2022 Volvo XC60

At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.

I received the the recall for the rear backup camera system not working now the whole cars safety system doesn't work. The infotainment screen keeps crashing and showing a dead android on it thus killing the Turn signal noise, climate controls, safety systems blind spot monitoring, adaptive cruise control randomly turns off, rear backup cameras still don't work. Overall this could lead to an accident as the whole cars safety system is not working and it makes me wonder if this could trigger the car to fail while driving if the operating system is malfunction or bad. I have tried to fix the issue with a factory reset but nothing seems to be working.

The contact owns a 2022 Volvo XC60. The contact stated that while driving approximately 45 MPH during nighttime, the Forward Collision Avoidance system engaged while there were no vehicles or objects in front of the vehicle. The contact stated that the failure caused pain in her rib cage when the brake was suddenly applied. Medical attention was not sought. No warning lights were illuminated; however, the message "Front Collision Aversion Engaged" was displayed on the instrument panel. The vehicle was taken back to the residence, and the dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 53,000.

Feb. 1, 2024: A short drive on electric during below zero weather, a car wash & a couple 100ft drive into a parking lot. Pulling into a parking space, foot on the brake pedal, ICE roared on accelerating the car over a curb, down an embankment & into a 3ft snow drift before I could stop it by pressing the brake pedal with both feet. We stopped 6in from a power pole. If forward crash avoidance system worked, didn't register in the EEPROM per the service tech! Feb. 17, 2024, during below zero weather, no electric charge, operating on ICE over about 2mi, Pulled into a parking space, foot on the brake pedal, ICE surged accelerating the car up over a 6" high curb onto sidewalk. Stopped car by depressing the brake pedal with both feet. Car stopped 2in before hitting a brick building. It didn't seem the forward crash avoidance system functioned to stop us. As a 35-year electronic design and repair professional, I have attempted to merge the two situations to try to find similarities. Two things: unexpected ICE engine acceleration surge & forward collision sensor not kicking on brakes. Per Volvo tech, Feb. 1, no register in EEPROM of forward crash avoidance or ICE issues. Second visit Feb. 22 to service will probably yield same. Obviously, this is not normal operation. We have been in two near collisions caused by the car doing things not designed to do.

I have had 5 visits with problems with engine , braking sensors, and automatic braking incidents when no obstruction is noted. Propulsion System failure has occurred 3+ times and turtle mode has come on and limited my speed to 30 MPG. It has also started bouncing and shaking while in reverse. I am extremely concerned about the safety threats and lack of consistency when taking it to be repaired.

The Google/Android (IHU) electrical system controls the entire car: brakes, engine, safety features, AC/Heat, etc. It is unreliable after 4 repair attempts. Problems started date of delivery (9/6/22) & have been ongoing. The ones that directly affect safety are the auto braking activating without cause, blind spot warning missing motorcycles, lane keeping will pull car towards a hazard in middle of road when you swerve to avoid it and the Google/Android system in general malfunctioning. I live in south Florida and I can assure you that air conditioning is a safety concern, especially in people like me who have medical conditions in which excessive heat exposure can result in an ER visit. My AC has failed upon starting the car as well as following the rebooting of the Google/Android system. The rebooting of the system must be done whenever the system malfunctions & it is wise to pull off the road to do it because everything but engine shuts down during the procedure. I have had to do this several times sitting off the side of the road & the system still wasn't working. It is not safe to have to pull off road so frequently. The automatic braking was particularly frightening, as both I and the car in front of me were both slowing for a stoplight, there was at least 5 car lengths between us & the distance between us was not narrowing. My car suddenly braked. Had someone been close behind me they would likely have rear-ended my car. They might have also assumed I brake-checked them & reacted with anger. Requested Volvo corporate involvement for 4th repair attempt & IHU was replaced. System began malfunctioning again, but blind spot worked. The Google system is apparently unstable, as the 2nd loaner car's backup camera & cross traffic warning froze & failed to alert. Dates: 9-6-22 to 1-25-23 (date they took car for repair try #5). About 4000 miles on it. Volvo says they can't replicate concerns. I have video of some malfunctions & sent to dealer.

Picked the vehicle up from dealership, rapidly received errors in May 2022. Errors as follows; Blind Spot Sensor service required, rear auto brake reduced functionality, park assist system reduced functionality, vehicle had less that 15 miles. A different incident in May, the AC wouldn’t work and had to shut down and reset screen. July 2022, car would not start with either key, confirmed both keys working. Would not recognize key or respond to app, eventually radio would come on but car wouldn’t crank. Dealership updated software. August 2022, GPS kept dropping and continued issues with electrical, TCAM module replaced.

The vehicle is basically new and I have only had it a few months. It has already been with the dealer three times because of technical/computer/infotainment issues. The dealer had the vehicle for about a week on each occasion. Today, I started to break so I could turn the car around and park it in the parking lot. I was moving very slowly, as you would expect in such a case. However, the car didn't stop but instead lurched forward in full throttle causing me to crash into a breezeblock wall. The automatic warning system did not sound and the crash detection system never engaged. I haven't been in an accident for 30 years and was not distracted when this happened. If the vehicle hadn't already had issues, I would accept user error as the problem, however in light of the car's history, I have doubts.

The car is only a few months old with less than 10k miles. After parking the car for about 2 hrs, came back and the battery was completely dead. This left me and my family stranded unexpectedly. After jumping the car, a warning displayed "Stop Safely, 12 V Battery Critical Charging Fault". I decided to try to make the short drive home as I was stranded with my family otherwise, the vehicle was in a limp home "turtle mode" which was not safe. The acceleration was surging unexpectedly and without warning. I realize that there was a warning not to drive, however I didn't have a lot of good options given the electrical failure. Also, in thinking back, there was a warning sometime in the last month regarding collision detection that needed to be fixed, but warning went away. In researching this issue online, seems that there are other complaints similar in nature (11472450, 11469166).

Started car after driving an hour, and having it sit 2.5 hours. Center panel was very dim and no air out of vents despite leaving air on when turned off. Error Message that cooling infotainment system. Audio sound for turn signal also not working Had to drive/leave. Left and found somewhere safe to pull over turn car off and sit. After 10+min no change. Drove home 60miles with no AC, cruise control or other safety features, or sounds w blinkers. At home, the beeeping for 360 camera and red/orange lights to help backup/part not functioning. The backup Light was. Car felt a little jerky during trip. After 4+ hours it appeared to be functioning. When restarted Car is 5-6 weeks old with 346 miles on it Including the 100+ from Saturday. Did not make a planned drive Sunday as did not feel it was safe. Verified all software/apps up to date Vm left for service on Saturday will follow up on opening today.