NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
51 reportsClear category filter75,000 miles · Aug 21, 2011
Electrical SystemExterior Lighting
VOLVO XC90 2005 LOW BEAM BULB FAILURE ERROR AND ONE BEAM TURNS OFF. THEN COMES BACK ON, AND SOMETIMES ALL LIGHTS GO OFF. VERY DANGEROUS AT NIGHT. IF YOU TURN THE HEADLIGHT DIAL TO ANOTHER SETTING THEY WILL COME BACK ON, BUT THEN BLINK OFF AGAIN, AND SOMETIMES OFF COMPLETELY. THE BIGGEST ISSUE IS THE INTERMITTENT OCCURRENCE …
Read full complaint
VOLVO XC90 2005 LOW BEAM BULB FAILURE ERROR AND ONE BEAM TURNS OFF. THEN COMES BACK ON, AND SOMETIMES ALL LIGHTS GO OFF. VERY DANGEROUS AT NIGHT. IF YOU TURN THE HEADLIGHT DIAL TO ANOTHER SETTING THEY WILL COME BACK ON, BUT THEN BLINK OFF AGAIN, AND SOMETIMES OFF COMPLETELY. THE BIGGEST ISSUE IS THE INTERMITTENT OCCURRENCE OF THIS. THE CAR IS NOT SAFE TO DRIVE. *TR
NHTSA ODI #10420879
60,800 miles · Aug 18, 2011
Electrical SystemEngine And Engine Cooling
PURCHASED USED 2005 VOLVO XC90 IN SPRING OF 2010. DURING THE NEXT YEAR EXPERIENCED VERY INTERMITTENT ELECTRICAL ISSUES. EXAMPLES ARE LOCKS NOT WORKING, BLINKER, RADIO. THESE ISSUES LITERALLY ONLY HAPPENED A COUPLE TIMES. IN APRIL 2011 HAD BIYEARLY SAFETY AND EMISSIONS DONE AT LOCAL DEALERSHIP (NON VOLVO) AND IT DID NOT PASS EM…
Read full complaint
PURCHASED USED 2005 VOLVO XC90 IN SPRING OF 2010. DURING THE NEXT YEAR EXPERIENCED VERY INTERMITTENT ELECTRICAL ISSUES. EXAMPLES ARE LOCKS NOT WORKING, BLINKER, RADIO. THESE ISSUES LITERALLY ONLY HAPPENED A COUPLE TIMES. IN APRIL 2011 HAD BIYEARLY SAFETY AND EMISSIONS DONE AT LOCAL DEALERSHIP (NON VOLVO) AND IT DID NOT PASS EMISSIONS. NEXT DAY TOOK MY VOLVO XC90 TO WEISS VOLVO AND IT PASSED EMISSIONS (WITHOUT ME KNOWING THEY CLEARED ERRORS ON THE CAR TO GET IT TO PASS. THIS MUST BE THE REASON IN EUROPE THAT DEALERSHIPS CAN'T INSPECT THEIR OWN MAKE OF CARS) ON JULY 17 2011 I WAS DRIVING DOWN THE HIGHWAY WITH MY 1 YEAR OLD IN THE BACK SEAT. RADIO WENT OUT. A FEW MINUTES LATER ALMOST EVERYTHING IN THE CAR SHUT DOWN EXCEPT FOR THE ENGINE. LOST A/C (IT WAS 110 THAT DAY), LOST POWER STEERING, BRAKING WAS INTERMITTENT, NO BLINKERS, NO HEADLIGHTS, NO LIGHTS IN INTERIOR, WHILE I WAS AT FULL SPEED ON THE HIGHWAY. I AM NOT SURE IF ENGINE WAS INTERMITTENT OR NOT BECAUSE I GOT OFF AS SOON AS I COULD. I WAS VERY CLOSE TO WEISS VOLVO SO DROPPED IT OFF THERE AGAIN ON THE DATE OF THE TOTAL FAILURE. CALLED VOLVO CUSTOMER CARE ON JULY 18 2011 TO FILE COMPLAINT. WEISS VOLVO CALLED BACK AND TOLD US CAR WOULDN'T START. CALLED BACK LATER IN THE DAY AND SAID THEY SAW THAT EVERYTHING WENT OUT AND CAR WAS FULL OF CODES. WEISS SENT IN AN ESTIMATE FOR $1500 TO REPLACE ECM. I ASKED WEISS TO PERFORM AN EMISSIONS TEST (BY MO LAW MANUFACTURER'S CARS MUST PASS EMISSIONS TEST UP TO 80K MILES AND MY CAR HAD 61K) I RESEARCHED ECM AND FOUND VERY SIMILAR STORIES TO MINE AND BROUGHT THIS UP TO VOLVO NA. VOLVO NA TOLD WEISS VOLVO TO "RESET" MY CAR (AGAIN WITHOUT MY PERMISSION). THE CAR THEN WAS FUNCTIONAL AFTER RESET. WEISS THEN "TESTED" MY CAR FOR ALMOST 3 WEEKS TO FIGURE OUT THE DESIGN FLAW FOR A TOTAL OF 451 MILES. THE MECHANIC TOLD ME IT WAS THE ECM BUT VOLVO NA SAID IT WAS VARIOUS OTHER REASONS AND WOULDN'T REPLACE IT. CAR STILL BROKE. REACHED LIMIT. *KB
NHTSA ODI #10419955
93,834 miles · Aug 9, 2011
Electrical SystemFuel System, Gasoline
I'D LIKE TO ADD MY COMPLAINT TO THE LIST OF THOSE ALREADY REPORTING THE ABRUPT LOSS OF ALL ELECTRONICS, INCLUDING WINDSHIELD WIPERS AND ALL DASHBOARD GAUGES, DURING A RAINSTORM. MY ISSUE WAS ALSO IDENTIFIED AS A PREMATURELY CORRODED CENTRAL ELECTRONIC MODULE (CEM) CAUSED BY A DESIGN FLAW ALLOWING WATER TO ACCESS THE CEM CONNECT…
Read full complaint
I'D LIKE TO ADD MY COMPLAINT TO THE LIST OF THOSE ALREADY REPORTING THE ABRUPT LOSS OF ALL ELECTRONICS, INCLUDING WINDSHIELD WIPERS AND ALL DASHBOARD GAUGES, DURING A RAINSTORM. MY ISSUE WAS ALSO IDENTIFIED AS A PREMATURELY CORRODED CENTRAL ELECTRONIC MODULE (CEM) CAUSED BY A DESIGN FLAW ALLOWING WATER TO ACCESS THE CEM CONNECTOR. I'M SHOCKED TO FIND OUT VOLVO KNEW ABOUT THIS IN 2005, WELL WITHIN THE WARRANTY PERIOD FOR MOST OF THESE AFFECTED VEHICLES, AND DID NOTHING TO CORRECT OR EVEN ALERT THEIR OWNERS. I URGE THE NHTSA TO REVISIT THEIR INVESTIGATION, AND FORCE A RECALL IF VOLVO CONTINUES TO REFUSE. I CAN ASSURE YOU AS A DRIVER DURING THIS EVENT, THIS IS INDEED A SAFETY ISSUE, AND I HOPE WE AREN'T WAITING FOR ENOUGH INJURIES OR DEATHS BEFORE YOU GET TO THAT OBVIOUS CONCLUSION.
NHTSA ODI #10418848
130,000 miles · Aug 5, 2011
Electrical System
BRAKES LIGHTS ALWAYS ON. TOOK CAR TO DEALER AND THEY ADVISED THAT WATER HAD LEAKED INTO CEM MODULE AND MAIN WIREHARNESS AND REQUIRED REPLACEMNET AT A COST OF $7000. KNOWN ISSUE TO VOLVO WITH SERVICE BULLETIN SENT TO DEALERS. FOUND INDEPENDENT VOLVO REPAIR SHOP WILLING TO REPLACE MODULE ONLY (SOFTWARE DOWNLOAD FROM DEALER) AND …
Read full complaint
BRAKES LIGHTS ALWAYS ON. TOOK CAR TO DEALER AND THEY ADVISED THAT WATER HAD LEAKED INTO CEM MODULE AND MAIN WIREHARNESS AND REQUIRED REPLACEMNET AT A COST OF $7000. KNOWN ISSUE TO VOLVO WITH SERVICE BULLETIN SENT TO DEALERS. FOUND INDEPENDENT VOLVO REPAIR SHOP WILLING TO REPLACE MODULE ONLY (SOFTWARE DOWNLOAD FROM DEALER) AND CLEAN BUILD-UP ON HARNESS CONNECTORS. REQUIRING REMOVAL OF PART OF DASH, DRIVER SEAT. TOOK 4 DAYS AT REPAIR SHOP. REPAIR COMPLETED FOR UNDER $2000. *TT
NHTSA ODI #10417710
130,000 miles · Jun 9, 2011
Electrical System
DURING RAIN THE WINDSHIELD WIPERS STOP WORKING, HEADLIGHTS GO OUT AND CAR LOSES POWER. I HAVE COME DANGEROUSLY CLOSE TO HIGH SPEED ACCIDENTS DUE TO THE LOSS OF POWER. ALSO CAR HAS A SEVERE JERK IN THE TRANSMISSION WHEN ACCELERATING AFTER A TURN. SO STRONG I THOUGHT I WAS HIT FROM BEHIND. THERE IS A PROBLEM NHTSA INVESTIGATED WIT…
Read full complaint
DURING RAIN THE WINDSHIELD WIPERS STOP WORKING, HEADLIGHTS GO OUT AND CAR LOSES POWER. I HAVE COME DANGEROUSLY CLOSE TO HIGH SPEED ACCIDENTS DUE TO THE LOSS OF POWER. ALSO CAR HAS A SEVERE JERK IN THE TRANSMISSION WHEN ACCELERATING AFTER A TURN. SO STRONG I THOUGHT I WAS HIT FROM BEHIND. THERE IS A PROBLEM NHTSA INVESTIGATED WITH WATER GETTING INTO THE CEM. VOLVO ACKNOWLEDGED MANUFACTURER DEFECT THAT RESULTS IN WATER GETTING IN CEM BUT WILL NOT REPLACE THE DEFECTIVE COVER. THERE IS NO WAY OF KNOWING WHEN THIS MIGHT HAPPENS-APPEARS TO DEPEND ON HOW HEAVY THE RAIN, IF ROADWAY HAS A LOT OF WATER. THIS NEEDS TO BE RECALLED FOR SAFETY REASONS-VOLVO CONTINUES TO PUT CONSUMERS AT RISK. *TR
NHTSA ODI #10405733
42,000 miles · Jun 9, 2011
Electrical SystemExterior Lighting
1. NORMAL CITY/HIGHWAY DRIVING. 2. TURN SIGNALS SPORADICALLY DO NOT FUNCTION. AMBIENT TEMPERATURE DOES NOT MATTER, WHETHER IN WINTER OR SUMMER. 3. NOTHING WAS DONE TO CORRECT. *TR
NHTSA ODI #10405718
70,000 miles · May 12, 2011
Electrical System
2005 VOLVO XC90 V8 AWD-NUMEROUS ELECTRICAL ISSUES SINCE PURCHASING VEHICLE FROM A LOCAL DEALER IN UPSTATE NY IN 2010. ODD PROBLEMS SUCH AS HEADLIGHTS FAILING, POWER WINDOWS OPENING AND "ANTI" THEFT FEATURES (KEY LOCK) BEING ACTIVATED FOR UNKNOWN REASON-THE VEHICLE REQUIRED A BALANCE SHAFT REPLACEMENT AT ABOUT 70K MILES (I BELIE…
Read full complaint
2005 VOLVO XC90 V8 AWD-NUMEROUS ELECTRICAL ISSUES SINCE PURCHASING VEHICLE FROM A LOCAL DEALER IN UPSTATE NY IN 2010. ODD PROBLEMS SUCH AS HEADLIGHTS FAILING, POWER WINDOWS OPENING AND "ANTI" THEFT FEATURES (KEY LOCK) BEING ACTIVATED FOR UNKNOWN REASON-THE VEHICLE REQUIRED A BALANCE SHAFT REPLACEMENT AT ABOUT 70K MILES (I BELIEVE IT HAD 65K MILES WHEN I PURCHASED IT) WHICH APPARENTLY WAS DUE TO MANUFACTURER NOT HAVING DRIP HOLES IN ENGINE COMPARTMENT. I BELIEVE THE ELECTRICAL ISSUES ARE SOMEWHAT RELATED TO THAT PROBLEM IN THAT WATER SEEMS TO BE A PROBLEM FOR THIS VEHICLE. THE ODD ELECTRICAL ISSUES DON'T ALWAYS HAPPEN WHEN ITS RAINING BUT MOISTURE APPEARS TO BE A FACTOR. LATEST ISSUE WAS A LOCKED SHIFTER IN THE PARK POSITION-CAR WOULD START BUT COULD NOT PUT INTO ANY GEAR-TOWED TO DEALER AND THEY REPLACED THE CEM (CENTRAL ELECTRONICS MODULE) FOR $2300.00. I MADE THEM GIVE ME THE DEFECTIVE MODULE SO HAVE IT IF YOU WOULD LIKE TO EXAMINE IT EXAMINE IT. LUCKILY, I ONLY HAD ONE DANGEROUS ISSUE AND THAT IS WHEN THE HEADLIGHTS FAILED DURING A DARK/RAINY NIGHT. TOO EARLY TO TELL IF THE CEM FIXES THE PROBLEM AS JUST HAD IT FIXED TODAY 5/13/2011. STARTED RESEARCHING WHY THIS WOULD BE AN ISSUE AND THAT'S WHEN I STARTED READING OTHER VOLVO DRIVERS EXPERIENCES THAT SEEMED QUITE SIMILAR TO MINE. I NEVER HAD COMPLETE VEHICLE FAILURE BUT LOSING THE HEADLIGHTS WAS NOT FUN...I THINK VOLVO KNOWS EXACTLY WHAT THE ISSUE AS THEY DIDN'T HESITATE IN INSTALLING THE CEM...I AM LISTING THE SPECIFIC DATE THAT THE HEADLIGHTS FAILED BELOW-THEY FAILED SEVERAL OTHER TIMES BUT CANT RECALL THE SPECIFIC DATES. *TR
NHTSA ODI #10400706
49,700 miles · Mar 24, 2011
Electrical SystemVisibility
TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 40 MPH IN RAINY WEATHER, THE DRIVER ATTEMPTED TO TURN ON THE WINDSHIELD WIPERS BUT THEY WOULD NOT ENGAGE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE CENTRAL ELECTRONIC MODULE WOULD NEED TO BE REPLACED BECAUSE RAIN WAS SEEPI…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO XC90. WHILE DRIVING APPROXIMATELY 40 MPH IN RAINY WEATHER, THE DRIVER ATTEMPTED TO TURN ON THE WINDSHIELD WIPERS BUT THEY WOULD NOT ENGAGE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE CENTRAL ELECTRONIC MODULE WOULD NEED TO BE REPLACED BECAUSE RAIN WAS SEEPING INTO THE CENTRAL ELECTRONIC MODULE. THE VEHICLE WAS REPAIRED. UPDATED 05/05/11*LJ UPDATED 05/13/11
NHTSA ODI #10392720
61,000 miles · Feb 21, 2011
Electrical SystemExterior Lighting
WHILE DRIVING ON THE HIGHWAY IN RAIN, THE HEADLIGHTS OF THE CAR BEGAN FLASHING ON AND OFF (SOMETIMES DRIVERS SIDE, SOMETIMES PASSENGER SIDE, SOMETIMES BOTH) INTERMITTENTLY. I PULLED OVER AND TURNED OFF AND RESTARTED CAR. THIS SOLVED THE PROBLEM FOR A FEW MILES, THEN IT DID IT AGAIN. NOW, THE RIGHT LIGHT IS OUT COMPLETELY, BUT…
Read full complaint
WHILE DRIVING ON THE HIGHWAY IN RAIN, THE HEADLIGHTS OF THE CAR BEGAN FLASHING ON AND OFF (SOMETIMES DRIVERS SIDE, SOMETIMES PASSENGER SIDE, SOMETIMES BOTH) INTERMITTENTLY. I PULLED OVER AND TURNED OFF AND RESTARTED CAR. THIS SOLVED THE PROBLEM FOR A FEW MILES, THEN IT DID IT AGAIN. NOW, THE RIGHT LIGHT IS OUT COMPLETELY, BUT AT LEAST THE LEFT SEEMS TO BE STAYING ON. THIS EXACT SAME THING HAPPENED ONE OTHER TIME. THE DEALERSHIP CLAIMED THEY COULD FIND NOTHING WRONG WITH THE VEHICLE. *TR
NHTSA ODI #10383884
131,000 miles · Jan 31, 2011
Electrical SystemEngine And Engine CoolingFuel System, Other
2005 XC90 V8-MANY PROBLEMS WITH CHECK ENGINE LIGHT COMING ON AND CAR LOSING POWER. LOST POWER ON INTERSTATE-CAR WOULD LOSE POWER AND SPEED-NEEDED TOW-HAPPENED TWICE. CURRENT ISSUE CHECK ENGINE LIGHT CAME ON FOLLOWED BY ALL LIGHTS COMING ON STATING BRAKE FAILURE, POWER OVERLOAD, LIMP MODE AND BRAKE FAILURE. DEALER REPLACED ALTERN…
Read full complaint
2005 XC90 V8-MANY PROBLEMS WITH CHECK ENGINE LIGHT COMING ON AND CAR LOSING POWER. LOST POWER ON INTERSTATE-CAR WOULD LOSE POWER AND SPEED-NEEDED TOW-HAPPENED TWICE. CURRENT ISSUE CHECK ENGINE LIGHT CAME ON FOLLOWED BY ALL LIGHTS COMING ON STATING BRAKE FAILURE, POWER OVERLOAD, LIMP MODE AND BRAKE FAILURE. DEALER REPLACED ALTERNATOR AT COST OF $1006. 10 DAYS LATER CHECK ENGINE LIGHT AND ANTI SKID LIGHT CAME ON FOLLOWED BY BRAKE FAILURE LIGHT. CAR LOST HEADLIGHTS AND WINDSHIELD WIPERS-9 PM AND SLEETING. DEALER NOW SAYS NEED TO REPLACE CEM AND BATTERY AT A COST OF $3,000 DUE TO WATER IN CEM. IT WAS RAINING OR SLEETING BOTH TIMES THE CHECK ENGINE LIGHT CAME ON. VOLVO REDESIGNED THE COVER TO PREVENT WATER INTRUSION BUT NEEDS TO ISSUE RECALL. VERY DANGEROUS- TICKING TIME BOMB. SOMEONE WILL HAVE AN ACCIDENT ON RAINY NIGHT ON INTERSTATE. PLEASE CONSIDER REQUIRING RECALL-OWNERS OF THIS VEHICLE ARE SPENDING THOUSANDS OF DOLLARS DUE TO VOLVO XC90 V8 DESIGN FLAWS. HOW CAN VOLVO BE ALLOWED TO SELL VEHICLES THAT SHOULD NOT BE DRIVEN OUTSIDE/OR IN THE RAIN. *TR
NHTSA ODI #10379781
Official recalls
6Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 25, 2007
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
Consequence & remedy
Consequence: MISPLACEMENT OF THE JACK'S CRANK HANDLE CAN POSE A SAFETY RISK AS IT CAN RESULT IN A SHORT CIRCUIT OF THE BATTERY WHICH COULD THEN LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
Nov 17, 2005
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequence & remedy
Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE10025 · Central Electronic Module Failure
Opened Jul 20, 2010 · Closed Nov 22, 2010
Status: closed (inferred from source dates) · Electrical System
Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.
EA06006 · Volvo XC90 Battery Cable Failures
Opened Mar 21, 2006 · Closed Jun 14, 2007
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Electrical SYSTEM:12V/24V/48V Battery:cables
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Electrical SYSTEM:12V/24V/48V Battery
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Equipment:mechanical:accessory Scissor/screw/bottle Jack/lift
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05064 · Windshield Wiper Arm Performance
Opened Dec 2, 2005 · Closed May 10, 2006
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.
PE05057 · Volvo XC90 Battery Cable Failures
Opened Nov 2, 2005 · Closed Mar 23, 2006
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:starter Assembly; Electrical System:wiring; Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Additional source detail variants (4)
Electrical SYSTEM:12V/24V/48V Battery:cables
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:starter Assembly
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Illustration