NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
25 reportsClear category filter107,000 miles · Apr 8, 2013
EngineExterior Lighting
I PURCHASED A 2005 VOLVO XC90 FOR $16,000. 6 MONTHS LATER THE ENGINE FREEZES UP. THAT COST $10,000.00 TO REPLACE THE ENGINE. LOOKED ON GOOGLE, VERY COMMON FOR THESE V8 ENGINES TO FREEZE UP. NOW THE HEADLIGHTS ARE ACTING UP. LOOKED ON GOOGLE AND FOUND THE HEADLIGHT ISSUE IS VERY COMMON. THIS WILL COST $3,000.00 TO REPAIR. THIS C…
Read full complaint
I PURCHASED A 2005 VOLVO XC90 FOR $16,000. 6 MONTHS LATER THE ENGINE FREEZES UP. THAT COST $10,000.00 TO REPLACE THE ENGINE. LOOKED ON GOOGLE, VERY COMMON FOR THESE V8 ENGINES TO FREEZE UP. NOW THE HEADLIGHTS ARE ACTING UP. LOOKED ON GOOGLE AND FOUND THE HEADLIGHT ISSUE IS VERY COMMON. THIS WILL COST $3,000.00 TO REPAIR. THIS CAR IS GOING TO COST ME ALMOST AS MUCH TO REPAIR IT AS I PAID FOR IT!! VOLVO IS LOOSING CONTROL. I WOULD LIKE YOU TO ISSUE A RECALL FOR THESE ENGINE ISSUES AND ISSUE A RECALL FOR THESE HEADLIGHT ISSUES. PLEASE GOOGLE 2005 VOLVO XC90 V8 ENGINE AND GOOGLE THE SAME YEAR AND MODEL ABOUT THE HEADLIGHT ISSUE. YOU WILL BE ASTOUNDED BY ALL THE PAGES OF COMPLAINTS ABOUT WHAT IS SUPPOSED TO BE A GREAT CAR. THESE CARS WHERE $62,000.00 BRAND NEW, WHAT A JOKE THEY CAN SELL THIS CAR WITH SO MANY PROBLEMS. PLEASE ISSUE A RECALL. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10505600
103,000 miles · Jan 2, 2013
Electrical SystemExterior LightingCrash
DRIVING IN PITCH BLACK NIGHT ON BACKROADS OF CHARLESTON, SC. LIGHTS WENT OUT AFTER LEFT HEADLIGHT FLICKERED FOR A FEW DAYS. LIGHTS WENT OUT AND CAR WENT OFF ROAD AS WE WERE IN A CURVE. REGAINED CONTROL AFTER SPINNING ON WET GRASS. I NEED THE HEADLIGHTS REPAIRED BY VOLVO AT THEIR EXPENSE AND REIMBURSEMENT FOR THE FAILED ENGINE I …
Read full complaint
DRIVING IN PITCH BLACK NIGHT ON BACKROADS OF CHARLESTON, SC. LIGHTS WENT OUT AFTER LEFT HEADLIGHT FLICKERED FOR A FEW DAYS. LIGHTS WENT OUT AND CAR WENT OFF ROAD AS WE WERE IN A CURVE. REGAINED CONTROL AFTER SPINNING ON WET GRASS. I NEED THE HEADLIGHTS REPAIRED BY VOLVO AT THEIR EXPENSE AND REIMBURSEMENT FOR THE FAILED ENGINE I HAD TO REPLACE. *TR
NHTSA ODI #10490743
110,550 miles · Nov 7, 2012
Exterior Lighting
THE LEFT HEADLIGHT WILL SUDDENLY GO OUT, SOMETIMES WHILE DRIVING AND OTHER TIMES THE HEADLIGHT WILL NOT LIGHT WHEN THE VEHICLE IS STARTED. AT TIMES IT REMAINED OFF FOR ONLY A FEW MINUTES AND OTHER TIMES IT WILL BE FOR DAYS. I'D TAKEN THE VEHICLE IN FOR SERVICE, BUT EACH TIME I DID, THE LEFT HEADLAMP WAS AGAIN WORKING. I'D ALS…
Read full complaint
THE LEFT HEADLIGHT WILL SUDDENLY GO OUT, SOMETIMES WHILE DRIVING AND OTHER TIMES THE HEADLIGHT WILL NOT LIGHT WHEN THE VEHICLE IS STARTED. AT TIMES IT REMAINED OFF FOR ONLY A FEW MINUTES AND OTHER TIMES IT WILL BE FOR DAYS. I'D TAKEN THE VEHICLE IN FOR SERVICE, BUT EACH TIME I DID, THE LEFT HEADLAMP WAS AGAIN WORKING. I'D ALSO REPLACED THE HEADLAMP IN QUESTION, BUT STILL THE HEADLAMP WORKED ONLY INTERMITTENTLY. I JUST RETURNED FROM MY 4TH VISIT TO THE DEALER, AT WHICH TIME THEY REPLACED THE LEFT FRONT LIGHT BALLAST ($440.00). THE HEADLAMP IS CURRENTLY WORKING. MY WIFE HAS BEEN RELUCTANT TO DRIVE THE VEHICLE AT NIGHT, FOR FEAR THAT BOTH HEADLAMPS WOULD GO OUT. IN RESEARCHING ONLINE, I'M FINDING THAT THIS HAS BEEN A RECURRENT PROBLEM WITH 2004 AND 2005 VOLVO XC-90'S. I UNDERSTAND THAT THE NHTSA HAS BEEN INVESTIGATING THIS PROBLEM WITH THE VOLVO XC-90 AND A RECALL IS BEING CONSIDERED. WE PURCHASED THE VEHICLE PRIMARILY DUE TO IT'S 5-STAR SAFETY RATING, BUT WE ARE NOT CONVINCED THAT VOLVO HAS ADEQUATELY ADDRESSED A KNOWN PROBLEM. *TR
NHTSA ODI #10483622
88,000 miles · Aug 21, 2012
EngineExterior Lighting
TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED WITHOUT ANY WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT AUTO SHOP FOR DIAGNOSIS. THE TECHNICIAN STATED THE COUNTER BALANCE SHAFT BEARING WAS FROZEN AND THE ENGINE NEEDED TO BE REPLACED…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED WITHOUT ANY WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT AUTO SHOP FOR DIAGNOSIS. THE TECHNICIAN STATED THE COUNTER BALANCE SHAFT BEARING WAS FROZEN AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, THE HEADLIGHTS WOULD INTERMITTENTLY OPERATE AND HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. UPDATED 10/3/12 *CN UPDATED 10/09/2012 *JS
NHTSA ODI #10471742
90,000 miles · Sep 2, 2011
Electrical SystemExterior Lighting
A COMPLAINT WAS PREVIOUS FILED REGARDING TO TURN SIGNAL PROBLEM. SITUATION GETTING WORSE. VOLVO XC90 V8 2005; REPLACED CEM UNIT TWO YEARS BACK. RECENTLY FOLLOWING PROBLEMS HAPPENED. 1. TURN SIGNAL STOP WORKING 2. NO HIGH BEAM 3. NO WINDSHIELD WASHING 4. NO CRUISE CONTROL 5. NO VEHICLE INFORMATION FUNCTION PROBLEMS LOO…
Read full complaint
A COMPLAINT WAS PREVIOUS FILED REGARDING TO TURN SIGNAL PROBLEM. SITUATION GETTING WORSE. VOLVO XC90 V8 2005; REPLACED CEM UNIT TWO YEARS BACK. RECENTLY FOLLOWING PROBLEMS HAPPENED. 1. TURN SIGNAL STOP WORKING 2. NO HIGH BEAM 3. NO WINDSHIELD WASHING 4. NO CRUISE CONTROL 5. NO VEHICLE INFORMATION FUNCTION PROBLEMS LOOK LIKE ASSOCIATED WITH FAULTY CEM AGAIN. VEHICLE IS VERY RISKY TO DRIVE WITH UNRELIABLE OR NOT-FUNCTIONING TURN SIGNAL. *TR
NHTSA ODI #10423007
85,000 miles · Aug 26, 2011
Exterior Lighting
VOLVO XC90 2005, TURNING SIGNAL ACTS DANGEROUSLY. SOMETIMES IT WORKS BUT MOST TIME NO ACTION HAPPENS. COMPLETELY DEAD AND RESTARTING CAR SOMETIMES FIX THE PROBLEM. MULTIPLE CASES OF DANGEROUS INCIDENTS DUE TO NO SIGNAL. *TT
NHTSA ODI #10421666
75,000 miles · Aug 21, 2011
Electrical SystemExterior Lighting
VOLVO XC90 2005 LOW BEAM BULB FAILURE ERROR AND ONE BEAM TURNS OFF. THEN COMES BACK ON, AND SOMETIMES ALL LIGHTS GO OFF. VERY DANGEROUS AT NIGHT. IF YOU TURN THE HEADLIGHT DIAL TO ANOTHER SETTING THEY WILL COME BACK ON, BUT THEN BLINK OFF AGAIN, AND SOMETIMES OFF COMPLETELY. THE BIGGEST ISSUE IS THE INTERMITTENT OCCURRENCE …
Read full complaint
VOLVO XC90 2005 LOW BEAM BULB FAILURE ERROR AND ONE BEAM TURNS OFF. THEN COMES BACK ON, AND SOMETIMES ALL LIGHTS GO OFF. VERY DANGEROUS AT NIGHT. IF YOU TURN THE HEADLIGHT DIAL TO ANOTHER SETTING THEY WILL COME BACK ON, BUT THEN BLINK OFF AGAIN, AND SOMETIMES OFF COMPLETELY. THE BIGGEST ISSUE IS THE INTERMITTENT OCCURRENCE OF THIS. THE CAR IS NOT SAFE TO DRIVE. *TR
NHTSA ODI #10420879
42,000 miles · Jun 9, 2011
Electrical SystemExterior Lighting
1. NORMAL CITY/HIGHWAY DRIVING. 2. TURN SIGNALS SPORADICALLY DO NOT FUNCTION. AMBIENT TEMPERATURE DOES NOT MATTER, WHETHER IN WINTER OR SUMMER. 3. NOTHING WAS DONE TO CORRECT. *TR
NHTSA ODI #10405718
61,000 miles · Feb 21, 2011
Electrical SystemExterior Lighting
WHILE DRIVING ON THE HIGHWAY IN RAIN, THE HEADLIGHTS OF THE CAR BEGAN FLASHING ON AND OFF (SOMETIMES DRIVERS SIDE, SOMETIMES PASSENGER SIDE, SOMETIMES BOTH) INTERMITTENTLY. I PULLED OVER AND TURNED OFF AND RESTARTED CAR. THIS SOLVED THE PROBLEM FOR A FEW MILES, THEN IT DID IT AGAIN. NOW, THE RIGHT LIGHT IS OUT COMPLETELY, BUT…
Read full complaint
WHILE DRIVING ON THE HIGHWAY IN RAIN, THE HEADLIGHTS OF THE CAR BEGAN FLASHING ON AND OFF (SOMETIMES DRIVERS SIDE, SOMETIMES PASSENGER SIDE, SOMETIMES BOTH) INTERMITTENTLY. I PULLED OVER AND TURNED OFF AND RESTARTED CAR. THIS SOLVED THE PROBLEM FOR A FEW MILES, THEN IT DID IT AGAIN. NOW, THE RIGHT LIGHT IS OUT COMPLETELY, BUT AT LEAST THE LEFT SEEMS TO BE STAYING ON. THIS EXACT SAME THING HAPPENED ONE OTHER TIME. THE DEALERSHIP CLAIMED THEY COULD FIND NOTHING WRONG WITH THE VEHICLE. *TR
NHTSA ODI #10383884
70,000 miles · Nov 29, 2010
Exterior Lighting
TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SIDE HEADLIGHT WOULD SHUT OFF INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A DEALER WHERE THE CONTACT WAS INFORMED THAT THEY WOULD HAVE TO REPLACE THE CEM UNIT. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS AP…
Read full complaint
TL*THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SIDE HEADLIGHT WOULD SHUT OFF INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A DEALER WHERE THE CONTACT WAS INFORMED THAT THEY WOULD HAVE TO REPLACE THE CEM UNIT. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.
NHTSA ODI #10368105
Official recalls
6Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 25, 2007
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
Consequence & remedy
Consequence: MISPLACEMENT OF THE JACK'S CRANK HANDLE CAN POSE A SAFETY RISK AS IT CAN RESULT IN A SHORT CIRCUIT OF THE BATTERY WHICH COULD THEN LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Nov 17, 2005
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequence & remedy
Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE10025 · Central Electronic Module Failure
Opened Jul 20, 2010 · Closed Nov 22, 2010
Status: closed (inferred from source dates) · Electrical System
Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.
EA06006 · Volvo XC90 Battery Cable Failures
Opened Mar 21, 2006 · Closed Jun 14, 2007
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Electrical SYSTEM:12V/24V/48V Battery:cables
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Electrical SYSTEM:12V/24V/48V Battery
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05064 · Windshield Wiper Arm Performance
Opened Dec 2, 2005 · Closed May 10, 2006
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.
PE05057 · Volvo XC90 Battery Cable Failures
Opened Nov 2, 2005 · Closed Mar 23, 2006
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:starter Assembly; Electrical System:wiring; Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Additional source detail variants (4)
Electrical SYSTEM:12V/24V/48V Battery:cables
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:starter Assembly
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Illustration