NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
9 reportsClear category filter120,000 miles · Mar 17, 2014
Fuel System, GasolineVehicle Speed Control
WAS STARTING TO ACCELERATE AFTER A RED TRAFFIC LIGHT WHEN THE ENGINE SUDDENLY DIED AND CAR STOPPED RIGHT IN THE MIDDLE OF TRAFFIC. CAR WOULD NOT START AGAIN. BATTERY WAS GOOD, STARTED WORKED GOOD BUT IT SOUNDED LIKE NO GAS WAS GETTING TO THE ENGINE. BEING STUCK IN THE MIDDLE OF TRAFFIC, I WAS PUSHED BY THE CAR BEHIND ME TO A SAF…
Read full complaint
WAS STARTING TO ACCELERATE AFTER A RED TRAFFIC LIGHT WHEN THE ENGINE SUDDENLY DIED AND CAR STOPPED RIGHT IN THE MIDDLE OF TRAFFIC. CAR WOULD NOT START AGAIN. BATTERY WAS GOOD, STARTED WORKED GOOD BUT IT SOUNDED LIKE NO GAS WAS GETTING TO THE ENGINE. BEING STUCK IN THE MIDDLE OF TRAFFIC, I WAS PUSHED BY THE CAR BEHIND ME TO A SAFE LOCATION OUT OF TRAFFIC. TOWED CAR TO SHOP AND STILL INVESTIGATING THE FAILURE. *TR
NHTSA ODI #10572870
131,244 miles · Dec 31, 2012
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO A MECHANIC FOR INSPECTION WHERE THEY ADVISED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE DEALER THREE TIMES BUT THEY …
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT HE TOOK THE VEHICLE TO A MECHANIC FOR INSPECTION WHERE THEY ADVISED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE DEALER THREE TIMES BUT THEY DID NOT COMPLETE THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 9/4/13 *CN
NHTSA ODI #10490593
Mileage unknown · Apr 12, 2012
Engine And Engine CoolingFuel System, Gasoline
WHEN I FILL MY TANK UP ALL THE WAY MY GASOLINE ONLY LASTS ABOUT 150 MILES. THE GAS HAS GOT TO BE LEAKING SOMEWHERE!!! I HAVE TO FILL MY TANK UP SEVERAL TIMES A WEEK. *TR
NHTSA ODI #10455001
71,000 miles · Jan 11, 2012
Fuel System, Gasoline
STRONG FUEL ODOR WITHIN CABIN AFTER FUEL FILLUP, THERE IS A RECALL ON FUEL PUMPS DUE TO FIRE RISK ON THIS EXACT MODEL, JUST NOT ON MY VEHICLE. SHOULD I WAIT FOR A FIRE BEFORE A RECALL IS ISSUED? *TR
NHTSA ODI #10443420
93,834 miles · Aug 9, 2011
Electrical SystemFuel System, Gasoline
I'D LIKE TO ADD MY COMPLAINT TO THE LIST OF THOSE ALREADY REPORTING THE ABRUPT LOSS OF ALL ELECTRONICS, INCLUDING WINDSHIELD WIPERS AND ALL DASHBOARD GAUGES, DURING A RAINSTORM. MY ISSUE WAS ALSO IDENTIFIED AS A PREMATURELY CORRODED CENTRAL ELECTRONIC MODULE (CEM) CAUSED BY A DESIGN FLAW ALLOWING WATER TO ACCESS THE CEM CONNECT…
Read full complaint
I'D LIKE TO ADD MY COMPLAINT TO THE LIST OF THOSE ALREADY REPORTING THE ABRUPT LOSS OF ALL ELECTRONICS, INCLUDING WINDSHIELD WIPERS AND ALL DASHBOARD GAUGES, DURING A RAINSTORM. MY ISSUE WAS ALSO IDENTIFIED AS A PREMATURELY CORRODED CENTRAL ELECTRONIC MODULE (CEM) CAUSED BY A DESIGN FLAW ALLOWING WATER TO ACCESS THE CEM CONNECTOR. I'M SHOCKED TO FIND OUT VOLVO KNEW ABOUT THIS IN 2005, WELL WITHIN THE WARRANTY PERIOD FOR MOST OF THESE AFFECTED VEHICLES, AND DID NOTHING TO CORRECT OR EVEN ALERT THEIR OWNERS. I URGE THE NHTSA TO REVISIT THEIR INVESTIGATION, AND FORCE A RECALL IF VOLVO CONTINUES TO REFUSE. I CAN ASSURE YOU AS A DRIVER DURING THIS EVENT, THIS IS INDEED A SAFETY ISSUE, AND I HOPE WE AREN'T WAITING FOR ENOUGH INJURIES OR DEATHS BEFORE YOU GET TO THAT OBVIOUS CONCLUSION.
NHTSA ODI #10418848
50,000 miles · Apr 29, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE BEGAN TO JERK EXCESSIVELY WITH A SUBSTANTIAL LOSS OF ENGINE POWER. THE CONTACT WAS ABLE TO MANEUVER TO THE SIDE OF THE ROAD AS THE ENGINE STALLED. IN ADDITION, THE CONTACT NOTICED A STRONG ODOR OF FUEL BOTH INSIDE AND OUTSIDE OF THE VEHICLE. …
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE BEGAN TO JERK EXCESSIVELY WITH A SUBSTANTIAL LOSS OF ENGINE POWER. THE CONTACT WAS ABLE TO MANEUVER TO THE SIDE OF THE ROAD AS THE ENGINE STALLED. IN ADDITION, THE CONTACT NOTICED A STRONG ODOR OF FUEL BOTH INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FUEL PUMP WAS REPLACED. THE SIMILAR FAILURE RECURRED AND THE FUEL PUMP WAS REPLACED THREE DIFFERENT TIMES. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE CONTACT EXPERIENCED THE IDENTICAL FAILURE AS MENTIONED IN THE RECALL YET THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10398294
64,000 miles · Jan 27, 2011
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE FUEL TANK WHEN HE WAS DRIVING 25 MPH. THE CONTACT REFERENCED RECALL 09V483000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP) BUT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 64,000.
NHTSA ODI #10379327
105,000 miles · Mar 10, 2010
Fuel System, Gasoline
MY CAR STALLS WHILE DRIVING. WHEN CHECKED OUT BY DEALERSHIP THEY IDENTIFIED PROBLEMS WITH THE FUEL PUMP. ON YOUR WEB SITE THERE IS A RECALL FOR 2005 VOLVO XC90, WHICH MY CAR. HOWEVER, VOLVO IS DECLINING MY REQUEST TO FIX THE FUEL PUMP. *TR
NHTSA ODI #10318392
30,200 miles · Feb 17, 2008
Fuel System, Gasoline
CAR STALLED TWICE AT 65MPH WHILE ON FREEWAY. FIRST INCIDENT WAS 24NOV06, 2ND INCIDENT WAS 12 FEB 07. ON FIRST INCIDENT ALL CAR FUNCTIONS COMPLETELY DIED AND WENT INTO "LIMP MODE" AFTER SWERVING TO STOP, AND WAS TOWED TO BELLINGHAM WA (KING VOLVO) DEALER FOR "SOFTWARE UPGRADE ON FUEL PUMP". ON 2ND INCIDENT CAR WENT INTO "REDUCED…
Read full complaint
CAR STALLED TWICE AT 65MPH WHILE ON FREEWAY. FIRST INCIDENT WAS 24NOV06, 2ND INCIDENT WAS 12 FEB 07. ON FIRST INCIDENT ALL CAR FUNCTIONS COMPLETELY DIED AND WENT INTO "LIMP MODE" AFTER SWERVING TO STOP, AND WAS TOWED TO BELLINGHAM WA (KING VOLVO) DEALER FOR "SOFTWARE UPGRADE ON FUEL PUMP". ON 2ND INCIDENT CAR WENT INTO "REDUCED ENGINE PERFORMANCE" AFTER RESTART. I DROVE THE CAR HOME 350MILES ALTHOUGH VOLVO SUGGESTED TOWING. I JUST TRADED THE CAR IN TODAY ON AN ACURA AS VOLVO WASN'T INTERESTED IN HELPING ME BEYOND A $3K INCENTIVE TOWARDS A NEW VOLVO. *TR
NHTSA ODI #10218274
Official recalls
6Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 25, 2007
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
Consequence & remedy
Consequence: MISPLACEMENT OF THE JACK'S CRANK HANDLE CAN POSE A SAFETY RISK AS IT CAN RESULT IN A SHORT CIRCUIT OF THE BATTERY WHICH COULD THEN LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Nov 17, 2005
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequence & remedy
Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE10025 · Central Electronic Module Failure
Opened Jul 20, 2010 · Closed Nov 22, 2010
Status: closed (inferred from source dates) · Electrical System
Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.
EA06006 · Volvo XC90 Battery Cable Failures
Opened Mar 21, 2006 · Closed Jun 14, 2007
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Electrical SYSTEM:12V/24V/48V Battery:cables
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Electrical SYSTEM:12V/24V/48V Battery
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05064 · Windshield Wiper Arm Performance
Opened Dec 2, 2005 · Closed May 10, 2006
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.
PE05057 · Volvo XC90 Battery Cable Failures
Opened Nov 2, 2005 · Closed Mar 23, 2006
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:starter Assembly; Electrical System:wiring; Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Additional source detail variants (4)
Electrical SYSTEM:12V/24V/48V Battery:cables
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:starter Assembly
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Illustration