUGHTER ON A VERY LONG BRIDGE AT NIGHT IN MY 2005 VOLVO XC90. THE CHECK ENGINE LIGHT CAME ON AND WHILE THE CAR STAYED ON, IT APPEARED TO HAVE LOST POWER. I HAVE HAD OTHER ELECTRICAL PROBLEMS WITH THE CAR AND HAVE HAD IT TO THE DEALER 3 TIMES BUT THEY SAY THEY CAN'T FIND ANYTHING WRONG WITH IT. THIS WAS BY FAR THE MOST DANGEROUS INCIDENT! AFTER DOING SOME INTERNET RESEARCH, I HAVE READ HUNDREDS OF REPORTS SIMILAR TO MINE. THERE IS A DEFINITE ISSUE WITH THIS CAR AND IT SHOULD BE RECALLED. *TR
NHTSA ODI #10371228
70,000 miles · Nov 29, 2010
Exterior Lighting
TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SIDE HEADLIGHT WOULD SHUT OFF INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A DEALER WHERE THE CONTACT WAS INFORMED THAT THEY WOULD HAVE TO REPLACE THE CEM UNIT. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS AP…
Read full complaint
TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SIDE HEADLIGHT WOULD SHUT OFF INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A DEALER WHERE THE CONTACT WAS INFORMED THAT THEY WOULD HAVE TO REPLACE THE CEM UNIT. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
NHTSA ODI #10368105
85,698 miles · Nov 3, 2010
Engine And Engine Cooling
OCTOBER 10, 2010 PURCHASED CASH 2005 XC90 V8. WENT THROUGH SAFETY AND EMISSION SERVICE FOR REGISTRATION-- OKAY. OCTOBER 22 HEARD A STRANGE NOISE FROM ENGINE, CALLED VOLVO DEALERSHIP TO REQUEST SERVICE. DIDN'T DRIVE ON OCTOBER 23, 2010. ON SUNDAY, OCTOBER 24, WENT OUT TO MOVE THE CAR FOR OPPOSITE SIDE PARKING AND TO GAS UP FOR D…
Read full complaint
OCTOBER 10, 2010 PURCHASED CASH 2005 XC90 V8. WENT THROUGH SAFETY AND EMISSION SERVICE FOR REGISTRATION-- OKAY. OCTOBER 22 HEARD A STRANGE NOISE FROM ENGINE, CALLED VOLVO DEALERSHIP TO REQUEST SERVICE. DIDN'T DRIVE ON OCTOBER 23, 2010. ON SUNDAY, OCTOBER 24, WENT OUT TO MOVE THE CAR FOR OPPOSITE SIDE PARKING AND TO GAS UP FOR DRIVE TO SERVICE CENTER. CAR STOPPED AT SERVICE STATION, AND HAD TO BE TOWED TO DEALERSHIP. DEALERSHIP DIAGNOSTICS OCTOBER 25, 2010 CONFIRMED: NOISE IS FROM EITHER BROKEN CONNECTING ROD OR BALANCE SHAFT....ADVICE TO CUSTOMER "NEEDS ENGINE" AT A COST OF $14,000+. THE CAR DID NOT COME WITH A WARRANTY AND EVEN NOW THE DEALER IS BECOMING INCREASINGLY EVASIVE--AS HE SAYS HE WAS THE OWNER/DEALER AT THE TIME OF SALE, AND AS INDIVIDUAL SELLER REGISTERED IN ANOTHER STATE AND NOT NEW YORK, SO DOES NOT HAVE TO HONOR WARRANTY OR ASSUME RESPONSIBILITY. CALL VOLVO NORTH AMERICA ON OCTOBER 26, 2010 WITH NO KNOWLEDGE OF OUR OWNERSHIP, (STILL HAVEN'T RECEIVED TITLE TO CAR). RESPONSE WAS --NO WARRANTY NO ASSISTANCE WITH THIS COUNTER BALANCE OR ANY OTHER ISSUE BEYOND 4 YEAR/50,000 MILES. CONCERN: BEFORE PURCHASE WHEN ASKING THE DEALER NO MENTION NOR WHEN RESEARCHED NO REVELATION OF THE COUNTERBALANCE SHAFT BEING AN ONGOING ISSUE FOR THE 2005 XC90 V8. HOWEVER, FURTHER EVIDENCE CLEARLY SHOWS DESIGN FLAWS IN THE ORIGINAL YAMAHA ENGINES, AND A SLIGHT COVERT ATTEMPT BY VOLVO TO FIX IT VIA ITS LIMITED EDITION TECHNICAL SERVICE BULLETIN(TSB) TO DRILL THE HOLE IN THE SHAFT TO LET BUILD UP MOISTURE ESCAPE. ADDITIONALLY, VOLVO'S SECOND ATTEMPT TO SLIGHTLY ADDRESS THE COUNTER BALANCE ISSUE IS EVIDENCED VIA ITS LIMITED AND PAY-TO-GET TSB INFORMING DEALERSHIPS NOT CONSUMERS 'OF NOT WASHING THE ENGINE,' WHICH MAY LEAD TO MOISTURE BUILD UP AND TOTAL ENGINE FAILURE. OUR ATTEMPTS ARE NOW BEING MADE FOR VOLVO TO MAINTAIN ITS SLOGAN OF "SAFETY FOR LIFE." WE WANT THE SAFETY ATTRIBUTE TO BE EFFECTIVE AND USEFUL WHEN THE CAR IS OPERABLE, AND NOT WHEN THE CAR IS INOPERABLE. *TR
NHTSA ODI #10363820
60,000 miles · Nov 1, 2010
Power Train
60,000 MILES ON A 1995 VOLVO XC90 AND THE TRANSMISSION JUST FAILED FOR THE FOURTH TIME. THE TRANSMISSION WAS ALREADY REPLACED THREE TIMES. FAILURE RESULTS IN CAR STOPPING WITHOUT WARNING. ANYTIME, ANYPLACE, IT JUST LOSES POWER. *TR
NHTSA ODI #10363533
90,000 miles · Oct 29, 2010
Electrical SystemPower Train
I HAVE A 2005 VOLVO XC90 T6. BOUGHT THIS CAR BRAND NEW. HAD SO MANY PROBLEMS INCLUDING TRANSMISSION OUT; THE BLINKERS DO NOT WORK. THE QUALITY AND SAFETY OF THIS VEHICLE IS MISLEADING AND THIS IS A HORRIBLE SAFETY ISSUE SINCE BLINKER DON'T WORK. LOOKING INTO IT, SEEMS LIKE THIS IS AN ONGOING ISSUE WITH MANY OWNER OF VOLVO X…
Read full complaint
I HAVE A 2005 VOLVO XC90 T6. BOUGHT THIS CAR BRAND NEW. HAD SO MANY PROBLEMS INCLUDING TRANSMISSION OUT; THE BLINKERS DO NOT WORK. THE QUALITY AND SAFETY OF THIS VEHICLE IS MISLEADING AND THIS IS A HORRIBLE SAFETY ISSUE SINCE BLINKER DON'T WORK. LOOKING INTO IT, SEEMS LIKE THIS IS AN ONGOING ISSUE WITH MANY OWNER OF VOLVO XC90 2005. THEY REALLY NEED TO RECALL THIS BEFORE IT'S TOO LATE AND CAUSE FATALITIES. *TR
NHTSA ODI #10362949
106,000 miles · Oct 14, 2010
Electrical SystemExterior Lighting
VEHICLE HAS DRIVER'S SIDE HEADLIGHT FAILURE. REPLACED BULB WITH CERTIFIED VOLVO REPLACEMENT AND STILL DID NOT WORK. CERTIFIED VOLVO MECHANIC TRACED FUSES AND ALL ELECTRICAL COMPONENTS (5 HOURS PAID SERVICE) AND FOUND THAT A PLASTIC PART DESIGNED TO KEEP WATER OUT OF THE INTERIOR (VIA WINDSHIELD) WAS DEFECTIVE, THEREFOR…
Read full complaint
VEHICLE HAS DRIVER'S SIDE HEADLIGHT FAILURE. REPLACED BULB WITH CERTIFIED VOLVO REPLACEMENT AND STILL DID NOT WORK. CERTIFIED VOLVO MECHANIC TRACED FUSES AND ALL ELECTRICAL COMPONENTS (5 HOURS PAID SERVICE) AND FOUND THAT A PLASTIC PART DESIGNED TO KEEP WATER OUT OF THE INTERIOR (VIA WINDSHIELD) WAS DEFECTIVE, THEREFORE, CAUSING WATER LEAKAGE TO DAMAGE THE CENTRAL ELECTRICAL MODULE . *TR
NHTSA ODI #10360458
Official recalls
6Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 25, 2007
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
Consequence & remedy
Consequence: MISPLACEMENT OF THE JACK'S CRANK HANDLE CAN POSE A SAFETY RISK AS IT CAN RESULT IN A SHORT CIRCUIT OF THE BATTERY WHICH COULD THEN LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Nov 17, 2005
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequence & remedy
Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE10025 · Central Electronic Module Failure
Opened Jul 20, 2010 · Closed Nov 22, 2010
Status: closed (inferred from source dates) · Electrical System
Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.
EA06006 · Volvo XC90 Battery Cable Failures
Opened Mar 21, 2006 · Closed Jun 14, 2007
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Electrical SYSTEM:12V/24V/48V Battery:cables
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Electrical SYSTEM:12V/24V/48V Battery
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05064 · Windshield Wiper Arm Performance
Opened Dec 2, 2005 · Closed May 10, 2006
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.
PE05057 · Volvo XC90 Battery Cable Failures
Opened Nov 2, 2005 · Closed Mar 23, 2006
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:starter Assembly; Electrical System:wiring; Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Additional source detail variants (4)
Electrical SYSTEM:12V/24V/48V Battery:cables
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:starter Assembly
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Illustration