I was getting off the highway and made a left turn. As I was accelerating the motor gentle cut off.. (You wouldnt even notice if you wasnt driving) Full Traffic was behind me, so luckily I was able to get out of the way and pull to shoulder. It was the day before Christmas and car hasn't ran since. Upon investigation I found th…
Read full complaint
I was getting off the highway and made a left turn. As I was accelerating the motor gentle cut off.. (You wouldnt even notice if you wasnt driving) Full Traffic was behind me, so luckily I was able to get out of the way and pull to shoulder. It was the day before Christmas and car hasn't ran since. Upon investigation I found the CEM was effected. When the car died I was in left hand lane and I had to make my way to right, the shoulder. Yes the problem was diagnosed by myself. However I did investigation and researched using all data at library. It has not been inspected by anyone else. There where no warning lamps or messages prior to the failure. It happened all of a sudden in the middle of traffic when I was getting off the highway.
NHTSA ODI #11646424
120,000 miles · May 21, 2018
Air BagsElectronic Stability Control (esc)Fuel/propulsion System
ALL THE VEHICLE LIGHTS WILL COME ON OVER THE DASH AND THE WHEEL LOCKS THEN IT SHUTS OFF WHILE I AM DRIVING. THIS IS SO UNSAFE FOR MY FAMILY. I AM NOT SURE WHY THERE IS NOT A RECALL FOR MY VIN # WHEN GOOGLE CLEARLY STATES THAT THIS IS A HAZARD AND THAT THERE ARE RECALLS FOR THIS PROBLEM.
NHTSA ODI #11097108
102,000 miles · Jan 5, 2014
Air BagsElectrical System
THE CENTRAL ELECTRONIC MODULE (CEM) WILL NOT PERFORM AS INTENDED. AS A RESULT, AUDIO SYSTEM, PARKING ASSIST, AND PASSENGER AIRBAG DOES NOT WORK. AUDIO SYSTEM TURNS ON SPORADICALLY BY ITSELF AND RUNS CONTINUOUSLY(I HAVE TO PULL OVER, TURN THE ENGINE OFF, THEN WAIT 3+ MINUTES TO STOP IT). AS A RESULT, THE FRONT WINDSHIELD WIPE…
Read full complaint
THE CENTRAL ELECTRONIC MODULE (CEM) WILL NOT PERFORM AS INTENDED. AS A RESULT, AUDIO SYSTEM, PARKING ASSIST, AND PASSENGER AIRBAG DOES NOT WORK. AUDIO SYSTEM TURNS ON SPORADICALLY BY ITSELF AND RUNS CONTINUOUSLY(I HAVE TO PULL OVER, TURN THE ENGINE OFF, THEN WAIT 3+ MINUTES TO STOP IT). AS A RESULT, THE FRONT WINDSHIELD WIPERS MIGHT RUN CONTINUOUSLY WHEN THE IGNITION IS ON. ALSO, THE TURN SIGNALS, HIGH BEAMS, AND HEADLIGHT SWITCH MIGHT NOT WORK. THIS ISSUE WAS RECALL 2014 VOLVO S60, S80, XC60 AND XC70. 2005 XC90 BUT IT SHOULD BE INCLUDED IN THIS RECALL BECAUSE MALFUNCTIONING ELECTRONIC SYSTEM (PASSENGER AIRBAGS, HEAD LAMPS, AND/OR TURN SIGNALS) INCREASE THE RISK OF A CRASH. IT'S NOT FAIR, WHEN SAME PROBLEM IS ACCEPTED AS REASON FOR RECALL FOR 2014 MODELS(XC60, S60, S80, XC70) BUT NOT 2005 XC90S. *TR
NHTSA ODI #10558552
Mileage unknown · Nov 14, 2006
Air Bags
DT*: THE CONTACT STATED THE PASSENGER FRONT AIRBAG LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO COULD NOT DUPLICATE THE PROBLEM. THE GENERAL MANAGER SUGGESTED THAT THE CONTACT TAKE THE VEHICLE TO ANOTHER DEALERSHIP FOR SERVICE BECAUSE THE DEALER WAS NOT WILLING TO SERVICE OR FURTHER EXAMINE THE…
Read full complaint
DT*: THE CONTACT STATED THE PASSENGER FRONT AIRBAG LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO COULD NOT DUPLICATE THE PROBLEM. THE GENERAL MANAGER SUGGESTED THAT THE CONTACT TAKE THE VEHICLE TO ANOTHER DEALERSHIP FOR SERVICE BECAUSE THE DEALER WAS NOT WILLING TO SERVICE OR FURTHER EXAMINE THE VEHICLE.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
Consequence & remedy
Consequence: MISPLACEMENT OF THE JACK'S CRANK HANDLE CAN POSE A SAFETY RISK AS IT CAN RESULT IN A SHORT CIRCUIT OF THE BATTERY WHICH COULD THEN LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Consequence & remedy
Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
PE10025 · Central Electronic Module Failure
Opened Jul 20, 2010 · Closed Nov 22, 2010
Status: closed (inferred from source dates) · Electrical System
Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Electrical SYSTEM:12V/24V/48V Battery:cables
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Electrical SYSTEM:12V/24V/48V Battery
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05064 · Windshield Wiper Arm Performance
Opened Dec 2, 2005 · Closed May 10, 2006
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Additional source detail variants (4)
Electrical SYSTEM:12V/24V/48V Battery:cables
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:starter Assembly
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
Electrical System:wiring
THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.
2005 Volvo XC90 Problems, Complaints & Recalls | Skip That Year
Illustration